Cableado Electrico Toyota Tundra 2003
Cableado Electrico Toyota Tundra 2003
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . A . . . . 2
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . C . . . . 12
ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . D . . . . 17
RELAY LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . F . . . . 20
SYSTEM CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . H . . . . 55
2002
All rights reserved. This book may not be
reproduced or copied, in whole or in part, without
the written permission of Toyota Motor
Corporation.
1
2003 TOYOTA TUNDRA (EWD491U)
HOW TO USE THIS MANUAL B
The actual wiring of each system circuit is shown from the point where the power
source is received from the battery as far as each ground point. (All circuit
diagrams are shown with the switches in the OFF position.)
When troubleshooting any problem, first understand the operation of the circuit
where the problem was detected (see System Circuit section), the power source
supplying power to that circuit (see Power Source section), and the ground points
(see Ground Point section). See the System Outline to understand the circuit
operation.
3
2003 TOYOTA TUNDRA (EWD491U)
B HOW TO USE THIS MANUAL
[A] ∗ The system shown here is an EXAMPLE ONLY. It is different to the actual
circuit shown in the SYSTEM CIRCUITS SECTION.
STOP LIGHT
FROM POWER SOURCE SYSTEM (SEE PAGE 66)
,,,,,,,,,,
,,,,,,,,,,
,,,,,,,,,,
,,,,,,,,,,
15A 7. 5A
STOP GAUGE
,,,,,,,,,,
,,,,,,,,,, 4 R–L
,,,,,,,,,,
2
IB
,,,,,,,,,, ,,,,
@@@@
ÀÀÀÀ
[B] 1
,,,,,,,,,,
[C]
3 IB
@@@@
ÀÀÀÀ
,,,,
7 3C
@@@@
ÀÀÀÀ
,,,,
@@@@
ÀÀÀÀ
,,,, [G]
@@@@
ÀÀÀÀ
,,,,
@@@@
ÀÀÀÀ
,,,,
R (W/G)
L (S/D)
W–R
@@@@
ÀÀÀÀ
,,,,
15 3C
R–L
4
2
C7
REAR LIGHTS
S6 WARNING LIGHT
STOP LIGHT SW [COMB. METER]
14 IE1 [E] 13
1
[D]
G–W
[H]
L (S/D)
G–W
TO ABS ECU I5
[F]
Y–G
G–W
L4
7 8 LIGHT FAILURE SENSOR 4
DELAY
CIRCUIT
2 1 11
G–R
[I]
G
1 G–R
BV1 B18 [J] [K]
G–R
G–R
(SHIELDED)
[REAR COMB. LIGHT RH]
4 4 2
H17
W–B
STOP LIGHT RH
STOP LIGHT RH
3 3
R7
R6
W–B
W–B
W–B
1 W–B
BV1 B18
W–B
BO [M] BL
50 [N]
4
2003 TOYOTA TUNDRA (EWD491U)
B
[A] : System Title [I] : Indicates the wiring color.
[B] : Indicates a Relay Block. No shading is used and Wire colors are indicated by an alphabetical code.
only the Relay Block No. is shown to distinguish it B = Black W = White BR = Brown
from the J/B
L = Blue V = Violet SB = Sky Blue
Example: Indicates Relay Block No.1
R = Red G = Green LG = Light Green
[C] : ( ) is used to indicate different wiring and P = Pink Y = Yellow GR = Gray
connector, etc. when the vehicle model, engine
type, or specification is different. O = Orange
[D] : Indicates related system. The first letter indicates the basic wire color and the
second letter indicates the color of the stripe.
[E] : Indicates the wiring harness and wiring harness
connector. The wiring harness with male terminal is Example: L–Y
shown with arrows ( ).
Outside numerals are pin numbers.
L Y
(Blue) (Yellow)
[J] : Indicates a wiring Splice Point (Codes are ”E” for the
Engine Room, ”I” for the Instrument Panel, and ”B”
for the Body).
Female Male ( )
,,,,
Example:
Example: Numbered in order Numbered in order
,,,,
,,,,3C indicates from upper left to
lower right
from upper right to
lower left
,,,,
,,,,
that it is inside
Junction Block
,,,,No.3
,,,,
Female Male
[M] : Indicates a ground point.
[H] : When 2 parts both use one connector in common, The first letter of the code for each ground point(s)
the parts connector name used in the wire routing indicates the component’s location, e.g, ”E” for the
section is shown in square brackets [ ]. Engine Compartment, ”I” for the Instrument Panel
and Surrounding area, and ”B” for the Body and
Surrounding area.
[N] : Page No.
5
2003 TOYOTA TUNDRA (EWD491U)
B HOW TO USE THIS MANUAL
[O] SYSTEM OUTLINE
Current is applied at all times through the STOP fuse to TERMINAL 2 of the stop light SW.
When the ignition SW is turned on, current flows from the GAUGE fuse to TERMINAL 8 of the light failure sensor, and also flows
through the rear lights warning light to TERMINAL 4 of the light failure sensor.
STOP LIGHT DISCONNECTION WARNING
When the ignition SW is turned on and the brake pedal is pressed (Stop light SW on), if the stop light circuit is open, the current
flowing from TERMINAL 7 of the light failure sensor to TERMINALS 1, 2 changes, so the light failure sensor detects the
disconnection and the warning circuit of the light failure sensor is activated.
As a result, the current flows from TERMINAL 4 of the light failure sensor to TERMINAL 11 to GROUND and turns the rear lights
warning light on. By pressing the brake pedal, the current flowing to TERMINAL 8 of the light failure sensor keeps the warning
circuit on and holds the warning light on until the ignition SW is turned off.
@@@
ÀÀÀ
,,,
,,,
[S] @@@
ÀÀÀ
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
@@@
ÀÀÀ
Code See Page Junction Block and Wire Harness (Connector Location)
IB 20 Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
3C 22 Instrument Panel Wire and J/B No.3 (Instrument Panel Left Side)
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
IE1 42 Floor Wire and Instrument Panel Wire (Left Kick Panel)
BV1 50 Luggage Room Wire and Floor Wire (Luggage Compartment Left)
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I5 44 Cowl Wire B18 50 Luggage Room Wire
6
2003 TOYOTA TUNDRA (EWD491U)
B
[P] : Indicates values or explains the function for reference during troubleshooting.
[Q] : Indicates the reference page showing the position on the vehicle of the parts in the system circuit.
Example : Part ”L4” (Light Failure Sensor) is on page 36 of the manual.
∗ The letter in the code is from the first letter of the part, and the number indicates its order in parts
Á
starting with that letter.
Example : L 4
[R] : Indicates the reference page showing the position on the vehicle of Relay Block Connectors in the system circuit.
Example : Connector ”1” is described on page 18 of this manual and is installed on the left side of the instrument
panel.
[S] : Indicates the reference page showing the position on the vehicle of J/B and Wire Harness in the system circuit.
Example : Connector ”3C” connects the Instrument Panel Wire and J/B No.3. It is described on page 22 of this
manual, and is installed on the instrument panel left side.
[T] : Indicates the reference page describing the wiring harness and wiring harness connector (the female wiring
harness is shown first, followed by the male wiring harness).
Example : Connector ”IE1” connects the floor wire (female) and Instrument panel wire (male). It is described on
page 42 of this manual, and is installed on the left side kick panel.
[U] : Indicates the reference page showing the position of the ground points on the vehicle.
Example : Ground point ”BO” is described on page 50 of this manual and is installed on the back panel center.
[V] : Indicates the reference page showing the position of the splice points on the vehicle.
Example : Splice point ”I5” is on the Cowl Wire Harness and is described on page 44 of this manual.
7
2003 TOYOTA TUNDRA (EWD491U)
B HOW TO USE THIS MANUAL
The ground points circuit diagram shows the connections from all major parts to the respective ground points. When
troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify
the problem ground quickly. The relationship between ground points ( EA , IB and IC shown below) can also be
checked this way.
I GROUND POINT
W–B W–B A W–B HEATER CONTROL
FAN MAIN RELAY 5 CIGARETTE LIGHTER ASSEMBLY
W–B
E3
W–B A HEATER SERVO
FAN MAIN RELAY 5 O/D MAIN SW I6 MOTOR AMPLIFIER
W–B W–B A A
A/C FAN RELAY NO.2 5 E3 CLOCK I6 BLOWER SW
W–B A A W–B
A/C FAN RELAY NO.3 5 E3 PARKING BRAKE SW
J1
W–B JUNCTION
,,,,
RADIATOR FAN MOTOR E3 CONNECTOR
,,,, 7
,,,,
RETRACT CONTROL W–B W–B
E2 3B COMBINATION METER
RELAY
,,,,
,,,,
W–B W–B
E4 HORN SW [COMB. SW]
,,,,
RETRACT MOTOR RH
W–B
,,,, 7 W–B
DIMMER SW
,,,,
RETRACT MOTOR LH E5 3C I2 [COMB. SW]
W–B
,,,, 1 W–B
,,,,
FRONT TURN SIGNAL W–B FRONT SIDE MARKER CRUISE CONTROL
E4 E4 3D
LIGHT RH LIGHT RH MIRROR SW
,,,,
,,,,
3
W–B
W–B W–B W–B REMOTE CONTROL
E5 FRONT SIDE MARKER 3F
PARKING LIGHT RH
,,,,
LIGHT LH MIRROR SW
,,,,
W–B 13 W–B
FRONT TURN SIGNAL W–B BRAKE FLUID LEVEL
,,,,
E4 E6 WARNING SW 3G TURN SIGNAL FLASHER
LIGHT LH
W–B W–B
,,,, 5 W–B
,,,,
,,,,
W–B 2 6
DOOR LOCK CONTROL W–B W–B LIGHT CONTROL SW
B4 IA1 I4 3E I2 [COMB. SW]
SW RH
W–B
W–B
I5 ID1 B5 MASTER SW
RELAY
POWER WINDOW
B5 CONTROL RELAY
EA
W–B
W–B
W–B W–B 8
ELECTRICAL IDLE−UP DOOR LOCK CONTROL
CUT RELAY (M/T) I4 IB1 I8 B5
SW
W–B
W–B
W–B
A/C AMPLIFIER DOOR LOCK MOTOR LH
W–B (4A–GZE)
I5 FUEL CONTROL SW
4 4
BR W–B 3 W–B
RADIO AND PLAYER 4 4 I5 IC3 WOOFER AMPLIFIER
W–B BR
HEATER RELAY 4 COMBINATION METER
BR 5 BR BR BR
AUTO ANTENNA
MOTOR BA1 4 I3 I3 COMBINATION METER
W–B
BR
BR
FUEL SENDER
4
W–B
IB IC
∗ The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
8
2003 TOYOTA TUNDRA (EWD491U)
B
The ”Current Flow Chart” section, describes which parts each power source (fuses, fusible links, and circuit breakers)
transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system
are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully
understood.
10A ECU–B
Short Pin 2 2
7.5A DOME
15A EFI
BATTERY
3 EA2 1 EA1 W 7.5A DOME R
I2 1 1
50A MAIN
W
W
B
B W 7 W W
E7 2 2 EB1 I2 I2 1
W–B
W
B
1
7.5A AM2 W–R 6
B
E7 2 2 EB1
2 1
W–R
15A HAZ–RADIO W
2 TAIL
RELAY
B
INJECTION RELAY I8 4 3
B–O 1 3 W–B 8 4 IGNITION SW
2 2
AM2
AM1
1 1
G–W
B 2 4 B–W
E7 2 2
1 G
ACC
IG2
IG1
B 1 3 W–B
2 2 3 2
∗ The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION.
9
2003 TOYOTA TUNDRA (EWD491U)
B HOW TO USE THIS MANUAL
K CONNECTOR LIST
I14 I15 [A] I16 J1 J2
DARK GRAY GRAY BLACK
A A A B B D D
1 2 1 2 1 2 A A A A A A B CC CD D
6 7 8
[B]
J3 J4 K1 K2 L1
DARK GRAY
A A A
A B B DD 1
A A A A A 1 2
A A B CC CDD 1 2
L2 L3 L4 M1 M2 M3 [C]
GRAY BLACK
1 2 3 4 5 1 2
1 1 6 7 8 9 101112
2 1 3 45 6 78 1 2
2 3 4
[D]
M4 N1 N2 O1 O2
GRAY GRAY BLACK DARK GRAY
1 2 3 4 1
1 2 3 5 6 1 2 1
7 8 9 10
[A] : Indicates connector to be connected to a part. (The numeral indicates the pin No.)
[B] : Junction Connector
Indicates a connector which is connected to a short terminal.
Junction Connector
10
2003 TOYOTA TUNDRA (EWD491U)
B
A2 A/C Condenser Fan Motor 90980–11237 D5 Diode (Key Off Operation) 90980–10962
A3 A/C Condenser Fan Relay 90980–10940 D6 Diode (Luggage Compartment Light) 90980–11608
D7 Door Lock Control Relay 90980–10848
ÁÁ ÁÁ
A/C Triple Pressure SW (A/C Dual and
A4 Single Pressure SW) 90980–10943
D8 Door Courtesy Light LH
ÁÁ ÁÁ
90980–11148
[A]
A5 A/T Oil Temp. Sensor [B] [C]
90980–11413 D9 Door Courtesy Light RH
A12 Auto Antenna Motor 90980–11194 D16 Door Key Lock and Unlock SW LH
90980–11170
90980–11194 D17 Door Key Lock and Unlock SW RH
Not all of the above part numbers of the connector are established for the supply. In case of ordering a connector
or terminal with wire, please confirm in advance if there is supply for it using “Parts Catalog News” (published by
Parts Engineering Administration Dept.).
11
2003 TOYOTA TUNDRA (EWD491U)
C TROUBLESHOOTING
To Ignition SW VOLTAGE CHECK
IG Terminal
(a) Establish conditions in which voltage is present at the check
point.
Example:
Fuse [A] – Ignition SW on
[B] – Ignition SW and SW 1 on
[A] [C] – Ignition SW, SW 1 and Relay on (SW 2 off)
(b) Using a voltmeter, connect the negative lead to a good ground
point or negative battery terminal, and the positive lead to the
SW 1 Voltmeter connector or component terminal.
This check can be done with a test light instead of a voltmeter.
[B]
Relay
[C]
SW 2 Solenoid
SW
If the circuit has diodes, reverse the two leads and check
again.
When contacting the negative lead to the diode positive side
and the positive lead to the negative side, there should be
continuity.
Ohmmeter When contacting the two leads in reverse, there should be no
continuity.
Diode
12
2003 TOYOTA TUNDRA (EWD491U)
C
To Ignition SW FINDING A SHORT CIRCUIT
IG Terminal
(a) Remove the blown fuse and disconnect all loads of the fuse.
(b) Connect a test light in place of the fuse.
(c) Establish conditions in which the test light comes on.
Test Light Fuse Case Example:
[A] – Ignition SW on
[B] – Ignition SW and SW 1 on
Short [A] [C] – Ignition SW, SW 1 and Relay on (Connect the
Relay) and SW 2 off (or Disconnect SW 2)
(d) Disconnect and reconnect the connectors while watching the
SW 1 test light.
The short lies between the connector where the test light
Short [B] stays lit and the connector where the light goes out.
Disconnect (e) Find the exact location of the short by lightly shaking the
Disconnect problem wire along the body.
Pull Up Pull Up
13
2003 TOYOTA TUNDRA (EWD491U)
C TROUBLESHOOTING
Reference: HOW TO REPLACE TERMINAL
(with terminal retainer or secondary locking device)
10 1. PREPARE THE SPECIAL TOOL
”Case 1”
Raise the terminal retainer up to the temporary lock
[Retainer at Full Lock Position] position.
Terminal
Stopper Retainer
14
2003 TOYOTA TUNDRA (EWD491U)
C
Tool
Tab
Tab
”Case 1”
Type where terminal retainer is pulled
up to the temporary lock position (Pull
Type).
Insert the special tool into the terminal
retainer access hole (Mark) and pull
the terminal retainer up to the
temporary lock position.
HINT : The needle insertion position varies
Retainer according to the connector’s shape
at Full Lock Position (Number of terminals etc.), so check
the position before inserting it.
Retainer
at Temporary Lock Position
[Male] [Female]
”Case 2”
Type which cannot be pulled as far as
Example: Terminal Retainer Power Lock insert the tool straight into
(Case 2) the access hole of terminal retainer as
shown.
Tool Tool
Press Down
[Male] Press Down [Female]
15
2003 TOYOTA TUNDRA (EWD491U)
C TROUBLESHOOTING
Push the terminal retainer down to the temporary lock position.
Retainer at
Full Lock Position
Retainer at
Temporary Lock Position
[Male] [Female]
Locking Lug (c) Release the locking lug from terminal and pull the terminal out
from rear.
Tool
16
2003 TOYOTA TUNDRA (EWD491U)
ABBREVIATIONS D
ABBREVIATIONS
The following abbreviations are used in this manual.
2WD = Two Wheel Drive Vehicles
4WD = Four Wheel Drive Vehicles
A/C = Air Conditioning
A/T = Automatic Transmission
ABS = Anti–Lock Brake System
ACIS = Acoustic Control Induction System
ADD = Automatic Disconnecting Differential
COMB. = Combination
ECU = Electronic Control Unit
ESA = Electronic Spark Advance
ETCS–i = Electronic Throttle Control System–intelligent
EVAP = Evaporative Emission
J/B = Junction Block
LH = Left–Hand
M/T = Manual Transmission
O/D = Overdrive
R/B = Relay Block
RH = Right–Hand
SFI = Sequential Multiport Fuel Injection
SRS = Supplemental Restraint System
SW = Switch
TEMP. = Temperature
TVIP = TOYOTA Vehicle Intrusion Protection
VSV = Vacuum Switching Valve
w/ = With
w/o = Without
∗ The titles given inside the components are the names of the terminals (terminal codes) and are not treated as being
abbreviations.
17
2003 TOYOTA TUNDRA (EWD491U)
E GLOSSARY OF TERMS AND SYMBOLS
BATTERY GROUND
Stores chemical energy and The point at which wiring attaches to
converts it into electrical energy. the Body, thereby providing a return
Provides DC current for the auto’s path for an electrical circuit; without a
various electrical circuits. ground, current cannot flow.
CIGARETTE LIGHTER
An electric resistance heating 2. DOUBLE
element. FILAMENT
18
2003 TOYOTA TUNDRA (EWD491U)
E
RELAY SPEAKER
Basically, an electrically operated An electromechanical device which
1. NORMALLY switch which may be normally creates sound waves from current
CLOSED closed (1) or open (2). flow.
Current flow through a small coil
creates a magnetic field which either
opens or closes an attached switch.
2. NORMALLY SWITCH, MANUAL
OPEN Opens and closes
circuits,
i it thereby
th b
1. NORMALLY stopping (1) or
OPEN allowing (2) current
flow.
RELAY, DOUBLE THROW
A relay which passes current 2. NORMALLY
through one set of contacts or the CLOSED
other.
SHORT PIN
WIRES
Used to provide an unbroken
Wires are always drawn as
connection within a junction block. (1) NOT straight lines on wiring
CONNECTED diagrams.
Crossed wires (1) without a
black dot at the junction
j are
nott joined;
j i d
SOLENOID crossed wires (2) with a
An electromagnetic coil which forms black dot or octagonal ( )
a magnetic field when current flows, (2) SPLICED mark at the junction are
to move a plunger, etc. spliced (joined)
connections.
19
2003 TOYOTA TUNDRA (EWD491U)
F RELAY LOCATIONS
[Engine Compartment]
[Instrument Panel]
20
2003 TOYOTA TUNDRA (EWD491U)
F
2 : Engine Room R/B Engine Compartment Left (See Page 20)
21
2003 TOYOTA TUNDRA (EWD491U)
F RELAY LOCATIONS
,,,
,,, Driver Side J/B and
,,,: Integration Relay Lower Finish Panel (See Page 20)
22
2003 TOYOTA TUNDRA (EWD491U)
F
23
2003 TOYOTA TUNDRA (EWD491U)
F RELAY LOCATIONS
[Driver Side J/B and Integration Relay Inner Circuit]
(w/o Daytime Running Light)
24
2003 TOYOTA TUNDRA (EWD491U)
MEMO
25
2003 TOYOTA TUNDRA (EWD491U)
F RELAY LOCATIONS
,,,
,,, Driver Side J/B and
,,,: Integration Relay Lower Finish Panel (See Page 20)
26
2003 TOYOTA TUNDRA (EWD491U)
F
27
2003 TOYOTA TUNDRA (EWD491U)
F RELAY LOCATIONS
[Driver Side J/B and Integration Relay Inner Circuit]
(w/ Daytime Running Light)
28
2003 TOYOTA TUNDRA (EWD491U)
MEMO
29
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[2UZ–FE]
40
2003 TOYOTA TUNDRA (EWD491U)
G
Connector Joining Wire Harness and Wire Harness
EA1 BLACK EB1 BLACK
1 2 2 1
3 4 4 3
1 2 2 1
3 3
4 5 5 4
6
7 8 6
8 7
1 2 3 3 2 1 1 2 3 1 2 3 3 2 1
3 2 1
4 5 6 6 5 4 4 5 6 6 5 4
41
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[5VZ–FE]
42
2003 TOYOTA TUNDRA (EWD491U)
G
Connector Joining Wire Harness and Wire Harness
EA1 BLACK EB1 BLACK
1 2 2 1
3 4 4 3
1 2 2 1
3 3
4 5 5 4
6
7 8 6
8 7
1 2 2 1 1 2 2 1 3 2 1
1 2 3
3 4 5 6 6 5 4
3
43
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
44
2003 TOYOTA TUNDRA (EWD491U)
G
Connector Joining Wire Harness and Wire Harness
IA1 YELLOW IA4
2 1
1 2
2 3 3 2
1 4 4 1
6 7 8 9 10 11 11 10 9 8 7 6
5 12 12 5
14 15 16 17 18 19 20 20 19 18 17 16 15 14
13 21 21 13
22 23 24 25 26 26 25 24 23 22
IA5 IB2
1 2 3 4 5 6 7 8 9 9 8 7 6 5 4 3 2 1 1 2 3 4 4 3 2 1
10 11 12 13 14 15 16 17 18 18 17 16 15 14 13 12 11 10
1 2 1 2 2 1
2 1 1 2 3 4 5 5 4 3 2 1
3 4 5 6 7 7 6 5 4 3 6 7 8 9 10 10 9 8 7 6
8 9 10 11 12
12 11 10 9 8
45
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
46
2003 TOYOTA TUNDRA (EWD491U)
G
Connector Joining Wire Harness and Wire Harness
47
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[Access Cab]
48
2003 TOYOTA TUNDRA (EWD491U)
G
Connector Joining Wire Harness and Wire Harness
BA1 BB1 BLACK BB2
1 2 2 1
1 1 3 4 5 6 6 5 4 3
1 2 2 1
2 2 3 4 5 6 7 7 6 5 4 3
8 9 10 11 12
12 11 10 9 8
2 1 1 2 3 3 2 1
1 1 1 2
3 4 4 3 4 5 6 6 5 4
2 2
1 2 3 3 2 1
1 2 3 4 5 5 4 3 2 1 1 2 3 4 4 3 2 1
4 5 6 6 5 4
1 2 2 1
1 2 2 1 4 3 3 2 1
3 4 1 2 3
3 4 4 3
49
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
: Location of Ground Points
[Standard Cab]
50
2003 TOYOTA TUNDRA (EWD491U)
G
Connector Joining Wire Harness and Wire Harness
BA1 BB1 BLACK BB2
1 2 2 1
1 1 3 4 5 6 6 5 4 3
1 2 2 1
2 2 3 4 5 6 7 7 6 5 4 3
8 9 10 11 12
12 11 10 9 8
1 2 2 1
1 2 2 1
1 1 1 2 2 1 4 3
3 4 4 3 3 4
3 4 4 3
2 2
BK2
BLACK GRAY
3 2 1
1 2 3
51
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
: Location of Connector Joining Wire Harness and Wire Harness
52
2003 TOYOTA TUNDRA (EWD491U)
G
Connector Joining Wire Harness and Wire Harness
(w/ Power Seat) BI1 BJ1
1 2 2 1 1 2 2 1
3 4 4 3
53
2003 TOYOTA TUNDRA (EWD491U)
MEMO
54
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[2UZ–FE]
30
2003 TOYOTA TUNDRA (EWD491U)
G
Position of Parts in Engine Compartment
[2UZ–FE]
31
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[5VZ–FE]
32
2003 TOYOTA TUNDRA (EWD491U)
G
Position of Parts in Engine Compartment
[5VZ–FE]
M 1 Mass Air Flow Meter W 2 Washer Motor and Washer Level Sensor
W 3 Water Temp. Sender
N 1 Noise Filter W 4 Wiper Motor
33
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
34
2003 TOYOTA TUNDRA (EWD491U)
G
Position of Parts in Instrument Panel
U 1 Unlock Warning SW
35
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Body
[Access Cab]
36
2003 TOYOTA TUNDRA (EWD491U)
G
Position of Parts in Body
[Standard Cab]
37
2003 TOYOTA TUNDRA (EWD491U)
G ELECTRICAL WIRING ROUTING
Position of Parts in Seat
38
2003 TOYOTA TUNDRA (EWD491U)
MEMO
39
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM CIRCUITS H
55
2003 TOYOTA TUNDRA (EWD491U)
POWER SOURCE
2 1 1 2 1 2
40A AM1
1 2 W W
2
7. 5A ALT–S 5A ECU–B
SHORT PIN
2 1 1 2 B 1 2 W–R
2 2
20A RADIO
1 2
2 1 1 2 W–R W–G
2
50A J/B
1 2 W–G
2
J1
1 2 JUNCTION
CONNECTOR
1 2
(* 2)
B
20A HAZ
R–B
B–L
(* 1)
1 2 (* 4)
30A TOWING
DIMMER RELAY
1 2 1 2
2
R–B
R–B
(* 4)
(* 3)
5 W–G(* 3)
3 2
H–LP RELAY 2 4 G(*3)
5 3 R–B 2
2
BATTERY
(* 3)
1 2
10A ETCS(*5)
15A ETCS(*6)
1 2
56
2003 TOYOTA TUNDRA (EWD491U)
15A PWR OUTLET 1
A22
B 1 2 ACC CUT RELAY
2 G–Y 1 2 W–R
(*5) (* 5)
15A PWR OUTLET 2 8
3 4 L–O(* 5)
1 3 IA4
L–O(* 5)
L–R
(*5)
10A A/C
1 15A ACC
L–R 1 2
2 1I
L–R
9 IA4
(* 6)
5A ECU IG
L–R
(*5) 5A TURN
ACC 3 L–R
(* 6)
W 2 AM1 IG1 4 B–Y
10A GAUGE
20A 4WD
ST2 8 B–W 1I
(* 5) 4 5A IGN
G–B
1I
I23 (*6)
IGNITION SW
30A POWER
2
W–G W–G 1 2
1K
7. 5A OBD
5A CARGO LP
15A TAIL
B–W
(* 5)
10A HEAD RH
1 2
10A HORN
10A HEAD LH
R–B 1 3
2
(*4)
3 5 B–W
10A HEAD RL 2 2
(* 6)
(*6)
W
1 2
CONNECTOR
2 1 C
JUNCTION
2
W–G(* 3) ST RELAY
10A HEAD LL
J2
C
G(* 3) 1 3
2
5A STA 3
B–W
1I
(* 6)
B–W
(*5)
* 1: TOWING PACKAGE
* 2: EXCEPT TOWING PACKAGE
* 3: W/ DAYTIME RUNNING LIGHT
* 4: W/O DAYTIME RUNNING LIGHT
* 5: 2UZ–FE
* 6: 5VZ–FE
57
2003 TOYOTA TUNDRA (EWD491U)
POWER SOURCE
SERVICE HINTS
HEATER RELAY
5–3 : Closed with ignition SW on and heater blower SW on
H–LP RELAY
5–3 : Closed with light control SW at HEAD position or dimmer SW at FLASH position
Closed with engine running and parking brake lever released (w/ daytime running light)
I23 IGNITION SW
2–3 : Closed with ignition key at ACC or ON position
2–4 : Closed with ignition key at ON or ST position
7–6 : Closed with ignition key at ON or ST position
DIMMER RELAY (w/ DAYTIME RUNNING LIGHT)
3–5 : Closed with HEAD relay on and dimmer SW at HIGH or FLASH position
: PARTS LOCATION
Code See Page Code See Page Code See Page
A22 34 31 (2UZ–FE) 31 (2UZ–FE)
J1 J2
I23 35 33 (5VZ–FE) 33 (5VZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1I
26 (*1)
Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1K
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
58
2003 TOYOTA TUNDRA (EWD491U)
MEMO
59
2003 TOYOTA TUNDRA (EWD491U)
STARTING (5VZ–FE)
ACC
ST2 8 G–B
I23
IGNITION SW
W–B
I1
W–R
G–B
W
(A/T)
W–B
2 2
(M/T)
W–B
2 2
19 IE2
2 3 2
(A/T)
W–B
CLUTCH START SW
40A AM1
ST
PARK/NEUTRAL
RELAY 2 6
POSITION SW
P
5 1
1 N
C10
P1
1 9
2 2
2 2
(A/T)
B–W
P
CONNECTOR
100A ALT
30A AM2
B–W
JUNCTION
C
(M/T)
C 12 IE2
P
J2
G–R
1 1 C
B–W
(A/T)
P
2 P
3 EB1 (A/T)
A
24
P A A P
IA4
(* 2) (M/T)
B
B–W
J8
B JUNCTION
CONNECTOR
G–R
(* 1)
(* 1)
P
1 A 1 B
3 C 8 C
ST SRLY T13 C
BATTERY
M TVIP ECU
S1 A , S2 B
STARTER
60
2003 TOYOTA TUNDRA (EWD491U)
* 1 : W/ WIRELESS DOOR LOCK CONTROL
* 2 : W/O WIRELESS DOOR LOCK CONTROL
B–Y
B–W
B–Y
3 1I 2 1I
5A 10A
STA GAUGE
6 1F 7 1F
B
W–B
(M/T)
P
B–Y
(M/T)
1 7
+S IG
B
7 A
STA E3 A , E4 B
ENGINE CONTROL
MODULE
NSW
3 B
–S E
3 5 C9
CLUTCH START
CANSEL SW
(M/T)
(M/T)
W–B
W–B
P W–B W–B
I1 I1
(A/T)
P
W–B
(M/T)
A B
J23 A , J24 B
JUNCTION
CONNECTOR
A A
W–B
IE
61
2003 TOYOTA TUNDRA (EWD491U)
STARTING (5VZ–FE)
SERVICE HINTS
S1 (A), S2 (B) STARTER
Points closed with Park/Neutral position SW at P or N position and ignition SW at ST position (A/T)
Points closed with clutch start SW or clutch start cancel SW on and ignition SW at ST position (M/T)
I23 IGNITION SW
2–4 : Closed with ignition SW at ON or ST position
7–8 : Closed with ignition SW at ST position
P1 PARK/NEUTRAL POSITION SW (A/T)
6–9 : Closed with A/T shift lever in P or N position
ST RELAY
5–3 : Closed with Park/Neutral position SW at P or N position and ignition SW at ST position (A/T)
5–3 : Closed with clutch start SW or clutch start cancel SW on and ignition SW at ST position (M/T)
C9 CLUTCH START CANCEL SW (M/T)
1–3 : Closed with ignition SW on and cancel SW on
C10 CLUTCH START SW (M/T)
1–2 : Closed with clutch pedal fully depressed
: PARTS LOCATION
Code See Page Code See Page Code See Page
C9 34 J2 33 (5VZ–FE) S1 A 33 (5VZ–FE)
C10 34 J8 35 S2 B 33 (5VZ–FE)
E3 A 34 J23 A 35 T13 C 35
E4 B 34 J24 B 35
I23 35 P1 33 (5VZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1I Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I1 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
62
2003 TOYOTA TUNDRA (EWD491U)
MEMO
63
2003 TOYOTA TUNDRA (EWD491U)
STARTING (2UZ–FE)
7 AM2 IG2
ST2 8 B–W
I23 3 1I
IGNITION SW
5A
STA
6 1F
W–R
B
B
G–Y W–B
2 2 2 2
J20
JUNCTION
2 3 2 C CONNECTOR
J2
JUNCTION
ST CONNECTOR
30A 30A RELAY
AM2 ST3 C A A A
W–B
W–B
W–B
5 1
1
W–B
2 2
W–B
2 G–R
6
B–W
P P1
PARK/NEUTRAL
W–B
POSITION SW
N
3 EB1 24 IA4
9
B–W
P
B–L
(* 1)
(* 2)
B
P
I3
1 B
G–R
(*3)
(*4)
P
A
B–L 1 J18
JUNCTION 12 IE1
A M
CONNECTOR
A
S1 A , S2 B P P
STARTER
(* 4) (* 3)
BATTERY
W–B
G–R
(* 3)
EA
64
2003 TOYOTA TUNDRA (EWD491U)
* 1 : TOWING PACKAGE
* 2 : EXCEPT TOWING PACKAGE
* 3 : W/ WIRELESS DOOR LOCK CONTROL
* 4 : W/O WIRELESS DOOR LOCK CONTROL
15 IE1
B
12 C
STSW
E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
W–B
W–B
W–B
P P 8
C SRLY
(* 3) (* 3) T13 C
TVIP ECU
G–R G–R 3
C ST
(* 3) (* 3)
65
2003 TOYOTA TUNDRA (EWD491U)
STARTING (2UZ–FE)
SERVICE HINTS
S1 (A), S2 (B) STARTER
Points closed with Park/Neutral position SW at P or N position and ignition SW at ST position
I23 IGNITION SW
7–8 : Closed with ignition SW at ST position
P1 PARK/NEUTRAL POSITION SW
6–9 : Closed with A/T shift lever in P or N position
ST RELAY
5–3 : Closed with Park/Neutral position SW at P or N position and ignition SW at ST position
: PARTS LOCATION
Code See Page Code See Page Code See Page
E5 C 34 J2 31 (2UZ–FE) S1 A 31 (2UZ–FE)
E6 D 34 J18 31 (2UZ–FE) S2 B 31 (2UZ–FE)
E7 E 34 J20 35 T13 C 35
I23 35 P1 31 (2UZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1I Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I3 46 Engine Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
66
2003 TOYOTA TUNDRA (EWD491U)
MEMO
67
2003 TOYOTA TUNDRA (EWD491U)
IGNITION (2UZ–FE)
I23
IGNITION SW
LG–B
G–R
G–B
21 IE1
B–R
LG–B
G–R
G–B
B–R
B–R
B–R
B–R
W–R
1 1 3 1 3 1 3
NOISE FILTER
IGNITER AND
IGNITER AND
2
N1
30A
I3
I4
I5
AM2
4 2 4 2 4 2
1
L–W
L–W
L–B
BR
BR
BR
BR
L–W
I3
B–L(*1)
B(* 2)
BR BR BR
E5 E5 E5
L–B
BATTERY
BR
EC
68
2003 TOYOTA TUNDRA (EWD491U)
I6
BR
L–B
B–R
L–W
IGNITER AND
IGNITION COIL NO. 4
4
1
BR B–R
E5
E7
2
3
11
L–B B–L B–L
I3
IGT4
B–R
I7
BR
IGNITER AND
IGNITION COIL NO. 5
4
1
BR B–R
E5
E7
2
3
12
L–W G–W G–W
I3
IGT5
BR
L–B
B–R
I8
IGNITER AND
IGNITION COIL NO. 6
4
1
BR B–R
E5
E7
2
3
26
I3
IGT6
E7
BR
B–R
L–W
I9
IGNITER AND
IGNITION COIL NO. 7
L–B
4
1
BR B–R
E5
E7
2
3
13
I3
IGT7
I10
BR
L–B
IGNITER AND
4
1
BR B–R
2
3
10
L–W LG LG
I3
IGT8
L–W
23
L–W
IGF2
* 1 : TOWING PACKAGE
24
L–B
* 2 : EXCEPT TOWING PACKAGE
IGF1
69
IGNITION (2UZ–FE)
SERVICE HINTS
I23 IGNITION SW
7–6 : Closed with ignition SW at ON or ST position
: PARTS LOCATION
Code See Page Code See Page Code See Page
E7 34 I6 31 (2UZ–FE) I10 31 (2UZ–FE)
I3 31 (2UZ–FE) I7 31 (2UZ–FE) I23 35
I4 31 (2UZ–FE) I8 31 (2UZ–FE) N1 31 (2UZ–FE)
I5 31 (2UZ–FE) I9 31 (2UZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1I Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
E5 I3 46 Engine Wire
40 (2UZ–FE)
(2UZ FE) Engine Wire
E7
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
70
2003 TOYOTA TUNDRA (EWD491U)
MEMO
71
2003 TOYOTA TUNDRA (EWD491U)
IGNITION (5VZ–FE)
ST2
I23 4 1I
W–R
IGNITION SW
7 1J
B–R
TO COMBINATION METER
1 IE1
B–R
B–R B–R
I3 I3 I3
B–R
B–R
B–R
B–R
B
1 1 1 1
IGNITION COIL NO. 1
2 5 IE1
N1
2
2 2 2
30A
I11
I12
I13
AM2
W–G
B–R
R
B
L
2
10 2 1 9 8
I2
B
IGNITER
3 7 6 5 4
W–B
B–Y
B–L
R–L
BR
LG
BATTERY
11 10 9 2
IGT1 IGT2 IGT3 IGF
E6
ENGINE CONTROL MODULE
ED
72
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
I23 IGNITION SW
7–6 : Closed with ignition SW at ON or ST position
: PARTS LOCATION
Code See Page Code See Page Code See Page
E6 34 I12 33 (5VZ–FE) N1 33 (5VZ–FE)
I2 33 (5VZ–FE) I13 33 (5VZ–FE)
I11 33 (5VZ–FE) I23 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1I Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I3 46 Engine Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
73
2003 TOYOTA TUNDRA (EWD491U)
CHARGING
10 1F 5 1E
B–O
B–Y
W
LIGHT [COMB. METER]
CONNECTOR
CHARGE WARNING
JUNCTION
3 C
J1
C
W
B
C12
4
Y–G
(* 2)
2 2
J11
2
B–Y
JUNCTION
CONNECTOR
7. 5A ALT–S
Y–G A A Y–G
(* 1) (* 1)
A
1 7 IA5
Y–G
(* 1)
Y–G
2
140A ALT (* 3)
100A ALT (* 4)
Y–G
B–Y
B
1
2 4 B 2 B 3 B 1 A
L IG S B
B–L(* 3)
B(* 4)
BATTERY
IC REGULATOR
G1 A , G2 B
GENERATOR
74
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
G2 (B) GENERATOR
(B) 3–GROUND : 13.9–15.1 volts with engine running at 2000 rpm and 25°C (77°F)
13.5–14.3 volts with engine running at 2000 rpm and 115°C (239°F)
(B) 1–GROUND : 0–4 volts with ignition SW at ON position and engine not running
: PARTS LOCATION
Code See Page Code See Page Code See Page
C12 34 30 (2UZ–FE) J1 33 (5VZ–FE)
G2 B
30 (2UZ–FE) 32 (5VZ–FE) J11 35
G1 A
32 (5VZ–FE) J1 31 (2UZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
75
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (2UZ–FE)
B–R
W–R
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
2 1
ACC 3 L–R
2
7 AM2 IG2 6 15A
EFI NO. 1
5A ECU–B
W–R
L–R
ST2 8
2
9 IA4 17 IA5
1 I23 2
IGNITION SW
2 B–R
W–R
(*3)
B–Y
J21 A , J22 B
W–R
W–R
B–W
B–R
B–R
D A
B–Y
L–R
(* 4)
CONNECTOR
B
JUNCTION
B–W
F B
W–R
(* 3)
2 2 3 1I
2 2 2 2
2 2 3 2 3 2 3 2
C/OPN RELAY
SHORT PIN
EFI RELAY
A22
B–W
W–L
30A 5A ACC CUT
AM2 STA RELAY
1 4 1 5 1 5 1
1
2 2 2 2
L–O
2 6 1F
W–B
W–L
G–Y
Y
B–L
(* 1)
(* 2)
B
26 IA4
8 IE1
A
J18
JUNCTION
CONNECTOR
BATTERY
A
Y
W–B
G–Y
W–L
G–Y
B
W–B
EA
76
2003 TOYOTA TUNDRA (EWD491U)
B–R B–R
1
* 1: TOWING PACKAGE
* 2: EXCEPT TOWING PACKAGE
* 3: W/ DOOR LOCK CONTROL 10A
* 4: W/O DOOR LOCK CONTROL 7. 5A
EFI OBD
NO. 2
2 2 4 1B
B–R B–R
B–Y B–Y
B–W B–W
B–L
B–W
R
B–W
18 IA4 L–W
B–L
W–L
L–W
8 EA1 2 2
Y
CONNECTOR
CONNECTOR
2 3 B A
F/PMP RELAY
JUNCTION
JUNCTION
B A R
4 16 15
B–L
CONNECTOR 3
J14 A , J15 B
J1
J8
B A BAT WFSE
H A
DATA LINK
CONNECTOR
L–O
1 5
JUNCTION
CG SG TC SIL
D6
2 2 4 5 13 7
H B
5 IA4
W–L
W–L
PRESSURE SENSOR)
W–G
W–B
BR
W
L–O
1
L–O
L–B
VSV (VAPOR
25 IE1
2
4
FUEL PUMP
L–W
W–L
1
R
M
FUEL PUMP
BR
RESISTOR
F10
J14 A , J15 B
5
F B
CONNECTOR
W–B
F5
JUNCTION
W
2
12 BB1 G A W–G
L–W L–W
Y Y
W–L W–L
G–Y G–Y
R
W–B
B B
A
J3 A W–B
JUNCTION
CONNECTOR
IF EC
77
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (2UZ–FE)
21
B–R B–R
B–R
IE1
* 5 : SHIELDED
4 1I 7 1J
5A B–R B–R
IGN E6 E6
B–R
B–R
B–R
B–R
B–R
B–Y 6 1K 11 1F
B–W B–W
INJECTOR NO. 1
INJECTOR NO. 3
INJECTOR NO. 5
INJECTOR NO. 7
1 1 1 1
B–O
CONNECTOR
B–L B
B–R
B–Y
JUNCTION
I14
I16
I18
I20
2 2 2 2
15 IA4 6 IA4
J5
B
23 IE1
L–W
L–R
G
R
B–O
L
L–W
B–R
B–Y
B–L
19 A 33 E 8 A 3 A 9 A 1 E 3 E 5 E 6 C
WFSE FPR MREL BATT IGSW #1 #3 #5 #7
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
SIL TC CCV FC ACCR STSW STA NSW STAR +B2 +B HT2A OX2A
18 A 20 A 27 E 10 A 15 E 12 C 17 E 16 E 9 D 1 A 2 A 33 D 22 D
W–L
W–L
W–G
W–B
W–B
L–W
G–Y
W
(* 5)
CONNECTOR
CONNECTOR
I5 (* 5)
JUNCTION
JUNCTION
D D
16 IE1 15 IE1
W–L
Y–G
J5
J8
W
FROM PARK/NEUTRAL
FROM PARK/NEUTRAL
TO PARK/NEUTRAL
D D
POSITION SW
W–G
L–W
W
POSITION SW
POSITION SW
W
HEATED OXYGEN SENSOR
W–G
1 3
(BANK 2 SENSOR 1)
L–W HTR OX
Y
+B E1
W–L
2 4
H5
B–W
G–Y
R
R R R
I3
B
B–W
78
2003 TOYOTA TUNDRA (EWD491U)
H3
R
(* 5)
B–R
B–R
B–R
B–W
HEATED OXYGEN SENSOR I15
(BANK 1 SENSOR 1) INJECTOR NO. 2
2
1
2
1
R G–Y W B–R
2 E
4 D
I3
+B
#2
E6
HTL
HT1A
(* 5)
I17
B–R
4
3
B–W B INJECTOR NO. 4
23 D
I3
E1
2
1
R–B B–R B–R
OX2
OX1A
4 E
#4
E6
3 IE1
H6
B–W
HEATED OXYGEN SENSOR I19
(BANK 2 SENSOR 2) INJECTOR NO. 6
2
1
2
1
R Y–B Y–B Y B–R
25 D
3 D
I3
+B
#6
HT2B
HTR2
(* 5)
I21
4
3
B–W W W INJECTOR NO. 8
21 D
I3
E1
2
1
R–W B–R
OX2B
OXR2
5 C
#8
H4
B–W
HEATED OXYGEN SENSOR I3
(BANK 1 SENSOR 2)
B–R
2
1
R R–Y R–Y COIL NO. 1
5 D
I3
+B
3
1
G–R B–R
HTL2
HT1B
9 E
E7
(* 5)
IGT1
4
3
2
B–W B B L–B
29 D
I3
E1
OXL2
OX1B
B–R
I4
R
ENGINE CONTROL MODULE
B–W
IGNITER AND IGNITION
COIL NO. 2
I3
I3
3
1
LG–B B–R
8 E
E7
IGT2
BR
BR
2
L–W
BR BR BR BR
1 C
I3
I3
I3
E1
EC
I5
IGNITER AND IGNITION
BR
BR
L–W
COIL NO. 3
3
1
G–B B–R
25 E
I3
E7
IGT3
(*5)
2
L–W
I3
BR BR
E4
E8
3 EC2
B–R
K2 I6
KNOCK (* 5) (* 5)
IGNITER AND IGNITION
SENSOR 2
L–B
COIL NO. 4
1
3
1
GR GR B–L B–R
11 E
1 D
E7
2 EC2
IGT4
KNK1
K1
2
KNOCK (* 5) (* 5) L–B
I3
SENSOR 1
1
B B
2 D
1 EC2
KNK2
BR
L–B
B–R
L–W
B–W
79
ENGINE CONTROL (2UZ–FE)
L–W
B–R
B–R
B–R
B–R
L–B
L–B
IGNITER AND IGNITION
COIL NO. 6
COIL NO. 7
COIL NO. 8
I10
I7
I8
I9
3 3 3 3
G–W
R–W
L–W
L–B
P–L
LG
12 E 26 E 13 E 10 E 23 E 24 E
IGT5 IGT6 IGT7 IGT8 IGF2 IGF1
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
G–W
W–B
W–B
W–B
W–B
R
L
G
Y
W–G
(*5) (*5)
1
A3
VSV(EVAP)
G
R
Y
1
V4
A
2
A
1 2 2 1
B–W
A J19
R
C1 JUNCTION C2
CAMSHAFT POSITION CONNECTOR CRANKSHAFT POSITION
BR
SENSOR SENSOR
R R R
I3
B–W B–W
BR I3
W–B
W–B
B–W
EB
80
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
1 * 5 : SHIELDED
L–W
SENSOR ASSEMBLY
2
6
CENTER AIRBAG
2 1F INTEGRATION 2
RELAY
G–Y
(TRANSFER L4 POSITION)
2 GSW2
C5
W–G
4 1G 23
TO ADD DETECTION
TO DETECTION SW
STOP LIGHT
R–B
G
SW
E
S4
J10
JUNCTION
CONNECTOR 1 IA5 1 II1
SW
1
E
G–W
1
(IDLE–UP)
C
4
DIODE
W–G
C G–W
R–B
1D
D10
J10 2
L–W
G–O
V–G
L–R
JUNCTION 1 1D
GR
CONNECTOR
G–Y
G–W
19 B 12 A 6 B 14 A 8 D 4 B 5 A 17 B 11 A
STP ELS +BM F/PS 4WD L4 TACH SPD W
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
L–W
BR
I3
17 IA4
R–W
B–W
Y–G
B–Y
B–Y
L–B
L–Y
P–L
(* 5)
W
R
L
G–B G–B
W–L
6 4 1 2 5
A/C PRESSURE SW
ENGINE COOLANT
TEMP. SENSOR
2
MASS AIR FLOW METER
21 18 19 2 4 5
A/CS AIND A/CM
E2
A1
1 2
W–B
J18
CONNECTOR
M1
I24 3 1 T2 3 JUNCTION
JUNCTION
B–W
B–W
R B–W
J2
A
B–W B–W B–W
I3 I3
W–B
B–W
EA
81
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (2UZ–FE)
L–W L–W
G–O G–O
V–G
V1
VAPOR PRESSURE
SENSOR
B–L
2 3 1
A/C THERMISTOR 1
B–W
G–B
R–L
J14 A , J15 B
A13
2 H B I B G B
CONNECTOR
JUNCTION
B–L
E A D A F A
E3 A , E4 B , E5 C , E6 D , E7 E
B–W
G–B
R–L
B–L
ENGINE CONTROL MODULE 32 B
THE
B
B
B J9
JUNCTION
CONNECTOR
B–W
G–R
G–B
P–G
V–R
R–L
L
V–G
G–B G–B G–B
I3
3 6 5 4 1 2
A20
ACCEL PEDAL POSITION SENSOR
B–W
82
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
L–W
G–O 10A
GAUGE
5 1F 8 1F
D
J9
JUNCTION
CONNECTOR
D
G–O
L–W
B–Y
B–Y
3 C 4 C 9 A
COMBINATION METER
INDICATOR LAMP
MALFUNCTION
C11 A , C13 C
SPEEDOMETER
TACHOMETER
13 A 2 C 8 B 8 C
V–G
B–Y
R–L
P–L
BR
V–G
C
J8
JUNCTION
CONNECTOR
2 3
C
(COMBINATION METER)
VEHICLE SPEED
B–Y
BR
SENSOR
V2
B–Y
BR
IH
83
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (2UZ–FE)
SYSTEM OUTLINE
The engine control system utilizes a microcomputer and maintains overall control of the engine, transmission etc. An outline
of the engine control is given here.
1. INPUT SIGNALS
(1) Engine coolant temp. signal circuit
The engine coolant temp. sensor detects the engine coolant temp. and has a built–in thermistor with a resistance which
varies according to the engine coolant temp. The engine coolant temp. is input into TERMINAL THW of the engine
control module as a control signal.
(2) Intake air temp. signal circuit
The intake air temp. sensor is installed in the mass air flow meter and detects the intake air temp., which is input as a
control signal to TERMINAL THA of the engine control module.
(3) Oxygen sensor signal circuit
The oxygen density in the exhaust emission is detected and is input as a control signal from the heated oxygen sensors
to TERMINALS OX1A, OX2A, OX1B, OX2B of the engine control module.
(4) RPM signal circuit
The camshaft position is detected by the camshaft position sensor and is input into TERMINAL G2 of the engine control
module as a control signal. Also, the engine RPM is detected by the crankshaft position sensor and the signal is input
into TERMINAL NE+ of the engine control module.
(5) Throttle position sensor signal circuit
The throttle position sensor detects the throttle valve opening angle as a control signal, which is input into TERMINALS
VTA1, VTA2 of the engine control module.
(6) Vehicle speed circuit
The vehicle speed sensor (Combination meter) detects the vehicle speed, and the signal is input into TERMINAL SPD
of the engine control module via the combination meter.
(7) Battery signal circuit
Voltage is constantly applied to TERMINAL BATT of the engine control module. When the ignition SW is turned on, the
voltage for engine control module start up power supply is applied through the EFI relay, to TERMINALS +B, +B2 of the
engine control module. The current from the IGN fuse flows to TERMINAL IGSW of the engine control module, and
voltage is constantly applied to TERMINAL +BM.
(8) Intake air volume signal circuit
The intake air volume is detected by the mass air flow meter, and is input as a control signal to TERMINAL VG of the
engine control module.
(9) Stop light SW signal circuit
The stop light SW is used to detect whether the vehicle is braking or not, and the signal is input into TERMINAL STP of
the engine control module as a control signal.
(10) Starter signal circuit
To confirm whether the engine is cranking, the voltage applied to the starter motor when the engine is cranking is
detected, and is input into TERMINAL STA of the engine control module as a control signal.
(11) Engine knock signal circuit
Engine knocking is detected by the knock sensors, and is input into TERMINALS KNK1, KNK2 of the engine control
module as a control signal.
84
2003 TOYOTA TUNDRA (EWD491U)
2. CONTROL SYSTEM
∗ SFI system
The SFI system monitors the engine condition through the signals input from each sensors to the engine control module.
The control signal is sent to the engine control module TERMINALS #1, #2, #3, #4, #5, #6, #7, #8 to operate the injector
(Fuel injection). The SFI system controls the fuel injection by the engine control module in response to the driving
conditions.
∗ ESA system
The ESA system monitors the engine condition through the signals input from each sensors to the engine control module.
The best ignition timing is decided according to this data and the data memorized in the engine control module. The
control signal is output to TERMINALS IGT1, IGT2, IGT3, IGT4, IGT5, IGT6, IGT7, IGT8, and these signals control the
igniter to provide the best ignition timing.
∗ Heated oxygen sensor heater control system
The heated oxygen sensor heater control system turns the heater on when the intake air volume is low (Temp. of exhaust
emission is low), and warms up the heated oxygen sensors to improve their detection performance. The engine control
module evaluates the signals from each sensors, and outputs current to TERMINALS HT1A, HT2A, HT1B, HT2B to
control the heater.
∗ Fuel pump control system
The engine control module supplies current to TERMINAL FPR, and controls the operation speed of the fuel pump with
the F/PMP relay.
∗ ETCS–i
The ETCS–i controls the engine output at its optimal level in accordance with the opening of the accelerator pedal, under
all driving conditions.
3. DIAGNOSIS SYSTEM
When there is a malfunction in the engine control module signal system, the malfunctioning system is recorded in the
memory. The malfunctioning system can be found by reading the code displayed on the malfunction indicator lamp.
4. FAIL–SAFE SYSTEM
When a malfunction has occurred in any system, there is a possibility of causing engine trouble due to continued control
based on that system. In that case, the fail–safe system either controls the system using the data (Standard values)
recorded in the engine control module memory, or else stops the engine.
85
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (2UZ–FE)
SERVICE HINTS
EFI RELAY
5–3 : Closed with ignition SW at ON or ST position
C/OPN RELAY
5–3 : Closed with starter cranking or engine cranking
E2 ENGINE COOLANT TEMP. SENSOR
1–2 : Approx. 16.2 kΩ (–20°C, –4°F)
: Approx. 2.45 kΩ (20°C, 68°F)
: Approx. 0.32 kΩ (80°C, 176°F)
E3 (A), E4 (B), E5 (C), E6 (D), E7 (E) ENGINE CONTROL MODULE
BATT–E1 : Always 9.0–14.0 volts
+BM–E1 : Always 9.0–14.0 volts
IGSW–E1 : 9.0–14.0 volts with ignition SW at ON or ST position
+B, +B2–E1: 9.0–14.0 volts with ignition SW at ON or ST position
VC–E1 : 4.5–5.5 volts with ignition SW at ON or ST position
VTA2–E1 : 2.0–2.9 volts with ignition SW on and throttle valve fully closed
: 4.7–5.1 volts with ignition SW on and throttle valve fully open
VTA1–E1 : 0.4–1.0 volts with ignition SW on and throttle valve fully closed
: 3.2–4.8 volts with ignition SW on and throttle valve fully open
VPA–E1 : 0.3–0.9 volts with ignition SW on and throttle valve fully closed
: 3.2–4.8 volts with ignition SW on and throttle valve fully open
VPA2–E1 : 1.8–2.7 volts with ignition SW on and throttle valve fully closed
: 4.7–5.1 volts with ignition SW on and throttle valve fully open
THA–E1 : 0.5–3.4 volts with idling, intake air temp. 0°C (32°F) –80°C (176°F)
THW–E1 : 0.2–1.0 volts with idling, engine coolant temp. 60°C (140°F) –120°C (248°F)
STA–E1 : 6.0 volts or more with engine cranking
W–E1 : 9.0–14.0 volts with idling and malfunction indicator lamp off
SPD–E1 : Pulse generation with vehicle moving
STP–E1 : 7.5–14.0 volts with brake pedal depressed
: PARTS LOCATION
Code See Page Code See Page Code See Page
A1 30 (2UZ–FE) H5 30 (2UZ–FE) J5 35
A3 30 (2UZ–FE) H6 30 (2UZ–FE) J8 35
A13 34 I3 31 (2UZ–FE) J9 35
A20 34 I4 31 (2UZ–FE) J10 35
A22 34 I5 31 (2UZ–FE) 36 (Access Cab)
J14 A
C1 30 (2UZ–FE) I6 31 (2UZ–FE) 37 (Standard Cab)
C2 30 (2UZ–FE) I7 31 (2UZ–FE) 36 (Access Cab)
J15 B
C5 34 I8 31 (2UZ–FE) 37 (Standard Cab)
C11 A 34 I9 31 (2UZ–FE) J18 31 (2UZ–FE)
C13 C 34 I10 31 (2UZ–FE) J19 35
D6 34 I14 31 (2UZ–FE) J21 A 35
D10 34 I15 31 (2UZ–FE) J22 B 35
E2 30 (2UZ–FE) I16 31 (2UZ–FE) K1 31 (2UZ–FE)
E3 A 34 I17 31 (2UZ–FE) K2 31 (2UZ–FE)
E4 B 34 I18 31 (2UZ–FE) M1 31 (2UZ–FE)
E5 C 34 I19 31 (2UZ–FE) S4 35
E6 D 34 I20 31 (2UZ–FE) T2 31 (2UZ–FE)
E7 E 34 I21 31 (2UZ–FE) 36 (Access Cab)
V1
F5 30 (2UZ–FE) I23 35 37 (Standard Cab)
36 (Access Cab) I24 35 V2 31 (2UZ–FE)
F10
37 (Standard Cab) J1 31 (2UZ–FE) V4 31 (2UZ–FE)
H3 30 (2UZ–FE) J2 31 (2UZ–FE) 36 (Access Cab)
V9
H4 30 (2UZ–FE) J3 35 37 (Standard Cab)
86
2003 TOYOTA TUNDRA (EWD491U)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1B
26 (*1)
22 (*2)
1D
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1F
26 (*1)
22 (*2)
1G
26 (*1)
22 (*2)
1I Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1K Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
E4 40 (2UZ–FE) Engine No.2 Wire E8 40 (2UZ–FE)
Engine Wire
E6 I3 46
40 (2UZ–FE)
(2UZ FE) Engine Wire
E7 I5 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
87
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (5VZ–FE)
B–R
B–R
P
(A/T)
7 AM2 IG2 6
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
ST2 8
1
I23 15A
10A
W–R
G–B
IGNITION SW EFI
GAUGE
W NO. 1
2 2 2 7 1F 2
(M/T)
2 3 2
B–R
B–Y
ST RELAY
30A AM2
B–W
B–Y
5 1
B–R
1
2 2
2
P
B–W
B–W
B–R
B–R
B–Y
CONNECTOR
C
JUNCTION
24 IA4
J2
C
2 2 2 2
P
B–W
2 3 3 2
C/OPN RELAY
P
EFI RELAY
CONNECTOR
W–L
3 1I (A/T)
JUNCTION
A
J8
A 1 5 5 1
5A
(A/T)
2 2 2 2
STA
P
Y
(M/T)
(M/T)
(M/T)
W–B
W–L
B–Y
L–O
12 IE2
P
6 1F
(A/T)
B
5 IA4 26 IA4
CLUTCH START
CLUTCH START SW
9 1 1 7
B
PARK/NEUTRAL
CANCEL SW
POSITION SW
L–O
N
C9
P1
3 BB1
C10
6 2 3 5
(A/T)
W–B
L–O
(M/T)
(M/T)
(M/T)
W–B
W–B
W–B
4
19 IE2
FUEL PUMP
M
Y
W–B
(A/T)
F10
CONNECTOR
A 5
JUNCTION
W–B
W–B W–B
I1 I1
BATTERY
(A/T)
J18
A 12 BB1
A A W–B
A B W–L
J23 A , J24 B Y
W–B
JUNCTION
CONNECTOR
B
A
W–B
W–B
J3 A W–B
JUNCTION
CONNECTOR
IE EA IF
88
2003 TOYOTA TUNDRA (EWD491U)
B–R B–R B–R
P(A/T)
4 1I 7 1J
FROM POWER SOURCE SYSTEM
(SEE PAGE 56) * 1 : W/ CRUISE CONTROL
* 2 : W/O CRUISE CONTROL
5A
7. 5A J8 IGN
OBD JUNCTION
CONNECTOR
W–G D D W–G
4 1B 6 1K 11 1F
B–W
B–W
B–O
B–O
(* 1)
(* 2)
B–Y
CONNECTOR
B–R B
JUNCTION
B B–O
J5
JUNCTION (* 1)
CONNECTOR
J5
B
W D D W 6 IA4 15 IA4 20 IE1
B–O
(* 1)
J1
JUNCTION
W–G
(A/T)
L–W
B–R
B–Y
W
CONNECTOR
P
B B W–L
13 A 14 A 16 A 4 A 7 D 3 B 15 A
W–G
L–W
W–L
W–L
W–L
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
CG SG
W–L
W–L
4 5 D6
L–W
DATA LINK
CONNECTOR 3
W–B
BR
2 G A
I5 J14 A , J15 B
JUNCTION
R
CONNECTOR
F B
W–L
W–L
18 IA4
L–W
2 2
R
13 IE1
VSV(EVAP)
V9
J14 A , J15 B
VSV(CANISTER
H A CLOSED VALVE)
CONNECTOR
V4
15 IE1
JUNCTION
1 1
W–L
W–L
W–B
E B
I3
B–Y
B
W–B
W–B W–L
ED
89
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (5VZ–FE)
B–R
B–O
B–R (* 1)
3 IE1
B–R
C5
CENTER AIRBAG
SENSOR ASSEMBLY
B–R B–R B–R B–R
I3 I3 I3 I3 I3
B–R
B–R
B–R
B–R
B–R
(TRANSFER L4 POSITION)
TO ADD DETECTION SW
23
TO DETECTION SW
TO DETECTION SW
2 2 2 2 2 2
INJECTOR NO. 1
INJECTOR NO. 2
INJECTOR NO. 3
INJECTOR NO. 4
INJECTOR NO. 5
INJECTOR NO. 6
B–O
R–B
(* 1)
I14
I15
I16
I17
I18
I19
1 1 1 1 1 1
R–B
W
(A/T * 3)
(A/T * 3)
R
Y
L
R–Y
L–R
(*3)
GR
6 D 5 D 4 D 3 D 1 D 8 D 21 A 11 B 13 B 2 B
#10 # 20 # 30 #40 # 50 # 60 F/PS TFN 4WD L4
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
R–L
G–W
R–W
B–W
G–Y
Y–G
R–Y
19
G–B 22 IE1
I3 IE1
G–B
R–B
B–Y
2 EF1 G–B
R–L
J14 A , J15 B
G–B
G–Y
D A E A
CONNECTOR
MASS AIR FLOW METER
JUNCTION
2 3 4 3 4 1 2 3 4
ENGINE COOLANT
2 VPA VPA2 VC
TEMP. SENSOR
I B H B
G–B
R–L
E2
M1
3 2
E2
A8
1 5 1 2
T2 1
BR–B
B–W
THROTTLE
POSITION
B–W
B–W
W–L
SENSOR
V1 1
1 EF1 B–W VAPOR
I3 I3 PRESSURE
SENSOR
B–W
B–W
W–L
B–W
B–W
B–W
I3
J14 A , J15 B
26 IE1 JUNCTION
CONNECTOR
W–L
W–L W–L
90
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56) * 1 : W/ CRUISE CONTROL
* 3 : 4WD
B–O
(* 1)
15A
STOP
2 1F
I24
G–Y
INTEGRATION
T1 I2 CONTROL
THROTTLE CONTROL MOTOR IGNITER AND PANEL
3 2
STOP LIGHT SW
(SHIELDED)
S4
4 1
R
G–W
B–Y
B–L
R–L
LG
L–Y
L–B
C
4
C G–W
L–R
1D
J10 I3
(SHIELDED)
JUNCTION 1 1D
CONNECTOR
Y
L
G–W
BR
9 B 20 A 8 C 2 C 9 E 31 E 17 E 11 D 10 D 9 D 2 D 9 A 3 A
ST1– STP CL– CL+ M+ M– GE01 IGT1 IGT2 IGT3 IGF AC1 ACT
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
PSW OX2B HT2B KNK1 KNK2 E1 ME01 E04 E01 E02 E03
18 D 27 D 29 E 23 E 22 E 17 D 6 E 8 E 4 E 5 E 7 E
R–W
W–B
W–B
W–B
W–B
BR
BR
R
I3
(SHIELDED)
(SHIELDED)
25 IE1 23 IE1
GR
BR
B
Y–R
(SHIELDED)
E9
R–W
R
BR
R–W
(SHIELDED)
R
(SHIELDED)
1
BR
BR
OIL PRESSURE SW
POWER STEERING
3 1
(BANK 1 SENSOR 2)
GR
B
OX HT
E10
I3 +B E1
KNOCK SENSOR 1
KNOCK SENSOR 2
1 1
P2
2 4
H9
W–L
BR
BR
BR
1 BD1 3 BD1
K1
K2
BR
BR BR
I3
W–L
14 IE1
BR
BR
W–L W–L
W–L BR BR
I3
BR ED
91
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (5VZ–FE)
10A
GAUGE
BR
I3
CRANKSHAFT POSITION SENSOR
2 2
G–O
CONNECTOR
D
1 1
JUNCTION
C2
C1
B–Y
B–Y
J9
D
G
Y
(SHIELDED)
(SHIELDED)
G–O
G–O
BR
R
I3
C11 A , C13 C
G
COMBINATION METER 3 C 9 A
INDICATOR LIGHT
MALFUNCTION
SPEEDOMETER
12 D 21 D 13 D 6 A
NE+ NE– G2 SP1
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
V–G
B–Y
P–L
BR
V–G
2 IE1
BR
G–B
V–G
B–Y
P–L
I3 I3
AIR FUEL RATIO SENSOR
1 3
(BANK 1 SENSOR 1)
BR
HT AF+ 2 3
VEHICLE SPEED SENSOR
(COMBINATION METER)
+B AF–
2 4
A10
W–L
BR
V2
BR C
J8
JUNCTION
CONNECTOR
C
W–L
BR
IH
92
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM OUTLINE
The engine control system utilizes a microcomputer and maintains overall control of the engine, transmission etc. An outline
of the engine control is given here.
1. INPUT SIGNALS
(1) Engine coolant temp. signal circuit
The engine coolant temp. sensor detects the engine coolant temp. and has a built–in thermistor with a resistance which
varies according to the engine coolant temp. The engine coolant temp. is input into TERMINAL THW of the engine
control module as a control signal.
(2) Intake air temp. signal circuit
The intake air temp. sensor is installed in the mass air flow meter and detects the intake air temp., which is input as a
control signal to TERMINAL THA of the engine control module.
(3) Oxygen sensor signal circuit
The oxygen density in the exhaust emission is detected and is input as a control signal from the heated oxygen sensors
to TERMINAL OX2B of the engine control module.
(4) RPM signal circuit
The camshaft position is detected by the camshaft position sensor and is input into TERMINAL G2 of the engine control
module as a control signal. Also, the engine RPM is detected by the crankshaft position sensor and the signal is input
into TERMINAL NE+ of the engine control module.
(5) Throttle position sensor signal circuit
The throttle position sensor detects the throttle valve opening angle as a control signal, which is input into TERMINAL
VTA of the engine control module.
(6) Vehicle speed circuit
The vehicle speed sensor (Combination meter) detects the vehicle speed, and the signal is input into TERMINAL SP1 of
the engine control module via the combination meter.
(7) Battery signal circuit
Voltage is constantly applied to TERMINAL BATT of the engine control module. When the ignition SW is turned on, the
voltage for engine control module start up power supply is applied through the EFI relay, to TERMINAL +B of the engine
control module.
(8) Intake air volume signal circuit
The intake air volume is detected by the mass air flow meter, and is input as a control signal to TERMINAL VG of the
engine control module.
(9) Stop light SW signal circuit
The stop light SW is used to detect whether the vehicle is braking or not, and the signal is input into TERMINAL STP of
the engine control module as a control signal.
(10) Starter signal circuit
To confirm whether the engine is cranking, the voltage applied to the starter motor when the engine is cranking is
detected, and is input into TERMINAL STA of the engine control module as a control signal.
(11) Engine knock signal circuit
Engine knocking is detected by the knock sensors, and is input into TERMINALS KNK1, KNK2 of the engine control
module as a control signal.
(12) A/C SW signal system
The operating voltage of the A/C magnetic clutch is detected and input in the form of a control signal to TERMINAL AC1
of the engine control module.
(13) 4WD signal system
Whether or not the vehicle is operating in 4WD mode is determined, and a control signal is input to TERMINAL 4WD of
the engine control module.
(14) Air fuel ratio signal system
The air fuel ratio is detected and input as a control signal into TERMINAL AF1+ of the engine control module.
93
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (5VZ–FE)
2. CONTROL SYSTEM
∗ SFI system
The SFI system monitors the engine condition through the signals input from each sensors to the engine control module.
The control signal is sent to the engine control module TERMINALS #10, #20, #30, #40, #50, #60 to operate the injector
(Fuel injection). The SFI system controls the fuel injection by the engine control module in response to the driving
conditions.
∗ ESA system
The ESA system monitors the engine condition through the signals input from each sensors to the engine control module.
The best ignition timing is decided according to this data and the data memorized in the engine control module. The
control signal is output to TERMINALS IGT1, IGT2, IGT3 and these signals control the igniter to provide the best ignition
timing.
∗ Heated oxygen sensor heater control system
The heated oxygen sensor heater control system turns the heater on when the intake air volume is low (Temp. of exhaust
emission is low), and warms up the heated oxygen sensors to improve their detection performance. The engine control
module evaluates the signals from each sensors, and outputs current to TERMINAL HT2B to control the heater.
3. DIAGNOSIS SYSTEM
When there is a malfunction in the engine control module signal system, the malfunctioning system is recorded in the
memory. The malfunctioning system can be found by reading the code displayed on the malfunction indicator lamp.
4. FAIL–SAFE SYSTEM
When a malfunction has occurred in any system, there is a possibility of causing engine trouble due to continued control
based on that system. In that case, the fail–safe system either controls the system using the data (Standard values)
recorded in the engine control module memory, or else stops the engine.
SERVICE HINTS
EFI RELAY
5–3 : Closed with ignition SW at ON or ST position
C/OPN RELAY
5–3 : Closed with starter cranking or engine cranking
T2 THROTTLE POSITION SENSOR
2–1 : Approx. 2.5–6.0 kΩ
E2 ENGINE COOLANT TEMP. SENSOR
1–2 : Approx. 15.0 kΩ (–20°C, –4°F)
Approx. 2.45 kΩ (20°C, 68°F)
Approx. 0.32 kΩ (80°C, 176°F)
E3 (A), E4 (B), E5 (C), E6 (D), E7 (E) ENGINE CONTROL MODULE
BATT–E1 : Always 9.0–14.0 volts
+B–E1 : 9.0–14.0 volts with ignition SW at ON or ST position
VC–E1 : 4.5–5.5 volts
VTA–E1 : 0.3–1.0 volts with ignition SW on and throttle valve fully closed
: 3.2–4.9 volts with ignition SW on and throttle valve fully open
THA–E1 : 0.5–3.4 volts with idling, intake air temp. 0°C (32°F) –80°C (176°F)
THW–E1 : 0.2–1.0 volts with idling, engine coolant temp. 60°C (140°F) –120°C (248°F)
STA–E1 : 6.0 volts or more with engine cranking
W–E1 : 9.0–14.0 volts with idling and malfunction indicator lamp off
SP1–E1 : Pulse generation with vehicle moving
STP–E1 : 7.5–14.0 volts with brake pedal depressed
94
2003 TOYOTA TUNDRA (EWD491U)
: PARTS LOCATION
Code See Page Code See Page Code See Page
A8 32 (5VZ–FE) H9 37 (Standard Cab) 36 (Access Cab)
J15 B
A10 32 (5VZ–FE) I2 33 (5VZ–FE) 37 (Standard Cab)
C1 32 (5VZ–FE) I14 33 (5VZ–FE) J18 33 (5VZ–FE)
C2 32 (5VZ–FE) I15 33 (5VZ–FE) J23 A 35
C5 34 I16 33 (5VZ–FE) J24 B 35
C9 34 I17 33 (5VZ–FE) K1 33 (5VZ–FE)
C10 34 I18 33 (5VZ–FE) K2 33 (5VZ–FE)
C11 A 34 I19 33 (5VZ–FE) M1 33 (5VZ–FE)
C13 C 34 I23 35 P1 33 (5VZ–FE)
D6 34 I24 35 P2 33 (5VZ–FE)
E2 32 (5VZ–FE) J1 33 (5VZ–FE) S4 35
E3 A 34 J2 33 (5VZ–FE) T1 33 (5VZ–FE)
E4 B 34 J3 35 T2 33 (5VZ–FE)
E5 C 34 J5 35 36 (Access Cab)
V1
E6 D 34 J8 35 37 (Standard Cab)
E7 E 34 J9 35 V2 33 (5VZ–FE)
36 (Access Cab) J10 35 V4 33 (5VZ–FE)
F10
37 (Standard Cab) 36 (Access Cab) 36 (Access Cab)
J14 A V9
H9 36 (Access Cab) 37 (Standard Cab) 37 (Standard Cab)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1B
26 (*1)
22 (*2)
1D Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
22 (*2)
1I Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1K Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
95
2003 TOYOTA TUNDRA (EWD491U)
ENGINE CONTROL (5VZ–FE)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
E9 42 (5VZ–FE) Engine Wire I3 46 Engine Wire
E10 42 (5VZ–FE) Sensor Wire I5 46 Cowl Wire
I1 46 Cowl Wire
96
2003 TOYOTA TUNDRA (EWD491U)
MEMO
97
2003 TOYOTA TUNDRA (EWD491U)
HEADLIGHT (w/ DAYTIME RUNNING LIGHT)
5 1
1 1 1 1
10A HEAD RH
10A HEAD LH
10A HEAD RL
10A HEAD LL
H–LP
RELAY
3 2
3 3 2 2 2 2
2 2 2 2 2 2 2 R–B R
R–B
Y–B
G–W
W–G
R–W
R–L
G
L
R–B G–Y(*6)
G–Y(*5)
1 2 1 2 2 2 GR
H1 H2
HEADLIGHT HEADLIGHT
LH RH 3 1
DIMMER RELAY
3 3
W–G
W–G
CONNECTOR
A
4 5 2
JUNCTION
J2 A R–B F
JUNCTION
CONNECTOR 2 2 2
B–L(* 3)
B(* 4)
J7
A
F
W–G
Y–B
G
CONNECTOR
G–Y
G–Y
(* 6)
(* 5)
JUNCTION
B W–G
B
GR
V
J2
B C15
COMBINATION
SW 13 8 7
W–G
W–G
CONTROL SW
OFF
R–B
1 TAIL
LIGHT
HEAD
2 2
DAYTIME RUNNING
LIGHT RESISTOR
LOW
DIMMER SW
DRL NO. 4 RELAY
3 1
HIGH
FLASH
BATTERY
D2
2 5 2 16
W–B
W–B
2 2
R–W
4 3 4
R–W R–W
1K 1J 1J
W–B
(*1) (* 2) W–B
I2
CONNECTOR
W–B
JUNCTION
A
A
J18
A
W–B
A A
W–B
J3 A W–B
JUNCTION
CONNECTOR
EA IF
98
2003 TOYOTA TUNDRA (EWD491U)
* 1 : 2UZ–FE FROM POWER SOURCE SYSTEM (SEE PAGE 56)
* 2 : 5VZ–FE
* 3 : TOWING PACKAGE
* 4 : EXCEPT TOWING PACKAGE
* 5 : W/ DOOR LOCK CONTROL
* 6 : W/O DOOR LOCK CONTROL
5A 15A
ECU IG TAIL
5 6
[COMB. SW]
G–Y(*6)
G–Y(*5)
9 IA5
GR
G–Y(* 5)
G–Y(* 6)
G–B
G–W
Y–B
GR
R
V
13 1N 7 1N 8 1N 3 1N 3 1O 4 1O 5 1O
INTEGRATION
9 RELAY 6
6 1B
4 1E
8
G–W
BRAKE FLUID LEVEL
15 1N 8 1J 6 1O 1 1N 24 1N 2 1N
1
R–W
W–B
R–G
WARNING SW
Y–G
BR
(M/T)
B2
R–W
R–W
(A/T)
C11 A , C12 B
2 16 B
[COMB. METER]
CONNECTOR
W–B
JUNCTION
C A
1 1 J8
JUNCTION
J11
A P5 CONNECTOR
A W–B PARKING P5
7 A C A
BRAKE SW PARKING
(M/T) BRAKE SW
A J18 (A/T)
JUNCTION 2
W–B
Y–G
CONNECTOR
W–B
(M/T)
W–B
R–W
W–B 7 IA5
I2
W–B
Y–G
BR
A B
J23 A , J24 B
2 EB1
JUNCTION
W–B
W–B
CONNECTOR
18 IA5 A A
Y–G
A
W–B J13 4
W–B
JUNCTION
CONNECTOR L
G2
GENERATOR
EA IE II IH
99
2003 TOYOTA TUNDRA (EWD491U)
HEADLIGHT (w/ DAYTIME RUNNING LIGHT)
SYSTEM OUTLINE
When the following conditions are met while the ignition SW is ON, and if the light control SW is at OFF or TAIL position, the
daytime running light is controlled.
∗ Parking brake lever is released (Parking brake SW is OFF)
∗ Input signal from the generator
If any of the following conditions are met, the daytime running light control is canceled.
∗ Ignition SW is turned OFF.
∗ Light control SW is at HEAD position.
SERVICE HINTS
H–LP RELAY
5–3 : Closed with light control SW at HEAD position or dimmer SW at FLASH position
Closed with engine running and parking brake lever released
DIMMER RELAY
3–5 : Closed with HEAD relay on and dimmer SW at HIGH or FLASH position
: PARTS LOCATION
Code See Page Code See Page Code See Page
30 (2UZ–FE) 30 (2UZ–FE) J11 35
B2 H1
32 (5VZ–FE) 32 (5VZ–FE) J13 35
C11 A 34 30 (2UZ–FE) 31 (2UZ–FE)
H2 J18
C12 B 34 32 (5VZ–FE) 33 (5VZ–FE)
C15 34 31 (2UZ–FE) J23 A 35
J2
30 (2UZ–FE) 33 (5VZ–FE) J24 B 35
D2
32 (5VZ–FE) J3 35 P5 35
30 (2UZ–FE) J7 35
G2
32 (5VZ–FE) J8 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
1B
26 (*1) Cowl Wire and Driver Side J/B (Lower Finish Panel)
1C
1E 26 (*1) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1J 26 (*1) Cowl Wire and Driver Side J/B (Lower Finish Panel)
1K 26 (*1) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1N
27 (*1) Cowl Wire and Driver Side J/B (Lower Finish Panel)
1O
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
100
2003 TOYOTA TUNDRA (EWD491U)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire
101
2003 TOYOTA TUNDRA (EWD491U)
HEADLIGHT (w/o DAYTIME RUNNING LIGHT)
1 1
1 5
10A 10A
H–LP HEAD LH HEAD RH
RELAY
2 3 3 2
2 2 2 2 2 2
R–W
R–B
R–B
R–L
R
3 3
H1 H2
HEADLIGHT HEADLIGHT
LH RH
5 1K 2 1 2 1
R–G
R–G
R–Y
R–Y
6 1C 7 1C
A A B B
J2
JUNCTION
R
CONNECTOR
A B
6 1L R–Y
INTEGRATION
B–L(*1)
B(* 2)
9 IA5
R–G
RELAY
R–Y
5 1L A
J11
R–Y A
JUNCTION
G–Y CONNECTOR
(* 3)
F 4 1K
J7
4
G–Y
JUNCTION
(*4)
R–G
CONNECTOR 1J
F
G–Y
R–G
R–Y
R
(* 3) 3 1J
C15
COMBINATION SW 13 8 7 17
R–G
CONTROL SW
OFF
16 B
HIGH BEAM
HEAD INDICATOR LIGHT
[COMB. METER]
7 A
LOW
DIMMER SW
W–B
HIGH
BATTERY
FLASH
16 A B J23 A , J24 B
JUNCTION
W–B
CONNECTOR
* 1: TOWING PACKAGE
* 2: EXCEPT TOWING PACKAGE A A
W–B * 3: W/ DOOR LOCK CONTROL
I2
* 4: W/O DOOR LOCK CONTROL
W–B
W–B
A A
J3 J13
JUNCTION JUNCTION
CONNECTOR CONNECTOR
IF II IE
102
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
H–LP RELAY
5–3 : Closed with light control SW at HEAD position or dimmer SW at FLASH position
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 A 34 30 (2UZ–FE) J7 35
H2
C12 B 34 32 (5VZ–FE) J11 35
C15 34 31 (2UZ–FE) J13 35
J2
30 (2UZ–FE) 33 (5VZ–FE) J23 A 35
H1
32 (5VZ–FE) J3 35 J24 B 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
1C
22 (*2) Cowl Wire and Driver Side J/B (Lower Finish Panel)
1J
1K 22 (*2) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1L 23 (*2) Cowl Wire and Driver Side J/B (Lower Finish Panel)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
103
2003 TOYOTA TUNDRA (EWD491U)
FOG LIGHT (w/ DAYTIME RUNNING LIGHT)
(*2)
B–L R–B 1
(*1)
2 2 2 20A
FOG
1 3
2
1 5
DIMMER
H–LP RELAY
RELAY
2 3 2 5 4
2 2
2
(* 2)
B
R–B
R
G
B–L
(* 1)
5 1K
2
1
6 1C
R
BATTERY
10A
HEAD LL
4 1O
INTEGRATION
RELAY 3
2 2
G–W
L–R
2 2
3 1N 5 1O
2 3
G–B
FOG
10 RELAY
G–Y
(* 3)
C15
FOG LIGHT SW 1 5
[COMB. SW]
F 2 2
J7
JUNCTION 11 8
CONNECTOR R–Y R–Y
P
IA5
G–Y
(* 4)
D
J2 D P
JUNCTION
G–Y
(*3)
CONNECTOR
* 1 : TOWING PACKAGE
* 2 : EXCEPT TOWING PACKAGE D
* 3 : W/ DOOR LOCK CONTROL
* 4 : W/O DOOR LOCK CONTROL
P
FRONT FOG LIGHT
13
1 1
CONTROL SW
OFF
F1
F2
RH
LH
TAIL
LIGHT
2 2
HEAD
W–B
W–B
C15 16
W–B
COMBINATION SW
A
I2 J18 A W–B
JUNCTION
W–B
W–B
CONNECTOR
A
A A
W–B
J3 J13
JUNCTION JUNCTION
CONNECTOR CONNECTOR
IF II EA
104
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
FOG RELAY
3–5 : Closed with light control SW at HEAD position, dimmer SW at LOW position and fog light SW at ON position
: PARTS LOCATION
Code See Page Code See Page Code See Page
C15 34 F2 32 (5VZ–FE) J7 35
30 (2UZ–FE) 31 (2UZ–FE) J13 35
F1 J2
32 (5VZ–FE) 33 (5VZ–FE) 31 (2UZ–FE)
J18
F2 30 (2UZ–FE) J3 35 33 (5VZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
1C 26 (*1) Cowl Wire and Driver Side J/B (Lower Finish Panel)
1K 26 (*1) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1N
27 (*1) Cowl Wire and Driver Side J/B (Lower Finish Panel)
1O
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
105
2003 TOYOTA TUNDRA (EWD491U)
FOG LIGHT (w/o DAYTIME RUNNING LIGHT)
1 1 1
1 5
10A 10A 20A
HEAD LH HEAD RH FOG
H–LP
RELAY
3 2 2
2 3
2 2 2 2 2 2 2
R–B
R–W
R–L
R
L–R
3 3
H1 H2
B–L
(* 1)
(* 2)
HEADLIGHT HEADLIGHT
B
5 1K LH RH
2 1 2 1
R–G
R–G
R–Y
6 1C 7 1C
G–R
A
J2
A R–Y
R
JUNCTION 2 2
CONNECTOR
2 3
BATTERY
FOG RELAY
6 1L
R–Y
INTEGRATION
1 5
RELAY
9 IA5 8 IA5
2 2
R–Y
5 1L
G–Y
W–B
G–R
P
(* 3) A
CONNECTOR
R–Y A A
JUNCTION
F
G–Y
J2
(* 4)
J11
JUNCTION
J7
JUNCTION
CONNECTOR D CONNECTOR
R–Y
F
D
G–Y
R–Y
D
R
(* 3) 11
C15
COMBINATION SW 13 8 7 C15
W–B
[COMB. SW]
CONTROL SW
OFF
TAIL 10
1 1
LIGHT
HEAD G–R
F1
F2
LOW 2 2
DIMMER SW
HIGH
W–B
W–B
* 1 : TOWING PACKAGE
FLASH * 2 : EXCEPT TOWING PACKAGE
* 3 : W/ DOOR LOCK CONTROL
16 * 4 : W/O DOOR LOCK CONTROL
A A
A
W–B
J18 A
W–B JUNCTION
I2 CONNECTOR
W–B
W–B
A A
J3 J13
JUNCTION JUNCTION
CONNECTOR CONNECTOR
IF II EA
106
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
FOG RELAY
3–5 : Closed with light control SW at HEAD position, dimmer SW at LOW position and fog light SW at ON position
: PARTS LOCATION
Code See Page Code See Page Code See Page
C15 34 H1 32 (5VZ–FE) J7 35
30 (2UZ–FE) 30 (2UZ–FE) J11 35
F1 H2
32 (5VZ–FE) 32 (5VZ–FE) J13 35
30 (2UZ–FE) 31 (2UZ–FE) 31 (2UZ–FE)
F2 J2 J18
32 (5VZ–FE) 33 (5VZ–FE) 33 (5VZ–FE)
H1 30 (2UZ–FE) J3 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
1C 22 (*2) Cowl Wire and Driver Side J/B (Lower Finish Panel)
1K 22 (*2) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1L 23 (*2) Cowl Wire and Driver Side J/B (Lower Finish Panel)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
107
2003 TOYOTA TUNDRA (EWD491U)
BACK–UP LIGHT
10A 15A
GAUGE ACC
7 1F 8 1F 9 1F 11 1G
GR
(M/T)
(A/T)
(A/T)
B–Y
B–Y
B–Y
(*4)
GR
(* 5)
E A
J8 J9
JUNCTION JUNCTION
CONNECTOR D8 L–B(* 1)
CONNECTOR
DIODE (A/T)
E A
GR(* 4) 3 2 L–B(* 3)
B–Y(A/T) 1
B–Y
(M/T)
P1 A
BACK–UP LIGHT SW
J12 [PARK/NEUTRAL 4 IE1 (* 3)
POSITION SW](A/T)
(A/T)
IE1 (M/T)
B–Y
JUNCTION 2 26 IE1
CONNECTOR B1 B
2
R–B C C R–B R–B(*1) BACK–UP LIGHT L–B(* 3)
IE1 SW (M/T)
(A/T) (*1)
R–B(*2) 1 2 2 3 B–Y(M/T)
B A B A
5 1 L–B(* 1)
15 IE2 (* 3)
B3 (A/T)
IE1 (M/T)
R–B
12
(* 3)
BACK–UP (M/T)
LIGHT
RELAY
3 2
W–B
(A/T)
(A/T)
R–B
(M/T)
R–B
R–B
(A/T)
TO TRAILER SOCKET
7 BB1
R–B
I1 R–B
B10 B10
W–B
R–B
R–B
5 5
J23 A , J24 B
A B
CONNECTOR
R4 R5
BACK–UP LIGHT RH
JUNCTION
BACK–UP LIGHT LH
[REAR COMB. LIGHT LH] [REAR COMB. LIGHT RH]
A A 3 3
W–B
W–B
W–B
W–B
3
W–B W–B
BB2 B10 B10
W–B
IE BL
108
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
P1 (A) BACK–UP LIGHT SW [PARK/NEUTRAL POSITION SW] (A/T),
B1 (B) BACK–UP LIGHT SW (M/T)
(A) 3–(A) 2, (B) 2–(B) 1 : Closed with shift lever in R position
B3 BACK–UP LIGHT RELAY (A/T)
5–3 : Closed with shift level in R position and ignition SW at ON position
: PARTS LOCATION
Code See Page Code See Page Code See Page
B1 B 32 (5VZ–FE) J12 35 36 (Access Cab)
R4
B3 34 J23 A 35 37 (Standard Cab)
D8 34 J24 B 35 36 (Access Cab)
R5
J8 35 31 (2UZ–FE) 37 (Standard Cab)
P1 A
J9 35 33 (5VZ–FE)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1F
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1G
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I1 46 Cowl Wire B10 50 (Standard Cab) Frame Wire
B10 48 (Access Cab) Frame Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
109
2003 TOYOTA TUNDRA (EWD491U)
TAILLIGHT
* 1: TOWING PACKAGE
* 2: EXCEPT TOWING PACKAGE
* 3: W/ DAYTIME RUNNING LIGHT
* 4: W/O DAYTIME RUNNING LIGHT
INTEGRATION RELAY
6 8 4
4 1N (*3)
13 1L (*4) 2 1E 3 1H
15A TAIL
R–B
G
C A
J21 A , J22 B
2 1K 8 1J
JUNCTION
CONNECTOR 2 BB1
G
A B
R–B
W–G
W–B
C15
G
LIGHT CONTROL
14 SW [COMB. SW]
OFF
2
2 TAIL
HEAD J1
50A J/B
JUNCTION
A CONNECTOR
16
A G G
B10 B10 B10
W–B
1 A
[FRONT TURN SIGNAL LIGHT RH]
[FRONT TURN SIGNAL LIGHT LH]
2
G
G
140A ALT (* 1)
100A ALT (* 2)
1 1 2 2
PARKING LIGHT RH
PARKING LIGHT LH
1 1
TAILLIGHT RH
1
TAILLIGHT LH
2 2 2
2 2 3 3
R4
R5
F3
F4
L1
L2
W–B
W–B
W–B
W–B
W–B
W–B
B–L(* 1)
(*2)
B
A
A W–B W–B
B10 B10 B10
A J18
JUNCTION
CONNECTOR
W–B
BATTERY
I2
3 BB2
W–B
W–B
W–B
W–B
W–B
W–B
A B
J23 A , J24 B
JUNCTION
CONNECTOR
J3
CONNECTOR
JUNCTION A A
JUNCTION
A CONNECTOR A A
W–B
J13
IF II EA IE BL
110
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
C15 LIGHT CONTROL SW [COMB. SW]
14–16 : Closed with light control SW at TAIL or HEAD position
: PARTS LOCATION
Code See Page Code See Page Code See Page
C15 34 J13 35 L1 37 (Standard Cab)
30 (2UZ–FE) 31 (2UZ–FE) 36 (Access Cab)
F3 J18 L2
32 (5VZ–FE) 33 (5VZ–FE) 37 (Standard Cab)
30 (2UZ–FE) J21 A 35 36 (Access Cab)
F4 R4
32 (5VZ–FE) J22 B 35 37 (Standard Cab)
31 (2UZ–FE) J23 A 35 36 (Access Cab)
J1 R5
33 (5VZ–FE) J24 B 35 37 (Standard Cab)
J3 35 L1 36 (Access Cab)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1H
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1J
26 (*1)
22 (*2)
1K Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
1L 23 (*2)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
1N 27 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire B10 50 (Standard Cab) Frame Wire
B10 48 (Access Cab) Frame Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
111
2003 TOYOTA TUNDRA (EWD491U)
ILLUMINATION
INTEGRATION RELAY
E3
6 8 4 D10 ENGINE CONTROL
DIODE MODULE
(IDLE–UP)
15A TAIL
4 1N (* 3) 1 2 G–Y 12
ELS
13 1L (* 4) 4 1G (2UZ–FE)
(2UZ–FE)
R–B
G
2 1K 8 1J
J21 A , J22 B
J10
C A E E JUNCTION CONNECTOR
CONNECTOR
E G
W–G
W–B
JUNCTION
E E E E
A B
R–B
G
2
2 14
LIGHT CONTROL SW
METER ILLUMINATION
OFF I24 A , I25 B
50A R3 INTEGRATION CONTROL
J/B TAIL [COMB. METER]
[COMB. SW]
STEERING SW
[COMB. SW]
T 1 ILL+
HEAD
1
C15
16
C12
4 C16
2 E L
14
140A ALT (* 1)
100A ALT (* 2)
W–B
BR
G–W
W–G
W–G
W–G
W–B
E E E
W–B
B–L
(*1)
(*2)
B
J5
JUNCTION CONNECTOR
W–B
BR
BATTERY
5 IE1 (2UZ–FE)
17 IE1 (5VZ–FE)
W–B
I2
W–B
W–B
W–B
(2UZ–FE)
(5VZ–FE)
CONNECTOR
BR
BR
JUNCTION
A A
W–B A A J13
JUNCTION
J3
CONNECTOR
IF EC ED II
112
2003 TOYOTA TUNDRA (EWD491U)
* 1 : TOWING PACKAGE
* 2 : EXCEPT TOWING PACKAGE
* 3 : W/ DAYTIME RUNNING LIGHT
* 4 : W/O DAYTIME RUNNING LIGHT
G TO OPTION
CONNECTOR
J12
JUNCTION CONNECTOR E
G E E
E E E E
G
G
5 ID2 6 ID2
G
G
MIRROR HEATER SW
CIGARETTE LIGHTER
RADIO AND PLAYER
R1 A , R2 B
10 B
GLOVE BOX
2 2 2 1
ILLUMINATION
ILLUMINATION
ASHTRAY
LIGHT
G3
1 1 1 2
A18
M4
C8
5 A
G–W
W–G
W–G
W–G
W–B
4 ID2 3 ID2
G–W
W–G
W–G
E E
E
J5
JUNCTION CONNECTOR
W–B W–B
I1
W–B
A B J23 A , J24 B
JUNCTION
CONNECTOR
A A
W–B
IE
113
2003 TOYOTA TUNDRA (EWD491U)
ILLUMINATION
SERVICE HINTS
C15 LIGHT CONTROL SW [COMB. SW]
14–16 : Closed with light control SW at TAIL or HEAD position
: PARTS LOCATION
Code See Page Code See Page Code See Page
A18 34 I24 A 35 J22 B 35
C8 34 I25 B 35 J23 A 35
C12 34 J3 35 J24 B 35
C15 34 J5 35 M4 35
C16 34 J10 35 R1 A 35
D10 34 J12 35 R2 B 35
E3 34 J13 35 R3 35
G3 35 J21 A 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1G
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1J
26 (*1)
22 (*2)
1K Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
1L 23 (*2)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
1N 27 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I1 46 Cowl Wire I2 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
114
2003 TOYOTA TUNDRA (EWD491U)
MEMO
115
2003 TOYOTA TUNDRA (EWD491U)
INTERIOR LIGHT
10A 10A
GAUGE DOME
L–Y
2
5 1F 2
L–Y
L–Y
I22
B–Y
IGNITION KEY 6 1E 3 1A 4 1F
CYLINDER LIGHT
2 1
3 1F J23 A , J24 B
L–B
JUNCTION
R
C B CONNECTOR
9 A 9 B 6 B L–Y
5 B
B A B A B A
DOOR
L–Y
L–Y
L–Y
L–Y
13 B 7 B
C11 A , C12 B
COMBINATION METER
W–L
DOOR COURTESY
E
L–Y
L–Y
E E E
LIGHT RH
LIGHT LH
1 1
(* 2)
(* 1)
L
D15
D14
(DOOR COURTESY)
2 2
5 BE2
2 2
W–L
W–L
(STEP LIGHT)
(* 2)
L
DIODE
DIODE
D9
D27
1 1 8 IF4 8 IB4 (* 3)
4 BG2 4 IF1 4 IB2 (* 4)
W–L
W–L
W–L
W–L
(* 2)
B
L
STEP LIGHT
J9
2 JUNCTION
C C CONNECTOR C
C C W–L
S3
1
(* 1)
L
DOOR COURTESY
L–Y
1
SW FRONT LH
D16
116
2003 TOYOTA TUNDRA (EWD491U)
V6
L–Y
VANITY LIGHT LH
W–L
2
1
W–B W–B W–B W–B L–Y
IF
8 1J
2 1A
B4
B4
J3
D29
DIODE
(TVIP)
W–B
V7
JUNCTION
L–Y
2
1
B
B
J4
B B–W VANITY LIGHT RH
J21
CONNECTOR
(* 3) (* 3)
2
1
W–B L–Y
B
B
JUNCTION
JUNCTION
B4
B4
CONNECTOR
CONNECTOR
(*3)
B–W
B
(* 3)
L–Y
W–B
I26
INTERIOR LIGHT
1
W–L B–W B–W B–W
DOOR
8 1B
1 1H
2 IC1
B4
2 L–Y
(* 4)
B4
OFF
ON
B–L
9 1B
(* 3)
1
W–B
B–W
D11
1
C
B–W
DIODE
J5
3
(*4) L–Y
SYSTEM)
2
D18
DOOR COURTESY SW
DOOR
2
REAR LH LOWER B–W
(POWER WINDOW
2
1
W–B B–W (*3)
BJ
(* 2) (* 2)
JUNCTION CONNECTOR
D19
DOOR COURTESY SW
(*2)
REAR LH UPPER
W–B
P8
B8
4 BF2
5 BG2
(* 2) (* 2) (* 2) (*2)
D21
*
*
*
*
DOOR COURTESY SW
REAR RH UPPER
2
1
C
W–B B–W B–W B–W B–W
BK
B9
5 BF2
4 BH1
(* 2) (* 2) (* 2) (* 2) (*2)
C
D20
(* 2)
B–W
2 : ACCESS CAB
DOOR COURTESY SW
(* 2)
REAR RH LOWER
W–B
1 : STANDARD CAB
2
1
B–W
B9
(* 2)
3 : W/ DOOR LOCK CONTROL
4 : W/O DOOR LOCK CONTROL
B–W
D17
DOOR COURTESY (* 2)
SW FRONT RH
1
B–W B–W
(* 1) (*1)
117
INTERIOR LIGHT
SERVICE HINTS
C11 (A), C12 (B) COMBINATION METER
(A) 9–GROUND : Approx. 12 volts with ignition SW at ON or ST position
(B) 5–GROUND : Always approx. 12 volts
(B) 7–GROUND : Continuity with each door open
(B)13–GROUND : Continuity with front LH door open
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 A 34 D17 37 (Standard Cab) J4 35
C12 B 34 D18 36 (Access Cab) J5 35
D9 34 D19 36 (Access Cab) J9 35
D11 34 D20 36 (Access Cab) J21 35
36 (Access Cab) D21 36 (Access Cab) J23 A 35
D14
37 (Standard Cab) D27 34 J24 B 35
36 (Access Cab) D29 34 36 (Access Cab)
D15 P8
37 (Standard Cab) I22 35 37 (Standard Cab)
36 (Access Cab) 36 (Access Cab) S3 35
D16 I26
37 (Standard Cab) 37 (Standard Cab) V6 36 (Access Cab)
D17 36 (Access Cab) J3 35 V7 36 (Access Cab)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1A Roof Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1B Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
22 (*2)
1H Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
118
2003 TOYOTA TUNDRA (EWD491U)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
48 (Access Cab) B8 48 (Access Cab) Rear Door No.1 Wire LH
B4 Roof Wire
50 (Standard Cab) B9 48 (Access Cab) Rear Door No.1 Wire RH
119
2003 TOYOTA TUNDRA (EWD491U)
TURN SIGNAL AND HAZARD WARNING LIGHT
20A 5A
HAZ TURN
G
2
2 5 1J G–B
L–W
22 IA4 1 3
LH
L–W
R–B
I24 TURN
INTEGRATION RH
CONTROL AND
PANEL 4 1 6 5 C15 2
+B IG ER EL TURN SIGNAL SW
T5 [COMB. SW]
W–B
TURN SIGNAL
FLASHER
B1 EHW LL LR GND
17 8 3 2 7
W–B
G–B
G–Y
G–R
7 1D 10 1D
6 1D 9 1D 11 1E 12 1H 13 1H 7 1E 5 1D 11 1D
G–B
G–Y
G–B
G–Y
J14 A , J15 B
C A B A
CONNECTOR
G–B
G–Y
G–B
G–Y
JUNCTION
CONVERTER
TO TOWING
A B B B
G–B
G–Y
[REAR COMB. LIGHT RH]
[REAR COMB. LIGHT LH]
FRONT TURN SIGNAL
3 1 1 3 1 B 12 C
REAR TURN SIGNAL
RH
LH
LIGHT RH
LIGHT RH
LIGHT LH
LIGHT LH
2 3 3 2
R4
R5
W–B
F3
F4
7 A
W–B
W–B
C11 A , C12 B
W–B
W–B
W–B
C13 C
W–B TURN SIGNAL
B10 B10
INDICATOR LIGHT
A [COMB. METER] I2
A W–B
W–B
W–B
A J18
JUNCTION
CONNECTOR A
W–B
W–B
W–B
3 BB2
W–B W–B A A
I1 B A
J23 A , J24 B
JUNCTION
CONNECTOR
CONNECTOR
CONNECTOR
JUNCTION
JUNCTION
A A
W–B
W–B
J13
J3
EA BL IE IF II
120
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
T5 TURN SIGNAL FLASHER
4–GROUND : Always approx. 12 volts
1–GROUND : Approx. 12 volts with ignition SW at ON or ST position
7–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 A 34 I24 35 J18 33 (5VZ–FE)
C12 B 34 J3 35 J23 A 35
C13 C 34 J13 35 J24 B 35
C15 34 36 (Access Cab) 36 (Access Cab)
J14 A R4
30 (2UZ–FE) 37 (Standard Cab) 37 (Standard Cab)
F3
32 (5VZ–FE) 36 (Access Cab) 36 (Access Cab)
J15 B R5
30 (2UZ–FE) 37 (Standard Cab) 37 (Standard Cab)
F4
32 (5VZ–FE) J18 31 (2UZ–FE) T5 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1D Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1H
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1J
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I1 48 (Access Cab)
46 Cowl Wire B10 Frame Wire
I2 50 (Standard Cab)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
121
2003 TOYOTA TUNDRA (EWD491U)
STOP LIGHT
15A
STOP
2 1F
G–Y
S4
STOP LIGHT
SW
1
G–W
C
J10
JUNCTION
CONNECTOR
C
G–W
4 1D
5 1H 3 1D
G–W
J14 A , J15 B
G–W
JUNCTION
A A CONNECTOR
1 IC1
C B C B
G–W
G–W
G–W
HIGH MOUNTED
STOP LIGHT RH
STOP LIGHT LH
4 4
[REAR COMB.
[REAR COMB.
STOP LIGHT
1
LIGHT RH]
LIGHT LH]
H10
R4
R5
2
3 3
W–B
W–B
W–B
W–B 2 1A
B10
8 1J
W–B
W–B
A
J3
JUNCTION
CONNECTOR
BL IF
122
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
S4 STOP LIGHT SW
2–1 : Closed with brake pedal depressed
: PARTS LOCATION
Code See Page Code See Page Code See Page
36 (Access Cab) J14 A 37 (Standard Cab) 36 (Access Cab)
H10 R5
37 (Standard Cab) 36 (Access Cab) 37 (Standard Cab)
J15 B
J3 35 37 (Standard Cab) S4 35
J10 35 36 (Access Cab)
R4
J14 A 36 (Access Cab) 37 (Standard Cab)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1A Roof Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1D
26 (*1)
22 (*2)
1F
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1H
26 (*1)
22 (*2)
1J
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
B10 48 (Access Cab) Frame Wire B10 50 (Standard Cab) Frame Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
123
2003 TOYOTA TUNDRA (EWD491U)
LIGHT AUTO TURN OFF (w/ DAYTIME RUNNING LIGHT)
30A 15A 5A
INTEGRATION RELAY POWER TAIL ECU IG
8 14 9 6 3 2
4 1O 3 1N 4 1N 8 1J 7 1H
R–B
W–B
L
G–Y
(*5)
R
CONNECTOR
CONNECTOR
J21 A , J22 B
C A
JUNCTION
JUNCTION
F CONNECTOR E
E L * 1 : TOWING PACKAGE
G–Y
(* 6)
J4 (* 4) * 3 : STANDARD CAB
F A B E * 4 : ACCESS CAB
* 5 : W/ DOOR LOCK CONTROL
* 6 : W/O DOOR LOCK CONTROL
G–Y
R–B
(* 5)
5 BE2
6 1C
(* 4)
L
LIGHT CONTROL SW
13 14 4 BG2
(* 3)
L
5 1K
OFF
[COMB. SW]
TAIL
R–B
R–B
(* 4)
L
R
HEAD
C15
16
2 2
3 2
H–LP RELAY
5 1
DOOR COURTESY
1
SW FRONT LH
2
D16
W–B
B–L
(*1)
(*2)
B
BATTERY
I2
W–B
W–B
W–B
A A
J13 J3 A
JUNCTION JUNCTION
CONNECTOR CONNECTOR
II IF
124
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM OUTLINE
With the ignition SW turned on, the current flows to TERMINAL 9 of the integration relay through ECU IG fuse.
Voltage is applied at all times to TERMINAL 6 of the integration relay through the TAIL fuse, and through the H–LP relay coil
side.
1. NORMAL LIGHTING OPERATION
<Turn taillight on>
With the light control SW turned to TAIL position, a signal is input into the integration relay. Due to this signal, the current
flowing to TERMINAL 6 of the relay flows to TERMINAL 14 of the light control SW to TERMINAL 16 to GROUND, and
taillights to turn on.
SERVICE HINTS
H–LP RELAY
5–3 : Closed with the light control SW at HEAD position or the dimmer SW at FLASH position
Closed with the engine running and the parking brake lever released
C15 LIGHT CONTROL SW [COMB. SW]
13–16 : Closed with light control SW at HEAD position
14–16 : Closed with light control SW at TAIL or HEAD position
D16 DOOR COURTESY SW FRONT LH
1–GROUND : Continuity with the front LH door open
INTEGRATION RELAY
9–GROUND : Approx. 12 volts with the ignition SW at ON position
14–GROUND : Continuity with the front LH door open
3, 6–GROUND : Always approx. 12 volts
8–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
C15 34 J3 35 J13 35
36 (Access Cab) J4 35 J21 A 35
D16
37 (Standard Cab) J7 35 J22 B 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
1C
1H 26 ((*1)) Cowl Wire and Driver Side J/B (Lower
( Finish Panel))
1J
1K 26 (*1) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1N
27 (*1) Cowl Wire and Driver Side J/B (Lower Finish Panel)
1O
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
125
2003 TOYOTA TUNDRA (EWD491U)
LIGHT AUTO TURN OFF (w/ DAYTIME RUNNING LIGHT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
BE2 48 (Access Cab) Floor No.2 Wire and Cowl Wire (Center of Left Rocker Panel)
BG2 48 (Access Cab) Floor No.2 Wire and Rear Door No.1 Wire LH (Under the Left Quarter Panel)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire
126
2003 TOYOTA TUNDRA (EWD491U)
MEMO
127
2003 TOYOTA TUNDRA (EWD491U)
LIGHT AUTO TURN OFF (w/o DAYTIME RUNNING LIGHT)
8 14 9 6 3 2
6 1L 5 1L 13 1L 8 1J 7 1H
W–B
R–B
L
G–Y
(*5)
R
CONNECTOR
CONNECTOR
J21 A , J22 B
JUNCTION
JUNCTION
F E
G–Y
C A
(* 6)
CONNECTOR
E L * 1: TOWING PACKAGE
* 2: EXCEPT TOWING PACKAGE
JUNCTION
J7
J4 (* 4) * 3: STANDARD CAB
F E * 4: ACCESS CAB
A B * 5: W/ DOOR LOCK CONTROL
* 6: W/O DOOR LOCK CONTROL
G–Y
(* 5)
5 BE2
R–B
(* 4)
L
6 1C
LIGHT CONTROL SW
13 14 4 BG2
(* 3)
L
OFF
5 1K
[COMB. SW]
TAIL
(* 4)
L
R–B
HEAD
C15
16
2 2
3 2
H–LP RELAY
5 1
DOOR COURTESY
1
SW FRONT LH
2
D16
W–B
B–L
(*1)
(*2)
B
BATTERY
I2
W–B
W–B
W–B
A A
J13 J3 A
JUNCTION JUNCTION
CONNECTOR CONNECTOR
II IF
128
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM OUTLINE
With the ignition SW turned on, the current flows to TERMINAL 9 of the integration relay through ECU IG fuse.
Voltage is applied at all times to TERMINAL 6 of the integration relay through the TAIL fuse, and through the H–LP relay coil
side.
1. NORMAL LIGHTING OPERATION
<Turn taillight on>
With the light control SW turned to TAIL position, a signal is input into the integration relay. Due to this signal, the current
flowing to TERMINAL 6 of the relay flows to TERMINAL 14 of the light control SW to TERMINAL 16 to GROUND, and
taillights to turn on.
SERVICE HINTS
H–LP RELAY
5–3 : Closed with the light control SW at HEAD position or the dimmer SW at FLASH position
C15 LIGHT CONTROL SW [COMB. SW]
13–16 : Closed with light control SW at HEAD position
14–16 : Closed with light control SW at TAIL or HEAD position
D16 DOOR COURTESY SW FRONT LH
1–GROUND : Continuity with the front LH door open
INTEGRATION RELAY
9–GROUND : Approx. 12 volts with the ignition SW at ON position
14–GROUND : Continuity with the front LH door open
3, 6–GROUND : Always approx. 12 volts
8–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
C15 34 J3 35 J13 35
36 (Access Cab) J4 35 J21 A 35
D16
37 (Standard Cab) J7 35 J22 B 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
1C
1H 22 ((*2)) Cowl Wire and Driver Side J/B (Lower
( Finish Panel))
1J
1K 22 (*2) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1L 23 (*2) Cowl Wire and Driver Side J/B (Lower Finish Panel)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
129
2003 TOYOTA TUNDRA (EWD491U)
LIGHT AUTO TURN OFF (w/o DAYTIME RUNNING LIGHT)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
BE2 48 (Access Cab) Floor No.2 Wire and Cowl Wire (Center of Left Rocker Panel)
BG2 48 (Access Cab) Floor No.2 Wire and Rear Door No.1 Wire LH (Under the Left Quarter Panel)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire
130
2003 TOYOTA TUNDRA (EWD491U)
MEMO
131
2003 TOYOTA TUNDRA (EWD491U)
TRAILER TOWING
1 1 1
15A STOP
15A TAIL
INTEGRATION
2 2 2
6
2 2 2 1F 2
RELAY
4 5 1E
G–Y
B–Y
(* 1)
B–R
(*1)
4 1G
CONNECTOR
2 C
B–W
L–W
(*1)
JUNCTION
B–W
(* 1)
STOP LIGHT SW
G
J1
1 IA4 J12 C
JUNCTION
B–Y
(* 1)
CONNECTOR E
E G E
S4
(* 1) 2 2
B–R
(*1)
E J10
2 2 JUNCTION 1
(* 1)
CONNECTOR 3 2
G
SUB BATT
3 2 2 5
RELAY
TOW TAIL
+B TAIL
G–W
RELAY
5 1
BRK GND STOP
5 1 1 3 O5 4
OPTION C 2 2
CONNECTOR C G–W
G–W
2 2
(* 1)
(* 1)
(* 1)
BR
L
J10 L
C
B
W–B
R–B
JUNCTION
(*1)
(* 1)
CONNECTOR
G–W
(*1)
CONNECTOR
C C
JUNCTION
J8
12 IA4 20 IA4 1 BB2 JUNCTION 4 IA4
CONNECTOR
J2
C C
R–B
(*1)
G
W–B
(*1)
J21 A , J22 B
* 1 : TOWING PACKAGE
4 BB2 C A 2 BB2
(* 1)
(* 1)
BR
CONNECTOR
L
JUNCTION
J18
A B A
R–B
14
W–B
(* 1)
(* 1)
B
OFF
TAIL
HEAD
BR(*2)
G(* 1)
(* 1)
L
C15 16
LIGHT CONTROL SW
[COMB. SW]
W–B
L(* 1)
G(*1)
BR(* 2)
B
A
(* 1)
(* 1)
BR
J3
W–B
(*1)
JUNCTION
CONNECTOR
IF IH EA
132
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
1 1
30A TOWING
5A TURN
20A HAZ
10A 15A
GAUGE ACC
2 2
11 1G 5 1J 2 2
1 4
7 1F 9 1F IG +B
TURN SIGNAL
(* 3)
GR
FLASHER
L–W
L–W
R–B
B–Y
J8
JUNCTION LL LR
CONNECTOR
CONNECTOR A
T5
3 2
JUNCTION
B–Y E
G–B
G–Y
(* 4)
GR
(* 1)
J9
E A 22 IA4 21 IA4
7 1D 10 1D
B–Y
B–Y
(* 1)
(* 1)
(* 3)
GR
R–B 1 3
B–Y
6 1D 9 1D
(* 1)
G–B
G–Y
D8
DIODE
(A/T)
BACK–UP LIGHT
CONNECTOR
5 1 C 9 3 1
JUNCTION
2 LTIN RTIN +B
RELAY
J12
C
STIN LTOT RTOT GND
B3
R–B
L–B
(* 1)
(* 1)
3 2 8 4 2 T9 6
TOWING CONVERTER
G–W G–W
BR
R
W–B W–B
R–B
(*1)
(* 1) (* 1)
R–B
(*1)
W–B
2 IE1 26 IE1 7 BB1 5 BB2 6 BB2
R–B
(* 1)
R–B
L–B
(*1)
(*1)
BR
R
B10
J23 A , J24 B
(* 1)
3
Y
A B A B
CONNECTOR
JUNCTION
P1
BACK–UP LIGHT SW 3 BK2 3 BK1 1 BK1
[PARK/NEUTRAL
POSITION SW]
2 A A
(*1)
(*1)
(*2)
(*1)
(*2)
BR
G
R
Y
Y
R–B
(* 1)
4 A 3 A 5 A (* 1)
3 B 4 B (* 2)
B/UP STTL STTR T6 A , B
TRAILER
SOCKET
BRK TAIL BATT GND
W–B
7 A 1 A 2 A 6 A (* 1)
2 B 1 B (* 2)
(* 1)
(* 1)
W
B
L
G(*1)
L(* 1)
BR(* 2)
G(*1) 2 BK1
W
BR(* 2)
B
B10
(* 1)
W–B
BL IE
133
2003 TOYOTA TUNDRA (EWD491U)
TRAILER TOWING
SERVICE HINTS
T9 TOWING CONVERTER
1–GROUND : Always approx. 12 volts
6–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
B3 34 J10 35 P1 33 (5VZ–FE)
C15 34 J12 35 S4 35
D8 34 31 (2UZ–FE) T5 35
J18
31 (2UZ–FE) 33 (5VZ–FE) 36 (Access Cab)
J1 A
33 (5VZ–FE) J21 A 35 37 (Standard Cab)
T6
31 (2UZ–FE) J22 B 35 36 (Access Cab)
J2 B
33 (5VZ–FE) J23 A 35 37 (Standard Cab)
J3 35 J24 B 35 T9 35
J8 35 O5 35
J9 35 P1 31 (2UZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1D Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
22 (*2)
1G Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
134
2003 TOYOTA TUNDRA (EWD491U)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
B10 48 (Access Cab) Frame Wire B10 50 (Standard Cab) Frame Wire
135
2003 TOYOTA TUNDRA (EWD491U)
CARGO LIGHT
5A 10A
CARGO GAUGE
LP
11 1L (* 4)
11 1N (* 3)
G–O
5 5 1F 8 1F
INTEGRATION
RELAY
D
J9
11 JUNCTION
CONNECTOR
5 1N (* 3) D
10 1L (* 4) 10 1H
W–R
G–O
R–B
B–Y
B–Y
I24 A , I25 B
INTEGRATION CONTROL
AND PANEL 12 A 3 C 9 A
+B
C11 A , C12 B , C13 C
COMBINATION METER
SPEEDOMETER
GND L
1 B 9 A
R–B
2 1D 8 B 13 C 2 C
2
1H
7 1A
G–B
R–L
P–L
P–L
(* 1)
(* 2)
(* 2)
(* 1)
B–Y
BR
R–B
R–L
P–L
P–L
(* 1)
(* 2)
(* 2)
(* 1)
W–B
B–Y
[HIGH MOUNTED
STOP LIGHT]
2
W–B
2 3
C
J8
2 1A JUNCTION
CONNECTOR
1
C
8 1J
W–B
V2
VEHICLE SPEED SENSOR
BR
(COMBINATION METER)
A A * 1 : 2UZ–FE
J13 J3 * 2 : 5VZ–FE
A W–B A * 3 : W/ DAYTIME RUNNING LIGHT
JUNCTION JUNCTION
CONNECTOR CONNECTOR * 4 : W/O DAYTIME RUNNING LIGHT
II IF IH
136
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
I24 (A), I25 (B) INTEGRATION CONTROL AND PANEL
(B) 1–GROUND : Always continuity
(A)12–GROUND : Always. approx. 12 volts
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 A 34 I24 A 35 J13 35
C12 B 34 I25 B 35 31 (2UZ–FE)
V2
C13 C 34 J3 35 33 (5VZ–FE)
36 (Access Cab) J8 35
H10
37 (Standard Cab) J9 35
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1A Roof Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1D
26 (*1)
22 (*2)
1F
26 (*1)
22 (*2)
1H Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
1L 23 (*2)
1N 27 (*1)
: GROUND POINTS
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
137
2003 TOYOTA TUNDRA (EWD491U)
INTEGRATION CONTROL AND PANEL
10A 10A
GAUGE A/C
2
5 1F 9 1F B–Y
B–Y
B–Y
5
W–L
+
E E
J8
JUNCTION M
SERVO MOTOR
2 IA5
B–Y
B–Y
B–Y
DEFROSTER SW
A15
[BLOWER SW]
Y–B 6
(* 1)
W–L
B6
(* 1) 2 1
7
B–W
B
B–L
9 A 11 B 8 A 3 B 2 B 9 B 4 B 15 A 13 A 12 B
IND2 IND1 L IG FRS REC B
C11 A , C12 B , C14 D
I24 A , I25 B
COMBINATION METER
4HI
L–W
(* 2)
(* 2)
O
W–L
L–R
(* 2)
(* 1)
10 B 1 D
(* 1)
P
W–L
L–R
(* 2)
(* 1)
L–W
(* 2)
(* 2)
O
BR–Y
Y–B
(*1)
(*1)
3 A (* 1)
1 B (* 2)
2
21 20 7 4
A/C DUAL PRESSURE
A/C MAGNETIC
SW
A1
F7 A2 B , A3 A 1
4WD CONTROL ECU
A/C MAGNETIC
CLUTCH
138
2003 TOYOTA TUNDRA (EWD491U)
* 1 : 2UZ–FE FROM POWER SOURCE SYSTEM (SEE PAGE 56)
* 2 : 5VZ–FE
* 3 : 5VZ–FE A/T
* 4 : 5VZ–FE M/T 1
* 5 : W/ DAYTIME RUNNING LIGHT
* 6 : W/O DAYTIME RUNNING LIGHT
10A 15A
DOME ACC
2 10 1G
R2 B
L–Y
T5
RADIO AND TURN SIGNAL
PLAYER FLASHER
6 1E
1 ACC EHW
A/C THERMISTOR
3 B 8
4 1F
GR
MANUAL ON–OFF SW
PASSENGER AIRBAG
1
L–Y
A13
J23 A , J24 B
2
CONNECTOR
B A
JUNCTION
W–G
B–L
(*2)
(*2)
2
P4
G–R
C B
GR
W–R
W–B
L–Y
R
20 A 10 A 14 B 17 A 3 A 1 A 5 B 13 B 12 A
IN E ACC1 B1 PIND GND1 B ACC +B
I24 A , I25 B
INTEGRATION CONTROL AND PANEL
AIND(* 1) A/CM(* 1)
ACT(*2) AC1(* 2) A/CS BKLD GND IL–1 ILL– ILL+ L
18 A 19 A 21 A 16 A 1 B 7 B 8 B 7 A 9 A
B–R
G–W
W–G
G
L–B
L–Y
(* 1)
R–B
SEAT BELT WARNING OCCUPANT
1
W–B
3
33 B 2 B 31 B (* 1)
3 A 9 A (* 2)
ACLD(*1) ACMG(* 1) A/CS BUCKLE
ACT(* 2) AC1(* 2) SW
S5
B–L
G
2
W–G
E3 A , E4 B
ENGINE CONTROL 8 G–W
MODULE
RBE+
W–B
W–B
C6
CENTER
CONNECTOR
AIRBAG
JUNCTION
SENSOR A
ASSEMBLY
A W–B W–B
I2
J13
IH II
139
2003 TOYOTA TUNDRA (EWD491U)
INTEGRATION CONTROL AND PANEL
E3 A
15A 5A
TAIL CARGO D10 ENGINE CONTROL
LP DIODE MODULE
(IDLE–UP)
1 2 G–Y 12
A ELS
(* 1)
6 5 G
(*1)
G
INTEGRATION RELAY J10
E JUNCTION CONNECTOR E
E
11 4 E E E E
5 1N (*5) 4 1N (* 5)
10 1L (*6) 13 1L (* 6) 10 1H 4 1G
R–B
W–R
G
G
R–B
J21 A , J22 B
C A
METER ILLUMINATION
CONNECTOR
JUNCTION
[COMB. METER]
1
STEERING SW
2 1D 15 B
[COMB. SW]
A B 1
RHEOSTAT
C12 B
C16
R3
4
2 1H 7 1A 2 3 14 B
R–B
R–B
R–B
BR
[HIGH MOUNTED
CARGO LIGHT
STOP LIGHT]
3 5 IE1 (* 1)
W–G
W–G
R–B
W–B
17 IE1 (* 2)
H10
2
14
LIGHT CONTROL SW
W–B
OFF
[COMB. SW]
TAIL
2 1A
HEAD
C15
(* 1)
(* 2)
BR
BR
16
8 1J E
W–B
E
G
E J5
W–G JUNCTION
CONNECTOR
G–W G–W
W–B
W–B
W–B
A
W–B A J3
JUNCTION
CONNECTOR
IF EC ED
140
2003 TOYOTA TUNDRA (EWD491U)
* 1 : 2UZ–FE
* 2 : 5VZ–FE
* 5 : W/ DAYTIME RUNNING LIGHT
* 6 : W/O DAYTIME RUNNING LIGHT
J12
E JUNCTION CONNECTOR
E
E E E E
G
G
5 ID2 6 ID2
G
G
MIRROR HEATER SW
CIGARETTE LIGHTER
GLOVE BOX
R1 A , R2 B
10 B
ILLUMINATION
ILLUMINATION
2 1 2 1
ASHTRAY
LIGHT
G3
A18
M4
C8
1 3 1 2
5 A
W–G
W–G
4 ID2 3 ID2
G–W
W–G
W–G
W–G
W–B
W–B
I1
E E E
W–B
J5
JUNCTION
CONNECTOR
G–W A B
J23 A , J24 B
W–B JUNCTION
CONNECTOR
A B
W–B
IE
141
2003 TOYOTA TUNDRA (EWD491U)
INTEGRATION CONTROL AND PANEL
SYSTEM OUTLINE
The integration control panel is composed by design components such as the cluster, resistor, heater control panel, and SW.
The integration control panel controls systems such as the air conditioning, cargo light, 4WD (2UZ–FE) and hazard warning
light, clock, and the SRS.
SERVICE HINTS
I24 (A), I25 (B) INTEGRATION CONTROL AND PANEL
(B)12–GROUND : Approx. 12 volts with ignition SW on and blower SW on
(B) 4–GROUND : Approx. 12 volts with ignition SW at ON or ST position
(B) 5–GROUND : Always approx. 12 volts
(B)13–GROUND : Approx. 12 volts with ignition SW at ACC or ON position
(B) 1–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
30 (2UZ–FE) C16 34 J12 35
A1
32 (5VZ–FE) D10 34 J13 35
A2 B 32 (5VZ–FE) E3 A 34 J21 A 35
A3 A 30 (2UZ–FE) E4 B 34 J22 B 35
A13 34 F7 35 J23 A 35
A15 34 G3 35 J24 B 35
A18 34 36 (Access Cab) M4 35
H10
B6 34 37 (Standard Cab) P4 35
C6 34 I24 A 35 R1 A 35
C8 34 I25 B 35 R2 B 35
C11 A 34 J3 35 R3 35
C12 B 34 J5 35 36 (Access Cab)
S5
C14 D 34 J8 35 37 (Standard Cab)
C15 34 J10 35 T5 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1A Roof Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1D Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
22 (*2)
1G
26 (*1)
22 (*2)
1H Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
1L 23 (*2)
1N 27 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
142
2003 TOYOTA TUNDRA (EWD491U)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
IA4
44 Engine Room Main Wire and Cowl Wire (Left Kick Panel)
IA5
ID2 46 Cigarette Lighter Wire and Cowl Wire (Instrument Panel Brace LH)
IE1
IE2 46 Engine
g Wire and Cowl Wire (Right
( g Side of Instrument Panel))
IE3
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I1 46 Cowl Wire I2 46 Cowl Wire
143
2003 TOYOTA TUNDRA (EWD491U)
ELECTRONICALLY CONTROLLED TRANSMISSION AND A/T INDICATOR
15A 15A 5A
EFI STOP STA
NO. 1
2 2 1F 6 1F
B–R
B–R G–Y
2 2 2
STOP LIGHT SW
B–W B–W
2 3 I3 I3 I3
EFI RELAY
P
B–R
B–Y
S4
B–W
B–W
B–W
P
PARK/NEUTRAL
9
POSITION SW
1
1 5 P
G–W
CONNECTOR
P1
2 2
JUNCTION
C
6
W–B
W–L
TO STARTER RELAY(*2)
CONNECTOR
J10
W–B
B 1 1
ENGINE COOLANT
C
TO TVIP ECU(*1)
TEMP. SENSOR
CONNECTOR
G–W
J1
JUNCTION
A
B
W–L
J20
4 1D 2 2
E2
A A
A4
15 IA4 14 IA4 6 IA4
15 IE1
1 1D
G–W
B–W
W–B
W–B
W–L
B–R
B–Y
R–L
G
B
3 A 19 B 12 C 17 E 9 D 16 E 32 D 28 E 19 E
BATT STP STSW STA STAR NSW THOC E2 THW
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
G–R
W–L
W–L
W–L
V
B–R
B–Y
P–L
A I5 2 6 4 8 7 1
SPEED SENSOR
J18
JUNCTION
CONNECTOR
ELECTRONICALLY CONTROLLED
W
O
A
TRANSMISSION SOLENOID
O1
2
NO. 1
NO. 2
NO. 3
SLT
W–B
E1
EA
144
2003 TOYOTA TUNDRA (EWD491U)
(2UZ–FE)
FROM POWER SOURCE SYSTEM (SEE PAGE 56) * 1 : W/ DOOR LOCK CONTROL
* 2 : W/O DOOR LOCK CONTROL
B–Y
5A 15A 10A
IGN ACC GAUGE
L–B
8
1F
11 1F 5 1F 11 1G 9 1F J8
JUNCTION D8
CONNECTOR DIODE (A/T)
B–Y E E B–Y 1 2
J9
B–W JUNCTION
CONNECTOR
GR(*1) A A GR(*1) 3
3
GR(*2)
B–O
B–Y
THROTTLE POSITION
B–Y
R–B
SENSOR
M– M+ L
T2
CONNECTOR
B
1 2 4 6 5
JUNCTION
LG
(SHIELDED)
W–R
R
J5
I3
J9
JUNCTION
CONNECTOR
W–R
G–O
G–B
B–O
B–Y
R–B
P–L
BR
LG
L
Y–R
17 C 2 C 3 C 31 E 21 E 18 E 9 A 11 B 9 B 8 B 10 B 17 B 25 B
GE01 M– M+ VTA2 VTA VC IGSW R 2 L D SPD OILW
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
Y–R
3
O/D MAIN SW
(ELECTRONICALLY CONTROLLED
W–B
W–B
W–B
W–B
BR
O4
2
VEHICLE SPEED SENSOR
1
W–B
TRANSMISSION)
L–O
V3
W–B
EB EC
145
2003 TOYOTA TUNDRA (EWD491U)
ELECTRONICALLY CONTROLLED TRANSMISSION AND A/T INDICATOR
B–Y
26
L–B L–B
IE1
P1
A/T INDICATOR SW
3 [PARK/NEUTRAL POSITION SW]
RB
LL 2L DL NL RL PL
8 4 7 5 2 1
LG–B
W–R
R–B
B–Y
L–Y
LG
L
11 IE1 20 IE1 6 IE1 10 IE1 2 IE1 19 IE1
B–Y 7 IE1
LG–B
W–R
R–B
LG
L
R–B
B–Y
L
R–B
CONNECTOR
CONNECTOR
LG
JUNCTION
JUNCTION
B C C
W–R B
J12
J8
L–Y
LG
B C
G–O
CONNECTOR
A B A B
JUNCTION
CONNECTOR
JUNCTION
C
J12
J11
Y–R
A B
C
LG–B
G–O
W–R
R–B
LG
O/D OFF
L 2 D N R P
COMBINATION METER
10 D 3 D 8 B 13 C 2 C 7 A
R–L
P–L
BR
Y–R
9 IE1 17 IE1
W–B
R–L
P–L
VEHICLE SPEED SENSOR
(COMBINATION METER)
2 3
CONNECTOR
JUNCTION
L–O 1 B–Y
J8
V2
J23 A , J24 B
JUNCTION
CONNECTOR
IH IE
146
2003 TOYOTA TUNDRA (EWD491U)
(2UZ–FE)
SYSTEM OUTLINE
The electronically controlled transmission electrically controls the, throttle pressure, lock–up pressure, and accumulator
pressure etc. through the solenoid valve.
The electronically controlled transmission is a system which precisely controls the gear shift timing and lock–up timing in
response to the vehicle’s driving conditions and the engine condition detected by various sensors. It makes smooth driving
possible by shift selection of the gear which is the most appropriate to the driving conditions at that time, and by preventing
downing, squat and gear shift shock when starting off.
1. GEAR SHIFT OPERATION
When driving, the engine warm up condition is input as a control signal from the engine coolant temp. sensor to TERMINAL
THW of the engine control module, and the vehicle speed is input to TERMINAL SP2+ of the engine control module from the
vehicle speed sensor. At the same time, the throttle valve opening signal from the throttle position sensor is input to
TERMINALS VTA, VTA2 of the engine control module as a throttle angle signal. Based on these signals, the engine control
module selects the best shift position for the driving conditions and sends current to the electronically controlled transmission
solenoid.
2. LOCK–UP OPERATION
When the engine control module decides based on each signal that the lock–up condition has been met, the current flows
from the engine control module TERMINAL SL to TERMINAL 7 of the electronically controlled transmission solenoid to
GROUND.
3. STOP LIGHT SW CIRCUIT
If the brake pedal is depressed (Stop light SW on) when driving in lock–up position, a signal is input to TERMINAL STP of
the engine control module. As a result, the engine control module cuts the current to the solenoid to release the lock–up.
4. OVERDRIVE CIRCUIT
∗ O/D main SW on
When the O/D main SW is switched to ON position, a signal is input to TERMINAL ODMS of the engine control module,
and enables shift change to the overdrive range, through the control of the engine control module.
∗ O/D main SW off
When the O/D main SW is switched to OFF position, a signal is input to TERMINAL ODMS of the engine control module,
and prohibits shift change to the overdrive range through the control of the engine control module. When in the overdrive
range already, shift down is made.
147
2003 TOYOTA TUNDRA (EWD491U)
ELECTRONICALLY CONTROLLED TRANSMISSION AND A/T INDICATOR
SERVICE HINTS
E1 ELECTRONICALLY CONTROLLED TRANSMISSION SOLENOID
4, 7, 8-GROUND : Approx. 13 Ω
O4 O/D MAIN SW
3–1 : Open with O/D main SW at ON position
Closed with O/D main SW at OFF position
S4 STOP LIGHT SW
1–2 : Closed with brake pedal depressed
E3(A), E4 (B), E5 (C), E6 (D), E7 (E) ENGINE CONTROL MODULE
S1-E1 : 9-14 volts with vehicle not move and shift lever in D position
S2,SL-E1 : 0-1.5 volts with vehicle not move
STP–E1 : 7.5–14 volts with brake pedal depressed
: 0–1.5 volts with brake pedal released
THW–E1 : 0.2–1.0 volts with idling, engine coolant temp. 60°C (140°F)–120°C (248°F)
THOC–E1 : Below 1.0 volts with fluid temp. 110°C (230°F)
VTA–E1 : 0.4–1.0 volts with ignition SW on and throttle valve fully closed
: 3.2–4.8 volts with ignition SW on and throttle valve fully open
VC–E1 : 4.5–5.5 volts with ignition SW at ON or ST position
ODMS–E1 : 9–14 volts with O/D main SW turned on
: 0–3 volts with O/D main SW turned off
SPD–E1 : Pulse generation with vehicle moving
2–E1 : 7.5–14 volts with shift lever at 2 position
: 0–1.5 volts with shift lever at except 2 position
L–E1 : 7.5–14 volts with shift lever at L position
: 0–1.5 volts with shift lever at except L position
+B–E1 : 9–14 volts with ignition SW at ON or ST position
BATT–E1 : Always 9–14 volts
P1 A/T INDICATOR SW [PARK/NEUTRAL POSITION SW]
3–1 : Closed with shift lever in P position
3–2 : Closed with shift lever in R position
3–5 : Closed with shift lever in N position
3–7 : Closed with shift lever in D position
3–4 : Closed with shift lever in 2 position
3–8 : Closed with shift lever in L position
: PARTS LOCATION
Code See Page Code See Page Code See Page
A4 30 (2UZ–FE) E6 D 34 J23 A 35
C11 A 34 E7 E 34 J24 B 35
C12 B 34 J1 31 (2UZ–FE) O1 31 (2UZ–FE)
C13 C 34 J5 35 O4 35
C14 D 34 J8 35 P1 31 (2UZ–FE)
D8 34 J9 35 S4 35
E1 30 (2UZ–FE) J10 35 T2 31 (2UZ–FE)
E2 30 (2UZ–FE) J11 35 V2 31 (2UZ–FE)
E3 A 34 J12 35 V3 31 (2UZ–FE)
E4 B 34 J18 31 (2UZ–FE)
E5 C 34 J20 35
: RELAY BLOCKS
148
2003 TOYOTA TUNDRA (EWD491U)
(2UZ–FE)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1D
26 (*1)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1G
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire I5 46 Cowl Wire
I3 46 Engine Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
149
2003 TOYOTA TUNDRA (EWD491U)
ELECTRONICALLY CONTROLLED TRANSMISSION AND A/T INDICATOR
15A 15A 5A
EFI STOP STA
NO. 1
W
2
2 2 1F 6 1F
2 2
B–Y
B–R
G–Y
B–R W–B W–B
5 2
2
ST RELAY
2 2
STOP LIGHT SW
19 IE2
2 3
B–W B–W
W–B
3 1
B
I3 I3
EFI
S4
RELAY
PARK/NEUTRAL
6
B–W
B–W
B–W
2
POSITION SW
1
T13 C
1 5 P
G–W
TVIP ECU
1 EF1
CONNECTOR
P1
G–R
2 2
JUNCTION
C
9
BR–B
SRLY ST
J10
W–L
P
8 C 3 C
24 IA4 12 IE2 2 1
ENGINE COOLANT
JUNCTION
TEMP. SENSOR
B
G–R
(* 3)
(* 3)
G–W
P
J1
(* 4)
B
P
P
4 1D 1 2
E2
A4
G–Y
W–B
W–L
B–R
B–Y
CONNECTOR
A
JUNCTION
1 1D A
R–Y
15 IA4 14 IA4 6 IA4 2 EF1
J8
A
B
B–W
G–Y
G–W
W–L
B–R
B–Y
1 A 16 A 20 A 7 A 3 B 19 E 11 E 18 E
+B BATT STP STA NSW OIL E2 THW
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
G–W
G–R
W–L
B–R
R
CONNECTOR
JUNCTION
A 2 6 4 8 7
ELECTRONICALLY CONTROLLED
W
J18
TRANSMISSION SOLENOID
A
NO. 1
NO. 2
SL
W–B
E1
EA
150
2003 TOYOTA TUNDRA (EWD491U)
(5VZ–FE)
5A 15A 10A
IGN ACC GAUGE
L–B
8
1F
11 1F 5 1F 11 1G 9 1F J8
JUNCTION D8
W–B CONNECTOR DIODE (A/T)
B–Y E E B–Y 1 2
T2
B–O
(*1)
THROTTLE POSITION J9
SENSOR JUNCTION
JUNCTION CONNECTOR
CONNECTOR
B–W 1 GR(*3) A A GR(*3) 3
B GR(*4)
B–Y B–Y
2 3 4 B
R–B
J5
W–R
B–O
B–O
R–B
G–B
B–Y
(* 1)
(* 2)
LG
G–O D D G–O
J9
JUNCTION
CONNECTOR
W–R
G–O
B–O
R–B
G–B
R–B
B–Y
(* 1)
LG
L
4 C 15 E 25 E 15 A 6 B 25 B 5 B 4 B 6 A
VTA2 VTA VC IGSW R D 2 L SP1
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
SP2– SP2+ E1 E04 E02 E03 E01 ME01 ODMS OILW ODLP
22 D 23 D 17 D 8 E 5 E 7 E 4 E 6 D 14 B 21 B 20 B
W–R
W–B
W–B
W–B
W–B
W–B
Y–R
Y–R
L–O
BR
BR
3 A B
O/D MAIN SW
J23 A , J24 B
JUNCTION
(ELECTRONICALLY CONTROLLED
CONNECTOR
O4
A A
2
VEHICLE SPEED SENSOR
1
W–B
W–B
TRANSMISSION)
L–O
1
Y–R
V3
W–B
BR
ED IE
151
2003 TOYOTA TUNDRA (EWD491U)
ELECTRONICALLY CONTROLLED TRANSMISSION AND A/T INDICATOR
B–Y B–Y
4
L–B L–B
IE1 P1
A/T INDICATOR SW
3 [PARK/NEUTRAL POSITION SW]
RB
LL 2L DL NL RL PL
8 4 7 5 2 1
LG–B
W–R
R–B
B–Y
LG
L–Y
B–Y
W–R
L
W–R
W–R
R–B
B–Y
L–Y
LG
LG
CONNECTOR
CONNECTOR
JUNCTION
JUNCTION
B C C
G–O B
LG
J12
J8
B C
CONNECTOR
A B A B
JUNCTION
J12
LG–B
W–R
R–B
A B
LG
G–O
SPEEDOMETER
L 2 D N R P
O/D OFF
COMBINATION METER
10 D 3 D 8 B 13 C 2 C 7 A
G–B
P–L
BR
Y–R
3 IE2 25 IE2
W–B
G–B
P–L
VEHICLE SPEED SENSOR
(COMBINATION METER)
2 3
CONNECTOR
JUNCTION
C
L–O
1 B–Y
J8
Y–R
V2
J23 A , J24 B
JUNCTION
CONNECTOR
IH IE
152
2003 TOYOTA TUNDRA (EWD491U)
(5VZ–FE)
SYSTEM OUTLINE
Previous automatic transmissions have selected each gear shift using mechanically controlled throttle hydraulic pressure,
governor hydraulic pressure and lock-up hydraulic pressure. The electronically controlled transmission, however, electrically
controls the governor pressure and lock-up sensor through the solenoid valve. Control of the solenoid valve by the engine
control module based on the input signals from each sensor makes smooth driving possible by shift selection for each gear
which is most appropriate to the driving conditions at that time.
1. GEAR SHIFT OPERATION
During driving, the engine control module selects the shift for each gear which is most appropriate to the driving conditions,
based on input signals from the engine coolant temp. sensor to TERMINAL THW of the engine control module and also the
input signals to TERMINAL SP2+ of the engine control module from the vehicle speed sensor devoted to the electronically
controlled transmission. Current is then output to the electronically controlled transmission solenoid. When shifting to 1st
speed, current flows from TERMINAL S1 of the engine control module to TERMINAL 4 of the electronically controlled
transmission solenoid to GROUND, and continuity to the No.1 solenoid causes the shift.
For 2nd gear, current flows from TERMINAL S1 of the engine control module to TERMINAL 4 of the electronically controlled
transmission solenoid to GROUND, and from TERMINAL S2 of the engine control module to TERMINAL 8 of the
electronically controlled transmission solenoid to GROUND. And continuity to solenoid No.1 and No.2 causes the shift.
For 3rd gear, there is no continuity to No.1 solenoid, only to No.2 causing the shift. Shifting into 4th gear (Overdrive) takes
place when there is no continuity to either No.1 or No.2 solenoid.
2. LOCK-UP OPERATION
When the engine control module judges from each signal that lock-up operation conditions have been met, current flows
from TERMINAL SL of the engine control module to TERMINAL 7 of the electronically controlled transmission solenoid to
GROUND, causing continuity to the lock-up solenoid and causing lock-up operation.
3. STOP LIGHT SW CIRCUIT
If the brake pedal is depressed (Stop light SW on) when driving in lock–up position, a signal is input to TERMINAL STP of
the engine control module. As a result, the engine control module cuts the current to the solenoid to release the lock–up.
4. OVERDRIVE CIRCUIT
∗ O/D main SW on
When the O/D main SW is switched to ON position, a signal is input to TERMINAL ODMS of the engine control module,
and enables shift change to the overdrive range, through the control of the engine control module.
∗ O/D main SW off
When the O/D main SW is switched to OFF position, a signal is input to TERMINAL ODMS of the engine control module,
and prohibits shift change to the overdrive range through the control of the engine control module. When in the overdrive
range already, shift down is made.
153
2003 TOYOTA TUNDRA (EWD491U)
ELECTRONICALLY CONTROLLED TRANSMISSION AND A/T INDICATOR
SERVICE HINTS
E1 ELECTRONICALLY CONTROLLED TRANSMISSION SOLENOID
4, 7, 8-GROUND : Approx. 13 Ω
O4 O/D MAIN SW
3–1 : Open with O/D main SW at ON position
Closed with O/D main SW at OFF position
S4 STOP LIGHT SW
1–2 : Closed with brake pedal depressed
E3(A), E4 (B), E6 (C), E7 (D) ENGINE CONTROL MODULE
S1-E1 : 9-14 volts with vehicle not move and shift lever in D position
S2,SL-E1 : 0-1.5 volts with vehicle not move
STP–E1 : 7.5–14 volts with brake pedal depressed
: 0–1.5 volts with brake pedal released
THW–E1 : 0.2–1.0 volts with idling, engine coolant temp. 60°C (140°F)–120°C (248°F)
VTA–E1 : 0.3–1.0 volts with ignition SW on and throttle valve fully closed
: 3.2–4.9 volts with ignition SW on and throttle valve fully open
VC–E1 : 4.5–5.5 volts with ignition SW at ON or ST position
ODMS–E1 : 9–14 volts with O/D main SW turned on
: 0–3 volts with O/D main SW turned off
SP1–E1 : Pulse generation with vehicle moving
2–E1 : 7.5–14 volts with shift lever at 2 position
: 0–1.5 volts with shift lever at except 2 position
L–E1 : 7.5–14 volts with shift lever at L position
: 0–1.5 volts with shift lever at except L position
+B–E1 : 9–14 volts with ignition SW at ON or ST position
BATT–E1 : Always 9–14 volts
OIL–E2 : 0.1–0.9 volts after engine warm up
OILW–E1 : 0–1.5 volts with engine cranking at 400 rpm or more
P1 A/T INDICATOR SW [PARK/NEUTRAL POSITION SW]
3–1 : Closed with shift lever in P position
3–2 : Closed with shift lever in R position
3–5 : Closed with shift lever in N position
3–7 : Closed with shift lever in D position
3–4 : Closed with shift lever in 2 position
3–8 : Closed with shift lever in L position
: PARTS LOCATION
Code See Page Code See Page Code See Page
A4 32 (5VZ–FE) E5 C 34 J23 A 35
C11 A 34 E6 D 34 J24 B 35
C12 B 34 E7 E 34 O4 35
C13 C 34 J1 33 (5VZ–FE) P1 33 (5VZ–FE)
C14 D 34 J5 35 S4 35
D8 34 J8 35 T2 33 (5VZ–FE)
E1 32 (5VZ–FE) J9 35 T13 C 35
E2 32 (5VZ–FE) J10 35 V2 33 (5VZ–FE)
E3 A 34 J12 35 V3 33 (5VZ–FE)
E4 B 34 J18 33 (5VZ–FE)
: RELAY BLOCKS
154
2003 TOYOTA TUNDRA (EWD491U)
(5VZ–FE)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1D
26 (*1)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1G
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire I3 46 Engine Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
155
2003 TOYOTA TUNDRA (EWD491U)
ABS
D6 10A 5A
GAUGE ECU IG
DATA LINK CONNECTOR 3
TC TS SIL 5 1F 3 1K
13 12 7
W–G
B–Y
W
Y
D 9 A
J5
JUNCTION 7 EA1
C11 A , C13 C
D
[COMB. METER]
B–R
B–Y
R–L
Y
7 C
B–L
1 17 7 3 11 6
6 EA1 3 EA1 +BS +BM TS D/G WA IG1
A5
ABS ACTUATOR WITH ECU
B–R
B–Y
2 2
2 2 D
LG
P
L
W–G D
40A ABS2
40A ABS3
J8
JUNCTION
CONNECTOR
2
LG
P
L
B–L
(* 1)
(* 2)
B
2 1 2 1
A6 A7
ABS SPEED SENSOR ABS SPEED SENSOR
FRONT LH FRONT RH
BATTERY
156
2003 TOYOTA TUNDRA (EWD491U)
* 1 : TOWING PACKAGE FROM POWER SOURCE SYSTEM (SEE PAGE 56)
* 2 : EXCEPT TOWING PACKAGE
15A
STOP
2 1F
(TRANSFER L4 POSITION)
TO DETECTION SW
G–Y
L–R
14 2
EXI
STOP LIGHT SW
A5
ABS ACTUATOR WITH ECU
S4
RL+ RL– RR+ RR– GND1 GND2 STP
1
5 4 19 20 2 18 24
G–W
W
R
W–B
CONNECTOR
W
R
2 1 4 3
LH RH
A19
ABS SPEED SENSOR REAR
A A
J13
JUNCTION
CONNECTOR
II
157
2003 TOYOTA TUNDRA (EWD491U)
ABS
SYSTEM OUTLINE
This system controls the respective brake fluid pressures acting on the disc brake cylinders of the right front wheel, left front
wheel, and rear wheels when the brakes are applied in a panic stop so that the wheels do not lock.
This results in improved directional stability and steerability during panic braking.
1. INPUT SIGNAL
(1) Speed sensor signal
The speed of the wheels is detected and input to TERMINALS FL+, FR+, RL+ and RR+ of the ABS actuator with ECU.
(2) Stop light SW signal
A signal is input to TERMINAL STP of the ABS actuator with ECU when the brake pedal is depressed.
2. SYSTEM OPERATION
During sudden braking, the ABS actuator with ECU which has signals input from each sensor lets the hydraulic pressure
acting on each wheel cylinder escape to the reservoir.
The pump inside the ABS actuator with ECU is also operating at this time and it returns the brake fluid from the reservoir to
the master cylinder, thus preventing locking of vehicle wheels.
If the ABS actuator with ECU judges that the hydraulic pressure acting on the wheel cylinder is insufficient, the current acting
on the solenoid is controlled and the hydraulic pressure is increased.
Holding of the hydraulic pressure is also controlled by the ECU, by the same method as above, by repeated pressure
reduction. Holding and increase are repeated to maintain vehicle stability and to improve steerability during sudden braking.
SERVICE HINTS
A6, A7 ABS SPEED SENSOR FRONT LH, RH
1–2 : 0.92–1.22 kΩ (20°C, 68°F)
A19 ABS SPEED SENSOR REAR
1–2 : 0.89–1.29 kΩ (20°C, 68°F)
3–4 : 0.89–1.29 kΩ (20°C, 68°F)
A5 ABS ACTUATOR WITH ECU
6–GROUND : 10–14 volts with ignition SW at ON or ST position
24–GROUND : 10–14 volts with stop light SW on (Brake pedal depressed)
2, 18–GROUND : Always continuity
S4 STOP LIGHT SW
2–1 : Closed with brake pedal depressed
: PARTS LOCATION
Code See Page Code See Page Code See Page
30 (2UZ–FE) 36 (Access Cab) J8 35
A5 A19
32 (5VZ–FE) 37 (Standard Cab) J10 35
30 (2UZ–FE) C11 A 34 J13 35
A6
32 (5VZ–FE) C13 C 34 S4 35
30 (2UZ–FE) D6 34
A7
32 (5VZ–FE) J5 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1K Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
158
2003 TOYOTA TUNDRA (EWD491U)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
40 (2UZ–FE)
EA1 Cowl Wire and Engine Room Main Wire (Right Fender)
42 (5VZ–FE)
48 (Access Cab)
BB1 Frame Wire and Cowl Wire (Under the Driver’s Seat)
50 (Standard Cab)
: GROUND POINTS
159
2003 TOYOTA TUNDRA (EWD491U)
CRUISE CONTROL (2UZ–FE)
1 1
2 2
2 11 1F 2 1F 2
B–O
W–G
B–O
G–Y
CONNECTOR
JUNCTION
B 3 2
B
J5 1 IA5
S4
B–R
B–R
B–R
B–Y
B STOP LIGHT
B–Y
SW
W–G
4 1
G–W C J10
JUNCTION
CONNECTOR
C
G–W
4
15 IA4 6 IA4
L–B
1D
B–O
B–R
B–Y
1 1D
2 2
G–W
3 2
EFI RELAY
8 A 3 A 9 A 12 B 19 B 6 B
MREL BATT IGSW ST1– STP +BM
5 1 E3 A , E4 B , E5 C , E6 D , E7 E
2 A 1 A 4 C 7 C 6 E 7 E 1 C 28 E 21 E 31 E 18 E 2 C 3 C 17 C
BR
W–B
W–B
W–B
W–B
B–W
W–L
W–L
G–B
B–Y
P–L
BR
I3
I5
(SHIELDED)
W
R
W–L
CONNECTOR
A
JUNCTION
6 4 5 1 2
J18
A 14 IA4
THROTTLE POSITION
W–L
SENSOR
T2
B
3
W–L B
BR
J1
JUNCTION
CONNECTOR B–W
BR BR
W–B
W–B
W–B
W–B
W–B
I3
BR
EA EB EC
160
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
L–B 2 3 GR(*2)
J9
JUNCTION
CONNECTOR
GR(*1) A A 15A 10A
ACC GAUGE
26 IE1
DIODE (A/T)
L–B
1 B–Y E E
D8
J8
3 JUNCTION 11 1G 9 1F 5 1F 8 1F
CONNECTOR
P1 GR(*2)
D POSITION SW
[PARK/NEUTRAL
POSITION SW] GR(*1)
7 * 1 : W/ DOOR LOCK CONTROL B–Y
* 2 : W/O DOOR LOCK CONTROL
B–Y
B–Y
W–R
J9
JUNCTION
CONNECTOR
6 IE1 G–O D D G–O
W–R
B–R
B 9 C 3 C 9 A
J8
JUNCTION
CONNECTOR CRUISE
COMBINATION METER
W–R
G–O
SPEEDOMETER
10 B 17 B 13 B
D SPD PI
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE 8 B 13 C 2 C
B–Y
P–L
L–Y
26 A 27 A 29 A 22 A 23 A 28 A 24 B
G
LG–R
G–R
P–G
R–G
V–R
L
P–L
L–Y
BR
5
CCS
4 1 2 6 3 5 2 3
CRUISE
RES/
ACC
SET/
COAST
V2 1
A20 VEHICLE SPEED
ACCEL PEDAL POSITION SENSOR SENSOR
CANSEL (COMBINATION
B–Y
METER)
C
ECC J8
JUNCTION
4 C16 CONNECTOR
CRUISE CONTROL SW C
5 [COMB. SW]
BR BR
IE1
BR
IH
161
2003 TOYOTA TUNDRA (EWD491U)
CRUISE CONTROL (2UZ–FE)
SYSTEM OUTLINE
The cruise control system is a constant vehicle speed controller which controls the opening angle of the engine throttle valve
by the SW, and allows driving at a constant speed without depressing the accelerator pedal.
SET CONTROL
When the SET/COAST SW is operated while traveling with the main SW on, the speed when the SET/COAST SW is
operated to off is memorized, and the vehicle speed is controlled at that speed.
COAST CONTROL
When the SET/COAST SW is operated to on, the cruise control opening angle requirement is turned to 0 to decrease the
vehicle speed, and the speed when the SET/COAST SW is operated to off is memorized, and the vehicle speed is controlled
at that speed.
Furthermore, every time the SET/COAST SW is operated momentarily (Approx. 0.5 sec.) to on, the memorized vehicle
speed is decreased by approx. 1.6 km/h (1.0 mph).
ACCEL CONTROL
When the RES/ACC SW is operated to on, the throttle motor rotates the throttle valve to open direction to increase the
vehicle speed, and the speed when the RES/ACC SW is operated to off is memorized, and the vehicle speed is controlled at
that speed.
Furthermore, every time the RES/ACC SW is operated momentarily (Approx. 0.5 sec.) to on, the memorized vehicle speed is
increased by approx. 1.6 km/h (1.0 mph).
MANUAL CANCEL MECHANISM
If any of the following signals are input during cruise control traveling, the current to the motor flows in the direction to close
the throttle valve, and cancel the cruise control.
(1) Stop lamp SW is on (Brake pedal is depressed)
(2) The CANCEL SW of the control SW is on
(3) CRUISE SW is off
RESUME CONTROL
After canceling the cruise control (Except when the main SW is off) if the vehicle speed is above the minimum speed limit
(Approx. 40km/h, 25mph), operating the RES/ACC SW to on from off will cause the system to accelerate and resume to the
vehicle speed before manual cancellation.
OVERDRIVE FUNCTION
The overdrive may be cut on an uphill grade, while traveling with the cruise control.
After the overdrive is cut, if the vehicle speed reaches the overdrive resume speed (Set speed minus 2 km/h (1.2 mph) ), and
if the system determines that the uphill grade has finished, the overdrive will resume after the overdrive timer operation.
AUTO CANCEL OPERATION
If any of the following conditions are detected, the set speed is erased and the control is canceled.
(1) Disconnection and/or short in the stop light SW
(2) Malfunction in the vehicle speed signal
(3) Malfunction in the electronic throttle parts
(4) Malfunction in the stop light SW input circuit
(5) Malfunction in the cancel circuit
(6) The actual vehicle speed becomes slower than the minimum speed limit
(7) The actual vehicle speed becomes –16 km/h (10 mph) slower than the set speed
SERVICE HINTS
E3 (A), E4 (B), E6 (D), E7 (E) ENGINE CONTROL MODULE
IGSW–E1 : 9.0–14.0 volts with ignition SW at ON or ST position
BATT–E1 : Always 9.0–14.0 volts
STP–E1 : 7.5–14.0 volts with brake pedal depressed
: Below 1.5 volts with brake pedal released
C16 CRUISE CONTROL SW [COMB. SW]
5–3 : Approx. 1540Ω with CANCEL SW on
Approx. 240Ω with RES/ACC SW on
Approx. 630Ω with SET/COAST SW on
162
2003 TOYOTA TUNDRA (EWD491U)
: PARTS LOCATION
Code See Page Code See Page Code See Page
A20 34 E4 B 34 J9 35
C11 A 34 E5 C 34 J10 35
C12 B 34 E6 D 34 J18 31 (2UZ–FE)
C13 C 34 E7 E 34 P1 31 (2UZ–FE)
C16 34 J1 31 (2UZ–FE) S4 35
D8 34 J5 35 T2 31 (2UZ–FE)
E3 A 34 J8 35 V2 31 (2UZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1D
26 (*1)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1G
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I3 46 Engine Wire I5 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
163
2003 TOYOTA TUNDRA (EWD491U)
CRUISE CONTROL (5VZ–FE)
B–Y
B–Y
B–Y
ACC
B–R
B–Y
6 IA4 15 IA4
I23
IGNITION SW
B–R
B–R
B–R
B–Y
B–Y
B–Y
B–Y
B–Y
W
2 2 2 2 8 1F 5 1F 2 1I 9 1F
B–R
B–Y
2 2 2 3
15A EFI NO. 1
40A AM1
EFI
RELAY 10A
GAUGE
1 5
1 1
2 2
2
W–B
W–L
100A ALT
16 A 4 A
1 BATT MREL
CONNECTOR
CONNECTOR
A B
JUNCTION
JUNCTION
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
J18
J1
A B
2
+B ME01 E04 E1 E01 E02 E03
W–L
1 A 6 E 8 E 17 D 4 E 5 E 7 E
14 IA4
W–L
B
W–B
W–L
W–B
W–B
W–B
W–B
BR
BR
BATTERY
EA ED
164
2003 TOYOTA TUNDRA (EWD491U)
B–Y B–Y
B–Y B–Y
B–Y
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
15A 15A 5A
ACC STOP IGN
(A/T)
L–B
(A/T)
(A/T)
B–Y
B–Y
11 1G 2 1F 11 1F
L–B
4 IE1
B–O
G–W
GR
J5
PARK/NEUTRAL
JUNCTION
POSITION SW
CONNECTOR
E E 3 B CONNECTOR
JUNCTION
CONNECTOR
A B
JUNCTION
D
P1
J8
E 5 B
J9
A
B–O
(A/T)
B–Y
GR
(M/T)
W–R
2 3
(A/T)
(A/T)
B–Y
L–B
1 3
B–O
STOP LIGHT SW
DIODE(A/T)
CRUISE CONTROL
1 D8
15 IE2
CLUTCH SW
S4
2
J10 1 4
W–R
C G–W
(A/T)
JUNCTION
C18
2 CONNECTOR
C 4 1
(M/T)
C G–W
W–R
W–R C J12 1D 1D
G–W
JUNCTION
L–R
(A/T) CONNECTOR
25 B 20 A 9 B 15 A
D STP ST1– IGSW
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
BR
G–B
I3 I3
R–W
(SHIELDED)
B–W
G–B
G–B
G
R
3 4 1 3 2 4 1 2 3 4
VPA VPA2 VC VTA VTA2 VC M– M+ CL+ CL–
E2 E2
A8 2 1 T2 T1
ACCEL PEDAL THROTTLE POSITION THROTTLE CONTROL MOTOR
SENSOR SENSOR
B–W
B–W
I3
165
2003 TOYOTA TUNDRA (EWD491U)
CRUISE CONTROL (5VZ–FE)
B–Y
B–Y
15A
ETCS
G–O
W–G
B–Y
1 IA5
D
J9
JUNCTION
CONNECTOR 2 IE1
D
B–Y
W–G
G–O
G–O
B–Y
3 C 9 A
8 A 6 A
SPEEDOMETER
+BM SP1
COMBINATION METER
CRUISE
E3 A , E4 B , E5 C , E6 D , E7 E
C11 A , C13 C
ENGINE CONTROL MODULE
CCS PI
22 B 17 A
G
8 B 13 C 2 C 9 C
5
CRUISE CCS
G–B
P–L
RES/ACC
3 IE2 25 IE2 (A/T)
6 IE3 4 IE3 (M/T)
BR
SET/COAST
G–B
P–L
CANCEL 2 3
CONNECTOR
JUNCTION
ECC C
4 C16
J8
CRUISE CONTROL SW
BR
V2
17 IE1 VEHICLE SPEED SENSOR
(COMBINATION METER)
BR
BR
ED IH
166
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM OUTLINE
The cruise control system is a constant vehicle speed controller which controls the opening angle of the engine throttle valve
by the SW, and allows driving at a constant speed without depressing the accelerator pedal.
SET CONTROL
When the SET/COAST SW is operated while traveling with the main SW on, the speed when the SET/COAST SW is
operated to off is memorized, and the vehicle speed is controlled at that speed.
COAST CONTROL
When the SET/COAST SW is operated to on, the cruise control opening angle requirement is turned to 0 to decrease the
vehicle speed, and the speed when the SET/COAST SW is operated to off is memorized, and the vehicle speed is controlled
at that speed.
Furthermore, every time the SET/COAST SW is operated momentarily (Approx. 0.5 sec.) to on, the memorized vehicle
speed is decreased by approx. 1.6 km/h (1.0 mph).
ACCEL CONTROL
When the RES/ACC SW is operated to on, the throttle motor rotates the throttle valve to open direction to increase the
vehicle speed, and the speed when the RES/ACC SW is operated to off is memorized, and the vehicle speed is controlled at
that speed.
Furthermore, every time the RES/ACC SW is operated momentarily (Approx. 0.5 sec.) to on, the memorized vehicle speed is
increased by approx. 1.6 km/h (1.0 mph).
MANUAL CANCEL MECHANISM
If any of the following signals are input during cruise control traveling, the current to the motor flows in the direction to close
the throttle valve, and cancel the cruise control.
(1) Stop lamp SW is on (Brake pedal is depressed)
(2) The CANCEL SW of the control SW is on
(3) CRUISE SW is off
RESUME CONTROL
After canceling the cruise control (Except when the main SW is off) if the vehicle speed is above the minimum speed limit
(Approx. 40km/h, 25mph), operating the RES/ACC SW to on from off will cause the system to accelerate and resume to the
vehicle speed before manual cancellation.
OVERDRIVE FUNCTION
The overdrive may be cut on an uphill grade, while traveling with the cruise control.
After the overdrive is cut, if the vehicle speed reaches the overdrive resume speed (Set speed minus 2 km/h (1.2 mph) ), and
if the system determines that the uphill grade has finished, the overdrive will resume after the overdrive timer operation.
AUTO CANCEL OPERATION
If any of the following conditions are detected, the set speed is erased and the control is canceled.
(1) Disconnection and/or short in the stop light SW
(2) Malfunction in the vehicle speed signal
(3) Malfunction in the electronic throttle parts
(4) Malfunction in the stop light SW input circuit
(5) Malfunction in the cancel circuit
(6) The actual vehicle speed becomes slower than the minimum speed limit
(7) The actual vehicle speed becomes –16 km/h (10 mph) slower than the set speed
SERVICE HINTS
E3 (A), E4 (B), E6 (D), E7 (E) ENGINE CONTROL MODULE
IGSW–E1 : 9.0–14.0 volts with ignition SW at ON or ST position
BATT–E1 : Always 9.0–14.0 volts
STP–E1 : 7.5–14.0 volts with brake pedal depressed
: Below 1.5 volts with brake pedal released
C16 CRUISE CONTROL SW [COMB. SW]
5–3 : Approx. 1540Ω with CANCEL SW on
Approx. 240Ω with RES/ACC SW on
Approx. 630Ω with SET/COAST SW on
167
2003 TOYOTA TUNDRA (EWD491U)
CRUISE CONTROL (5VZ–FE)
: PARTS LOCATION
Code See Page Code See Page Code See Page
A8 32 (5VZ–FE) E5 C 34 J10 35
C11 A 34 E6 D 34 J12 35
C13 C 34 E7 E 34 J18 33 (5VZ–FE)
C16 34 I23 35 P1 33 (5VZ–FE)
C18 34 J1 33 (5VZ–FE) S4 35
D8 34 J5 35 T1 33 (5VZ–FE)
E3 A 34 J8 35 T2 33 (5VZ–FE)
E4 B 34 J9 35 V2 33 (5VZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1D
26 (*1)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1G
26 (*1)
22 (*2)
1I Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I3 46 Engine Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
168
2003 TOYOTA TUNDRA (EWD491U)
SRS
NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary
instructions and the procedure and precautions in the Repair Manual for the applicable model year.
Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information
when troubleshooting. When troubleshooting the SRS, always inspect the DTCs before disconnecting the battery.
Work must be started after 90 seconds from when the ignition switch is turned to the ”LOCK” position and the
negative (–) terminal cable is disconnected from the battery.
(The SRS is equipped with a back–up power source so that if work is started within 90 seconds from
disconnecting the negative (–) terminal cable of the battery, the SRS may be deployed.)
When the negative (–) terminal cable is disconnected from the battery, the memory of the clock and audio system will be
canceled. So before starting work, make a record of the contents memorized in the audio memory system. When work is
finished, reset the audio systems as they were before and adjust the clock. To avoid erasing the memory in each
memory system, never use a back–up power supply from outside the vehicle.
Before repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.
Do not expose the steering wheel pad, front passenger airbag assembly, seat belt pretensioner, center airbag sensor
assembly or front airbag sensor assembly directly to hot air or flames.
Even in cases of a minor collision where the SRS does not deploy, the steering wheel pad, front passenger airbag
assembly, seat belt pretensioner, center airbag sensor assembly and front airbag sensor assembly should be inspected.
Never use SRS parts from another vehicle. When replacing parts, replace them with new parts.
Never disassemble and repair the steering wheel pad, front passenger airbag assembly, seat belt pretensioner, center
airbag sensor assembly or front airbag sensor assembly in order to reuse it.
If the steering wheel pad, front passenger airbag assembly, seat belt pretensioner, center airbag sensor assembly or
front airbag sensor assembly has been dropped, or if there are cracks, dents or other defects in the case, bracket or
connector, replace them with new ones.
Use a volt/ohmmeter with high impedance (10 kΩ/V minimum) for troubleshooting the system’s electrical circuits.
Information labels are attached to the periphery of the SRS components. Follow the instructions on the notices.
After work on the SRS is completed, perform the SRS warning light check.
If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the Repair
Manual.
169
2003 TOYOTA TUNDRA (EWD491U)
SRS
A16
AIRBAG SQUIB A17
15A
ACC (FRONT PASSENGER AIRBAG SQUIB
AIRBAG ASSEMBLY) (STEERING WHEEL PAD)
10 1G 1 2
SPIRAL
CABLE
Y–G
Y–R
S5
SEAT BELT WARNING
P3 A , P4 B 1 2 OCCUPANT DETECTION SENSOR
PASSENGER AIRBAG
MANUAL ON–OFF SW 2 A 3 A
GR
SQB+ SQB–
Y–B
Y
3
E IND ECU– ECU+
1 B 2 B 4 A 1 A
B–L
W–B
Y–G
Y–R
R
11 B 10 B 14 B 13 B 8 C
13 B 1 A P– P+ D+ D– RBE+
ACC GND1
INTEGRATION CONTROL
C4 A , C5 B , C6 C
I24 A , I25 B
W–B
W–B
Y–B
Y–B
Y
1 2 1 2
W–B
P13 P14
PRETENSIONER LH PRETENSIONER RH
A
J13 W–B
JUNCTION
CONNECTOR
II IE IH
170
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM(SEE PAGE 56) * 1 : W/ POWER SEAT
* 2 : BENCH SEAT
* 3 : SEPARATE SEAT, CAPTAIN SEAT (W/O POWER SEAT)
1
5A 10A
IGN DOME
E3 A 2
ENGINE CONTROL L–Y
MODULE 3 1M 2
5 B
L–Y
C12 B , C13 C
F/PS
SRS WARNING LIGHT
14 A (2UZ–FE) [COMB. METER]
21 A (5VZ–FE) 6 1E
(2UZ–FE)
B–O
R–B
10 C
3 1F
B–Y
(5VZ–FE)
R–B
L–Y
1 II1 A
J5 A B–Y
JUNCTION
CONNECTOR
(2UZ–FE)
R–B
B–Y
23 B 5 B 3 B
GSW2 IG2 LA
C4 A , C5 B , C6 C
CENTER AIRBAG SENSOR ASSEMBLY
W–G
W–R
B
BR
J10
JUNCTION
CONNECTOR
B
CONNECTOR
CONNECTOR
(*1, * 2)
1 IA1 2 IA1 D D
JUNCTION
JUNCTION
B
BR–W
B–W
(* 3)
B
3 BI1
J5
J8
D D
W–R
BR
B
1 A (* 1)
BUCKLE SW LH
W–G
2 B (* 2)
B–Y
3 C
W
BUCKLE SW LH
B
B7 C
B7 A ,
2 A (* 1) 4 C 2 1 2 1 7 13 11
1 B (* 2) CONNECTION CONNECTION SIL TC A/B
DETECTION DETECTION
(*1, * 2)
PIN PIN
W–B
W–B
(*3)
A B A B
D6
DATA LINK CONNECTOR 3
4 BI1
171
2003 TOYOTA TUNDRA (EWD491U)
SRS
SYSTEM OUTLINE
The SRS is a driver protection device which has a supplemental role to the seat belts.
When the ignition SW on, the current from the IGN fuse flows to TERMINAL (B) 5 of the center airbag sensor assembly.
If an accident occurs while driving, deceleration caused by a frontal impact is detected (by sensor) and when the frontal
impact exceeds a set level, the current from the IGN fuse flows to TERMINAL (B) 5 of the center airbag sensor assembly.
This current flows to TERMINAL (B) 14, (A) 2, (C) 5 to TERMINAL 1 of the airbag squib (Steering wheel pad) and
Pretensioners to TERMINAL 2 to TERMINAL (B) 13, (A) 1, (C) 6 of the center airbag sensor assembly, and also flows to
TERMINAL (B) 11 of the center airbag sensor assembly to TERMINAL (A) 4 of the passenger airbag manual On–Off SW to
TERMINAL (A) 2 to TERMINAL 1 of the airbag squib (Front passenger airbag assembly) to TERMINAL 2 to TERMINAL (A)
3 of the passenger airbag manual On–Off SW to TERMINAL (A) 1 to TERMINAL (B) 10 of the center airbag sensor
assembly. Furthermore, the current flows to TERMINAL (B) 27 or (B) 28 to GROUND, causing the center airbag squibs to
expand.
When the safing sensor built into the center airbag sensor assembly is on, airbag sensor is off and the current from the IGN
fuse flows same as above–mentioned flowing, causing the airbag squibs to expand. When the safing sensor built into the
center airbag sensor assembly is on, the airbag sensor on one of the above-mentioned circuits is activated so that current
flows to the airbag squibs and causes them to operate.
The airbag stored inside the steering wheel pad is instantaneously expanded to soften the shock to the driver.
The airbag stored inside the passenger’s instrument panel is instantaneously expanded to soften the shock to the
passenger.
1. FRONT PASSENGER AIRBAG ON/OFF OPERATION
When the passenger airbag manual On–Off SW is on, the current flowing from the IGN fuse to the airbag squib (Front
passenger airbag assembly) is same as above, causing the airbag squib (Front passenger airbag assembly) to expand in an
accident.
If the passenger airbag manual On–Off SW is turned to off, the current flows from the ACC fuse to TERMINAL (B) 13 of the
passenger airbag OFF indicator (Integration control and panel) to TERMINAL (A) 3 to TERMINAL (B) 2 of the airbag manual
On–Off SW to TERMINAL (B) 1 to TERMINAL (A) 1 of the integration control and panel to TERMINAL (B) 1 to GROUND,
lighting the indicator up. Then the current between TERMINAL (B) 11 of the airbag sensor assembly and the airbag squib
(Front passenger airbag assembly) is cut off, so that it does not expand the airbag squib (Front passenger airbag assembly)
in an accident.
: PARTS LOCATION
Code See Page Code See Page Code See Page
30 (2UZ–FE) C4 A 34 J10 35
A11
32 (5VZ–FE) C5 B 34 J13 35
30 (2UZ–FE) C6 C 34 P3 A 35
A12
32 (5VZ–FE) C12 B 34 P4 B 35
A16 34 C13 C 34 36 (Access Cab)
P13
A17 34 D6 34 37 (Standard Cab)
A 38 (w/ Power Seat) E3 A 34 36 (Access Cab)
P14
36 (Access Cab *3) I24 A 35 37 (Standard Cab)
B
B7 37 (Standard Cab *3) I25 B 35 36 (Access Cab)
S5
36 (Access Cab *4) J5 35 37 (Standard Cab)
C
37 (Standard Cab *4) J8 35
: RELAY BLOCKS
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
172
2003 TOYOTA TUNDRA (EWD491U)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
22 (*2)
1G Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1M
26 (*1)
: GROUND POINTS
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
173
2003 TOYOTA TUNDRA (EWD491U)
4WD (2UZ–FE)
15A 10A
ACC GAUGE
11 1G 9 1F 8 1F 5 1F
B–Y
B–Y
B–Y
(*1)
GR
CONNECTOR
CONNECTOR
A E
JUNCTION
JUNCTION
(* 2)
GR
J9
J8
A E
(* 1)
GR
9 A COMBINATION METER
3 1
SPEEDOMETER
2 D8 4HI 4LO
DIODE
(A/T)
L–B
2 C 13 C 8 B 3 C 10 B 11 B 8 A 1 D
BR–Y
BR–Y
G–O
B–Y
Y–B
Y–B
26 IE1
R–L
P–L
BR
L–B
[PARK/NEUTRAL POSITION SW]
B–Y
R–L
P–L
5
CONNECTOR
CONNECTOR
3 2 C D
JUNCTION
JUNCTION
LG–B
P1
BR–Y
J8
J9
C D
Y–B
G–O
10 IE1
V2 Y–B
1
LG–B
VEHICLE
SPEED SENSOR
(COMBINATION
G–O
METER)
C
C LG–B LG–B
J11
JUNCTION
CONNECTOR
BR
IH
174
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56) * 1 : W/ DOOR LOCK CONTROL
* 2 : W/O DOOR LOCK CONTROL
20A
4WD
1 1J
B–Y
F7
12 4WD CONTROL ECU
IG
LG–B
W–B
G–O
G–R
G–Y
Y–B
L–R
P
J12
D JUNCTION CONNECTOR
D D D
L–R
L–R
L–R
3 IE2
BR–Y
24 IE2
G–Y
G–R
L–R
H–L 2–4
2 4 14 2
I24 A , I25 B
L4 EXI3
DETECTION SW
DETECTION SW
AND PANEL
D3
ENGINE ABS
CONTROL ACTUATOR
MODULE WITH ECU
BR–Y
W–B
Y–B
W–B
W–B
Y–B
G–O
LG–B
W–B
I4
W–B
2
W–B W–B W–B W–B
IE2 I3 I3
A
J13
JUNCTION
CONNECTOR
II
175
2003 TOYOTA TUNDRA (EWD491U)
4WD (2UZ–FE)
F7
4WD CONTROL ECU
ADD DL1 DL2 DM1 DM2 TM2 TM1 TL1 TL3 TL2
19 10 23 11 24 26 13 8 9 22
R–W
B–W
R–B
B–R
GR
LG
G
R
L
14 IE1 17 IE2 9 IE2 16 IE2 8 IE2 13 IE2 12 IE2 26 IE2 20 IE2 21 IE2
GR
R–W
R–B
LG
I3
GR
GR
B–W
B–R
W
G
Y
R–B
GR
LG
1 3 5 6
R–W
R–B
GR
LG
3 6 2 5 1 H2
DETECTION SW
M H4
M
4 A9 L4
ADD ACTUATOR
W–B
2 T3 4
TRANSFER SHIFT
ACTUATOR
6 ED1
W–B
W–B
6 EC1
W–B W–B
I3
W–B
176
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM OUTLINE
In the conventional system, the 2–4 select SW and the transfer shift lever was used to shift the mode between H–L. In this
system, the transfer shift lever is not used, and the H–L mode shift can be done by the transfer shift actuator.
The mode can be changed by the touch select 2–4 SW and touch select high–low in the integration control and panel.
The shift range is controlled according to the vehicle speed sensor and Park/Neutral position SW, and the indicator light is
turned ON to inform the driver if any of the following conditions are detected:
∗ The shift is not completed even though 3 seconds have elapsed after transfer operation.
∗ The vehicle speed is above approximately 100 km/h (63 mph) when shifting from H2 to H4.
∗ The vehicle speed is below approximately 5 km/h (3 mph) or the A/T shift lever is in a position other than N position, when
shifting from H4 to L4 or visa versa, and from L4 to H2.
TRANSFER OPERATION
H2 to H4
When the touch select 2–4 SW in the integration control and panel is turned ON, a signal is input into TERMINAL 4 of the
4WD control ECU.
The 4WD control ECU is activated by this, and the current flows from the 4WD control ECU TERMINAL 13 to transfer shift
actuator TERMINAL 1 to motor to TERMINAL 2 to 4WD control ECU TERMINAL 26 to GROUND, and the transfer shifts to
4WD (H4 position.)
When the system shifts to 4WD, the detection SW (Transfer 4WD position) is turned ON, and the current flows from 4WD
control ECU TERMINAL 11 to ADD actuator TERMINAL 5 to motor to TERMINAL 1 to 4WD control ECU TERMINAL 24 to
GROUND, and the ADD actuator is activated, and the ADD is connected. When the ADD is connected, the detection SW
(ADD position SW) is turned ON, and the 4HI Indicator light comes ON.
H4 to H2
When the touch select 2–4 SW in the integration control and panel is turned OFF, a signal is input into TERMINAL 4 of the
4WD control ECU.
The 4WD control ECU is activated by this, and the current flows from the 4WD control ECU TERMINAL 26 to transfer shift
actuator TERMINAL 2 to motor to TERMINAL 1 to 4WD control ECU TERMINAL 13 to GROUND, and the transfer shifts to
2WD (H2 position.)
When the system shifts to 2WD, the detection SW (Transfer 4WD position) is turned OFF, and the current flows from 4WD
control ECU TERMINAL 24 to ADD actuator TERMINAL 1 to motor to TERMINAL 5 to 4WD control ECU TERMINAL 11 to
GROUND, and the ADD actuator is activated, and the ADD is disconnected. When the ADD is disconnected, the detection
SW (ADD position SW) is turned OFF, and the 4HI indicator Light turns OFF.
H4 to L4
When the touch select high–low SW in the integration control and panel is turned ON, a signal is input into TERMINAL 7 of
the 4WD control ECU.
The 4WD control ECU is activated by this, and the current flows from the 4WD control ECU TERMINAL 13 to transfer shift
actuator TERMINAL 1 to motor to TERMINAL 2 to 4WD control ECU TERMINAL 26 to GROUND, and the transfer shifts to
4WD LO position (L4 position.)
The 4HI Indicator is turned OFF and the 4LO indicator is turned ON.
L4 to H4
When the touch select high–low SW in the integration control and panel is turned OFF, a signal is input into TERMINAL 7 of
the 4WD control ECU.
The 4WD control ECU is activated by this, and the current flows from the 4WD control ECU TERMINAL 26 to transfer shift
actuator TERMINAL 2 to motor to TERMINAL 1 to 4WD control ECU TERMINAL 13 to GROUND, and the transfer shifts to
4WD HI position (H4 Position.)
The 4HI indicator is turned ON and the 4LO indicator is turned OFF.
The shift is not completed even though 3 seconds have elapsed after transfer operation.
∗ The vehicle speed is above approximately 100 km/h (63 mph) when shifting from H2 to H4.
∗ The vehicle speed is below approximately 5 km/h (3 mph) or the A/T Shift Lever is in a position other than N position,
when shifting from H4 to L4 or visa versa, and from L4 to H2.
L4 to H2
When the touch select 2–4 SW in the integration control and panel is turned OFF, a signal is input into TERMINAL 4 of the
4WD control ECU.
The 4WD control ECU is activated by this, and the current flows from the 4WD control ECU TERMINAL 26 to transfer shift
actuator TERMINAL 2 to motor to TERMINAL 1 to 4WD control ECU TERMINAL 13 to GROUND, and the detection SW
(Transfer L4 position) is turned OFF.
Furthermore, the motor rotates to shift the transfer to 2WD (H2 position.)
When the system shifts to 2WD, the detection SW (Transfer 4WD position) is turned OFF, and the current flows from 4WD
control ECU TERMINAL 24 to ADD actuator TERMINAL 1 to motor to TERMINAL 5 to 4WD control ECU TERMINAL 11 to
GROUND, and the ADD actuator is activated, and the ADD is disconnected. When the ADD is disconnected, the detection
SW (ADD position SW) is turned OFF, and the 4LO indicator light turns OFF.
177
2003 TOYOTA TUNDRA (EWD491U)
4WD (2UZ–FE)
H2 to L4
When the touch select 2–4 SW in the integration control and panel is turned ON, and the touch select high–low SW is turned
ON, a signal is input into TERMINAL 4 of the 4WD control ECU.
The 4WD control ECU is activated by this, and the current flows from the 4WD control ECU TERMINAL 13 to transfer shift
actuator TERMINAL 1 to motor to TERMINAL 2 to 4WD control ECU TERMINAL 26 to GROUND, and the transfer shifts to
4WD (H4 position.)
When the system shifts to 4WD, the detection SW (Transfer 4WD position) is turned ON, and the current flows from 4WD
control ECU TERMINAL 11 to ADD actuator TERMINAL 5 to motor to TERMINAL 1 to 4WD control ECU TERMINAL 24 to
GROUND, and the ADD actuator is activated, and the ADD is connected. Then a signal is input into TERMINAL 7 of the
4WD control ECU and the 4WD control ECU is activated by this, so the current flows from the 4WD control ECU TERMINAL
13 to transfer shift actuator TERMINAL 1 to motor to TERMINAL 2 to 4WD control ECU TERMINAL 26 to GROUND. The
transfer shifts to 4WD LO position (L4 position), and the 4LO indicator light comes ON.
SERVICE HINTS
F7 4WD CONTROL ECU
12–GROUND : Approx. 12 volts with ignition SW at ON or ST position
25–GROUND : Always continuity
3–GROUND : 4 pulses with 1 rotation
4–GROUND : 2 volts or less with touch select 2–4 SW on
18–GROUND : 2 volts or less with detection SW (Transfer L4 position) on and transfer shift lever at L4 position
I24 (A), I25 (B) INTEGRATION CONTROL AND PANEL
(A) 5–(B) 1 : Closed with touch select 2–4 SW on
P1 NEUTRAL POSITION SW [PARK/NEUTRAL POSITION SW]
3–5 : Closed with A/T shift lever at N position
: PARTS LOCATION
Code See Page Code See Page Code See Page
A5 30 (2UZ–FE) D4 30 (2UZ–FE) J9 35
A9 30 (2UZ–FE) D8 34 J11 35
C11 A 34 E4 34 J12 35
C12 B 34 F7 35 J13 35
C13 C 34 I24 A 35 P1 31 (2UZ–FE)
C14 D 34 I25 B 35 T3 31 (2UZ–FE)
D3 30 (2UZ–FE) J8 35 V2 31 (2UZ–FE)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1F
26 (*1)
22 (*2)
1G Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
178
2003 TOYOTA TUNDRA (EWD491U)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I3 46 Engine Wire I4 46 Cowl Wire
179
2003 TOYOTA TUNDRA (EWD491U)
4WD (5VZ–FE)
W
POSITION)
20A
4WD
6 IE1
D3
W
B–R
1 1J
C
J11 C W
1 IE2 (A/T) JUNCTION
5 IE3 (M/T) CONNECTOR
C C
B–R
R–Y
T4
W
W
TRANSMISSION (A/T)
7 CONTROL RELAY 9 3
E4
ENGINE CONTROL
MODULE 11
TFN
4WD L4
13 2
(A/T)
L–R
GR
CONNECTOR
(M/T)
D
(A/T)
GR
GR
JUNCTION
D L–R
2 4 10 1 5
(A/T)
(M/T)
J12
R–W
W–B
R–B
GR
LG
D
R
17 IE2 10 IE3
(A/T)
L–R
8 IE2 20 IE2 9 IE2 18 IE1 (A/T)
(M/T)
(A/T)
GR
R–W
R–B
LG
R
13 IE2
D D
JUNCTION
R–W
R–B
GR
LG
R
J10
(A/T)
L–R
D
1 2 5 6 3
L–R
GR
(M/T)
1
M D4
DETECTION SW
(TRANSFER L4
POSITION)
2
A9 4
W–B
W–B
ADD ACTUATOR
W–B
GR
7
W–B W–B 6 EG1
I4 IE1
W–B W–B
W–B
W–B W–B
A I3
J13
JUNCTION
CONNECTOR
II
180
2003 TOYOTA TUNDRA (EWD491U)
* 1 : W/ DOOR LOCK CONTROL FROM POWER SOURCE SYSTEM (SEE PAGE 56)
* 2 : W/O DOOR LOCK CONTROL
15A 10A
ACC GAUGE
11 1G 9 1F 5 1F
B–Y
B–Y
(* 1)
GR
R–Y A E
J9 J8
(* 2)
GR
(A/T) JUNCTION JUNCTION
CONNECTOR CONNECTOR
A5 A E
B–Y
(* 1)
GR
ABS ACTUATOR WITH
ECU
3 1
EXI D8
DIODE
14 (A/T)
L–B
(M/T)
L–R
4 IE1
L–B
NEUTRAL POSITION SW
(A/T)
R–Y
7 IE3
[PARK/NEUTRAL
POSITION SW]
3
CONNECTOR
(M/T)
L–R
L–R
JUNCTION
(A/T) B
P1
J9
B B 1
L–Y
(A/T)
(A/T)
R–Y
R–Y
21 IE2
24 IE2
B–Y
L–Y
(A/T)
R–Y
(TRANSFER NEUTRAL
4 D 9 A
L–R 1
DETECTION SW
4WD
POSITION)
COMBINATION
METER
2
D5
2 D 10 B
(A/T)
W–B
R–Y
(A/T)
GR GR
W–B
I3
W–B
181
2003 TOYOTA TUNDRA (EWD491U)
4WD (5VZ–FE)
SERVICE HINTS
P1 NEUTRAL POSITION SW [PARK/NEUTRAL POSITION SW]
3–1 : Closed with A/T shift lever at P position
D5 DETECTION SW (TRANSFER NEUTRAL POSITION)
1–2 : Closed with transfer position at N position
: PARTS LOCATION
Code See Page Code See Page Code See Page
A5 32 (5VZ–FE) D4 32 (5VZ–FE) J10 35
A9 32 (5VZ–FE) D5 32 (5VZ–FE) J11 35
C11 A 34 D8 34 J12 35
C12 B 34 E4 34 J13 35
C14 D 34 J8 35 P1 33 (5VZ–FE)
D3 32 (5VZ–FE) J9 35 T4 35
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1F
26 (*1)
22 (*2)
1G Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I3 46 Engine Wire I4 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
182
2003 TOYOTA TUNDRA (EWD491U)
MEMO
183
2003 TOYOTA TUNDRA (EWD491U)
184
W–B W–B W–B
A A
A B
7 A
IE
METER
A B
Y–B
2 B
COMBINATION
J23 A , J24 B
W–B
JUNCTION
CONNECTOR
13 B
10A
U1 J7
GAUGE
E
E
1
2
P–B P–B B–Y
9 A
1 C
5 1F
E
10A
J8
DOME
JUNCTION
CONNECTOR
2
1
C
C
BR BR L–Y L–Y
2
8 B
5 B
3 1F
6 1E
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
P–B
6 1N
D22 J7
DOOR KEY LOCK AND JUNCTION
6
UNLOCK SW LH CONNECTOR
B
B
1
LOCK W–G W–G W–G
IB4
J7
2
W–B
B
JUNCTION
7
CONNECTOR
3
C
C
IB4
UNLOCK
INTEGRATION RELAY
P10 J4
DOOR LOCK CONTROL SW LH JUNCTION
DOOR LOCK CONTROL (w/ DAYTIME RUNNING LIGHT)
2
D
D
9 IB3
1
W–B
B3
8
5
C
C
IB3
UNLOCK
D
C
L
G–B
R–Y
W–B
W–B
W–G
L
D23
G–B
R–Y
W–B
W–B
W–G
DOOR KEY LOCK AND
6
UNLOCK SW RH
J13
1
JUNCTION LOCK W–G
IF4
CONNECTOR
A
2
W–B W–B W–B
II
IF3
B7
7
3
R–Y R–W
A
22 1N
IF4
UNLOCK (2UZ–FE)
R–Y
D24 (5VZ–FE)
W–B
DOOR LOCK CONTROL
9
SW RH
6
LOCK G–B
IF3
INTEGRATION RELAY
3
W–B
B7
8
5
R–Y
IF3
UNLOCK
A
A
R–L
D25
DOOR LOCK MOTOR
AND DOOR UNLOCK
DETECTION SW LH
D
D
L–Y
1
3
W–B
9 1N 10 1N
1
4
W–B W–B R–L R–L
IB3
B3
IB3
J7
4
5
JUNCTION
CONNECTOR
3
2
B–Y L–W L–W
W–B
M
IB3
IB3
D26
L–Y
DOOR LOCK MOTOR J21 A , J22 B
L–W
3
CONNECTOR
2
1
4
W–B L–Y L–Y E A
IF3
T13
4
5
ACT+
13
3
2
B–Y L–W L–W L–W
E B
E A
M
8 1H
IF3
IF3
TVIP ECU
ACT–
B–Y
JUNCTION CONNECTOR
4
12
B–Y
D B
F A
9 1H
J3
B–Y
F A
JUNCTION
A
8
CONNECTOR A
W–B W–B
IF
8 1J
J8
JUNCTION
CONNECTOR
D
D
BR BR BR
IH
24 1N
L
L
185
186
L
E
E
L
(*2)
1
14
L L L L
E
E
7 1H
5 BE2
4 BG2
(* 1) (*1) (*1)
D16
J4
DOOR COURTESY
SW FRONT LH
JUNCTION
CONNECTOR
2
1
W–B B–W B–W B–W
BJ
B8
4 BE2
5 BG2
(* 1) (* 1) (* 1) (* 1)
D19
DOOR COURTESY
SW REAR LH UPPER
INTEGRATION RELAY
(* 1)
B–W
2
1
W–B B–W
(* 1) (* 1)
C
D18
C
DOOR COURTESY B–W
SW REAR LH LOWER
(*2)
1
15
C
C
B–W B–W B–W B–W B–W
6 1H
B9
5 BF2
4 BH1
(* 1) (* 1) (*1) (*1)
D17
J5
DOOR COURTESY
SW FRONT RH
(* 1)
B–W
JUNCTION
2
1
W–B B–W
CONNECTOR
BK
(* 1) (* 1)
D21
DOOR COURTESY
SW REAR RH UPPER
2
1
W–B B–W
(* 1) (* 1)
D20
30A
DOOR COURTESY
DOOR LOCK CONTROL (w/ DAYTIME RUNNING LIGHT)
SW REAR RH LOWER
* 1 : ACCESS CAB
POWER
* 2 : STANDARD CAB
2
1
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
SYSTEM OUTLINE
Current always flows to TERMINAL 3 of the integration relay through the POWER fuse.
1. MANUAL LOCK OPERATION
To push the door lock control SW or door key lock and unlock SW to LOCK position, a lock signal is input to the integration
relay and causes the relay to function. Current flows from TERMINAL 3 of the relay to TERMINAL 13 to TERMINAL 2 of the
door lock motors to TERMINAL 3 to TERMINAL 12 of the relay to TERMINAL 8 to GROUND and the door lock motor causes
the door to lock.
2. MANUAL UNLOCK OPERATION
To push the door lock control SW or door key lock and unlock SW to UNLOCK position, an unlock signal is input to the
integration relay and causes the relay to function. Current flows from TERMINAL 3 of the relay to TERMINAL 12 to
TERMINAL 3 of the door lock motors to TERMINAL 2 to TERMINAL 13 of the relay to TERMINAL 8 to GROUND and the
door lock motor causes the door to unlock.
3. DOUBLE OPERATION UNLOCK OPERATION
When the door key lock and unlock SW LH is turned to unlock position, only the front LH door is mechanically unlocked.
Turning the door key lock and unlock SW LH to the unlock side causes a signal to be input to the relay, and if the signal is
input again within 3 seconds by turning the door key lock and unlock SW LH to the unlock side again, current flows from
TERMINAL 12 of the integration relay to TERMINAL 3 of the door lock motors, TERMINAL 2 to TERMINAL 13 of the
integration relay to TERMINAL 8 to GROUND, causing the door lock motors to operate and unlock the doors.
4. KEY CONFINE PREVENTION FUNCTION
∗ Operating door lock knob (In door lock motor operation)
With ignition key in cylinder (Unlock warning SW on), when any door is opened and locked using door lock knob (Door
lock motor), the door is locked once but each door is unlocked soon by the function of the integration relay. As a result,
current flows from TERMINAL 3 of the relay to TERMINAL 12 to TERMINAL 3 of the door lock motors to TERMINAL 2 to
TERMINAL 13 of the relay to TERMINAL 8 to GROUND and causes all the doors to unlock.
∗ Operating door lock control SW or door key lock and unlock SW
With ignition key in cylinder (Unlock warning SW on), when any door is opened and locked using the door lock control
SW or door key lock and unlock SW, all doors are locked once but each door is unlocked by the function of the SW
contained in motor, which inputs the signal to the integration relay. According to this input signal, current flows from
TERMINAL 3 of the relay to TERMINAL 12 to TERMINAL 3 of the door lock motors to TERMINAL 2 to TERMINAL 13 of
the relay to TERMINAL 8 to GROUND and causes all the doors to unlock.
SERVICE HINTS
INTEGRATION RELAY
8–GROUND : Always continuity
3–GROUND : Always approx. 12 volts
12–GROUND : Approx. 12 volts for 0.2 seconds with following operations
∗ Door lock control SW unlocked
∗ Door lock control SW locked with ignition key in cylinder and LH or RH door open
(Ignition key reminder function)
∗ Door lock knob locked with ignition key in cylinder and LH or RH door open. (Ignition key reminder function)
∗ Unlocking the LH, RH door cylinder with key
13–GROUND : Approx. 12 volts for 0.2 seconds with following operations
∗ Door lock control SW locked
∗ Locking the LH, RH door cylinder with key
14–GROUND : Continuity with front LH door open
15–GROUND : Continuity with front RH door open (Standard cab)
15–GROUND : Continuity with front RH, rear LH, RH door open (Access cab)
D16, D17 DOOR COURTESY SW FRONT LH, RH
1–GROUND : Closed with door open
D22, D23 DOOR KEY LOCK AND UNLOCK SW LH, RH
1–2 : Closed with door lock cylinder locked with key
3–2 : Closed with door lock cylinder unlocked with key
D25, D26 DOOR LOCK MOTOR AND DOOR UNLOCK DETECTION SW LH, RH
4–1 : Closed with door lock knob UNLOCK position
U1 UNLOCK WARNING SW
1–2 : Closed with key in cylinder
187
2003 TOYOTA TUNDRA (EWD491U)
DOOR LOCK CONTROL (w/ DAYTIME RUNNING LIGHT)
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 A 34 D22 37 (Standard Cab) J7 35
C12 B 34 36 (Access Cab) J8 35
D23
C13 C 34 37 (Standard Cab) J13 35
36 (Access Cab) 36 (Access Cab) J21 A 35
D16 D24
37 (Standard Cab) 37 (Standard Cab) J22 B 35
36 (Access Cab) 36 (Access Cab) J23 A 35
D17 D25
37 (Standard Cab) 37 (Standard Cab) J24 B 35
D18 36 (Access Cab) 36 (Access Cab) 36 (Access Cab)
D26 P10
D19 36 (Access Cab) 37 (Standard Cab) 37 (Standard Cab)
D20 36 (Access Cab) J3 35 T13 35
D21 36 (Access Cab) J4 35 U1 35
D22 36 (Access Cab) J5 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
1E 26 (*1) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1F
1H 26 (*1)
( )
Cowl Wire and Driver Side J/B (Lower Finish Panel)
1J
1N 27 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
48 (Access Cab) B7 50 (Standard Cab) Front Door RH Wire
B3 Front Door LH Wire
50 (Standard Cab) B8 48 (Access Cab) Rear Door No.1 Wire LH
B7 48 (Access Cab) Front Door RH Wire B9 48 (Access Cab) Rear Door No.1 Wire RH
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
188
2003 TOYOTA TUNDRA (EWD491U)
MEMO
189
2003 TOYOTA TUNDRA (EWD491U)
DOOR LOCK CONTROL (w/o DAYTIME RUNNING LIGHT)
10A 10A
GAUGE DOME
INTEGRATION RELAY
5 1F 2
L–Y
6 1E
B–Y
3 1F
L–Y
C11 A , C12 B , C13 C
COMBINATION
METER 9 A 5 B
4 1L 3 1L 1 1L 2 1L
G–B
R–Y
L–R
CONNECTOR
JUNCTION
C D C
P–B
C R–Y
J4
J7
D28 JUNCTION
DIODE CONNECTOR D G–B
C
7 A 2 B 13 B 1 C 8 B (LOCK)
2 1 G–B D C R–Y
W–B
Y–B
P–B
J7
BR
D C
L
W–G
JUNCTION
CONNECTOR
CONNECTOR
B B W–G W–G
JUNCTION
E
E P–B
B
J7
W–G
G–B
R–Y
L–R
E
P–B
G–B
R–Y
L–R
2
DOOR KEY LOCK AND
1 3 2 5
UNLOCK
UNLOCK
CONNECTOR
UNLOCK SW LH
JUNCTION
LOCK
LOCK
SW
C
U1
1
J8
2 1
D22
C
W–B
P10
W–B
W–B
BR
B3
W–B
W–B
J23 A , J24 B
A B A B
CONNECTOR
JUNCTION
W–B
A A
L
W–B
IE
190
2003 TOYOTA TUNDRA (EWD491U)
L
R–Y
G–B
R–Y
W–B
W–B
W–G
D23
DOOR KEY LOCK AND
6
UNLOCK SW RH
D30
1
LOCK W–G
DIODE
IF4
1
(UNLOCK)
A
2
W–B W–B W–B
II
IF3
B7
7
2
A
A
3
R–Y R–W R–W
A
IF4
UNLOCK
J13
J4
D24 JUNCTION
JUNCTION
CONNECTOR
W–B
DOOR LOCK CONTROL
CONNECTOR
9
SW RH
INTEGRATION RELAY
6
LOCK G–B
IF3
3
W–B
B7
8
5
R–Y
IF3
UNLOCK
A
A
R–L
D25
9 1L
DOOR LOCK MOTOR
AND DOOR UNLOCK
DETECTION SW LH
D
D
L–Y
1
3
W–B
8 1L
1
4
W–B W–B R–L R–L
IB3
B3
IB3
J7
4
5
JUNCTION
CONNECTOR
3
2
L–Y B–Y L–W L–W
W–B
M
IB3
IB3
2
D26
DOOR LOCK MOTOR
AND DOOR UNLOCK
T13
ACT+
DETECTION SW RH
1
4
W–B L–Y L–Y
TVIP ECU
E A
IF3
ACF
4
5
13
4
E B
E A
M
8 1H
IF3
IF3
J21 A , J22 B
JUNCTION
B–Y
B–Y
J21 A , J22 B CONNECTOR
JUNCTION CONNECTOR
12
B–Y
D B
F A
9 1H
F A
B–Y
A
8
A
W–B
IF
8 1J
J3
L
L
JUNCTION
CONNECTOR
191
192
L
E
E
L
(*2)
E
E
1
14
L L L L
7 1H
5 BE2
4 BG2
(*1) (*1) (*1)
D16
J4
DOOR COURTESY
SW FRONT LH
JUNCTION
CONNECTOR
D
D
BR BR
IH
16 1L
J8
JUNCTION
CONNECTOR
2
1
W–B B–W B–W B–W
BJ
B8
4 BE2
5 BG2
(* 1) (* 1) (* 1) (*1)
D19
DOOR COURTESY
SW REAR LH UPPER
(* 1)
2
1
W–B B–W
B–W
(* 1) (* 1)
INTEGRATION RELAY
D18
DOOR COURTESY
SW REAR LH LOWER
C
B–W
(*2)
1
15
C
C
B–W B–W B–W B–W B–W
6 1H
B9
5 BF2
4 BH1
(* 1) (* 1) (*1) (*1)
D17
J5
DOOR COURTESY
(* 1)
B–W
JUNCTION
2
1
W–B B–W
CONNECTOR
BK
B9
3
(* 1) (* 1)
D21
DOOR COURTESY
SW REAR RH UPPER
30A
2
1
W–B B–W
POWER
(* 1) (* 1)
DOOR LOCK CONTROL (w/o DAYTIME RUNNING LIGHT)
D20
2
1
DOOR COURTESY
SW REAR RH LOWER
* 1 : ACCESS CAB
* 2 : STANDARD CAB
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
SYSTEM OUTLINE
Current always flows to TERMINAL 3 of the integration relay through the POWER fuse.
1. MANUAL LOCK OPERATION
To push the door lock control SW or door key lock and unlock SW to LOCK position, a lock signal is input to the integration
relay and causes the relay to function. Current flows from TERMINAL 3 of the relay to TERMINAL 13 to TERMINAL 2 of the
door lock motors to TERMINAL 3 to TERMINAL 12 of the relay to TERMINAL 8 to GROUND and the door lock motor causes
the door to lock.
2. MANUAL UNLOCK OPERATION
To push the door lock control SW or door key lock and unlock SW to UNLOCK position, an unlock signal is input to the
integration relay and causes the relay to function. Current flows from TERMINAL 3 of the relay to TERMINAL 12 to
TERMINAL 3 of the door lock motors to TERMINAL 2 to TERMINAL 13 of the relay to TERMINAL 8 to GROUND and the
door lock motor causes the door to unlock.
3. DOUBLE OPERATION UNLOCK OPERATION
When the door key lock and unlock SW LH is turned to unlock position, only the front LH door is mechanically unlocked.
Turning the door key lock and unlock SW LH to the unlock side causes a signal to be input to the relay, and if the signal is
input again within 3 seconds by turning the door key lock and unlock SW LH to the unlock side again, current flows from
TERMINAL 12 of the integration relay to TERMINAL 3 of the door lock motors, TERMINAL 2 to TERMINAL 13 of the
integration relay to TERMINAL 8 to GROUND, causing the door lock motors to operate and unlock the doors.
4. KEY CONFINE PREVENTION FUNCTION
∗ Operating door lock knob (In door lock motor operation)
With ignition key in cylinder (Unlock warning SW on), when any door is opened and locked using door lock knob (Door
lock motor), the door is locked once but each door is unlocked soon by the function of the integration relay. As a result,
current flows from TERMINAL 3 of the relay to TERMINAL 12 to TERMINAL 3 of the door lock motors to TERMINAL 2 to
TERMINAL 13 of the relay to TERMINAL 8 to GROUND and causes all the doors to unlock.
∗ Operating door lock control SW or door key lock and unlock SW
With ignition key in cylinder (Unlock warning SW on), when any door is opened and locked using the door lock control
SW or door key lock and unlock SW, all doors are locked once but each door is unlocked by the function of the SW
contained in motor, which inputs the signal to the integration relay. According to this input signal, current flows from
TERMINAL 3 of the relay to TERMINAL 12 to TERMINAL 3 of the door lock motors to TERMINAL 2 to TERMINAL 13 of
the relay to TERMINAL 8 to GROUND and causes all the doors to unlock.
SERVICE HINTS
INTEGRATION RELAY
8–GROUND : Always continuity
3–GROUND : Always approx. 12 volts
12–GROUND : Approx. 12 volts for 0.2 seconds with following operations
∗ Door lock control SW unlocked
∗ Door lock control SW locked with ignition key in cylinder and LH or RH door open
(Ignition key reminder function)
∗ Door lock knob locked with ignition key in cylinder and LH or RH door open. (Ignition key reminder function)
∗ Unlocking the LH, RH door cylinder with key
13–GROUND : Approx. 12 volts for 0.2 seconds with following operations
∗ Door lock control SW locked
∗ Locking the LH, RH door cylinder with key
14–GROUND : Continuity with front LH door open
15–GROUND : Continuity with front RH door open (Standard cab)
15–GROUND : Continuity with front RH, rear LH, RH door open (Access cab)
D16, D17 DOOR COURTESY SW FRONT LH, RH
1–GROUND : Closed with door open
D22, D23 DOOR KEY LOCK AND UNLOCK SW LH, RH
1–2 : Closed with door lock cylinder locked with key
3–2 : Closed with door lock cylinder unlocked with key
D25, D26 DOOR LOCK MOTOR AND DOOR UNLOCK DETECTION SW LH, RH
4–1 : Closed with door lock knob UNLOCK position
U1 UNLOCK WARNING SW
1–2 : Closed with key in cylinder
193
2003 TOYOTA TUNDRA (EWD491U)
DOOR LOCK CONTROL (w/o DAYTIME RUNNING LIGHT)
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 A 34 36 (Access Cab) J7 35
D23
C12 B 34 37 (Standard Cab) J8 35
C13 C 34 36 (Access Cab) J13 35
D24
36 (Access Cab) 37 (Standard Cab) J21 A 35
D16
37 (Standard Cab) 36 (Access Cab) J22 B 35
D25
36 (Access Cab) 37 (Standard Cab) J23 A 35
D17
37 (Standard Cab) 36 (Access Cab) J24 B 35
D26
D18 36 (Access Cab) 37 (Standard Cab) 36 (Access Cab)
P10
D19 36 (Access Cab) D28 34 37 (Standard Cab)
D20 36 (Access Cab) D30 34 T13 35
D21 36 (Access Cab) J3 35 U1 35
36 (Access Cab) J4 35
D22
37 (Standard Cab) J5 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
1E 22 (*2) Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
1F
1H 22 (*2)
( )
Cowl Wire and Driver Side J/B (Lower Finish Panel)
1J
1L 23 (*2)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
48 (Access Cab) B7 50 (Standard Cab) Front Door RH Wire
B3 Front Door LH Wire
50 (Standard Cab) B8 48 (Access Cab) Rear Door No.1 Wire LH
B7 48 (Access Cab) Front Door RH Wire B9 48 (Access Cab) Rear Door No.1 Wire RH
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
194
2003 TOYOTA TUNDRA (EWD491U)
MEMO
195
2003 TOYOTA TUNDRA (EWD491U)
TVIP AND WIRELESS DOOR LOCK CONTROL
1 5 15A 10A
TAIL HORN
H–LP
RELAY
2 3
2 2 2
R–B
B–L
(* 1)
(* 2)
R
B
INTEGRATION
RELAY 6 7
5 1K
6 1C
4 1O (* 3) 3 1N (* 3) 4 1N (* 3) 12 1N (* 3)
6 1L (* 4) 5 1L (* 4) 13 1L (* 4) 12 1L (* 4)
G–R
G–Y
R–B
R
F A
J7 J10
JUNCTION C A JUNCTION
J21 A , J22 B
CONNECTOR CONNECTOR
JUNCTION
F CONNECTOR A
A B
G–R
R–B
G–Y
B–L
(*1)
(*2)
B
* 1: TOWING PACKAGE
* 2: EXCEPT TOWING PACKAGE
* 3: W/ DAYTIME RUNNING LIGHT
* 4: W/O DAYTIME RUNNING LIGHT
* 5: 2UZ–FE
* 6: 5VZ–FE
BATTERY
196
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
5A 30A 5A
ECU–B POWER ECU IG
2 4 1C 13 1G
W–G
W–R
(* 5)
W–G
(*6)
T11 A , T12 B , T13 C
TVIP ECU
J23 A , J24 B
17 IA5 C A
CONNECTOR
JUNCTION
W–R
(*5)
(*6)
(*5)
W–G(*6)
W–G(*5)
W–R(* 6)
CONNECTOR
W–R
G–R
R–B
G–Y
D A
(* 5)
JUNCTION
B–R
J21 A
D A
G–R
R–B
G–Y
197
2003 TOYOTA TUNDRA (EWD491U)
TVIP AND WIRELESS DOOR LOCK CONTROL
R–W
W–G
W–B
P–B
L–R
L–R
(* 4)
V
R–Y
(* 3)
CONNECTOR
E B C C
JUNCTION
C C R–Y
(W/O TVIP)
(SHILEDED)
7 IA4 (* 3)
LG–B
L–W
J4
E B B C J7 C
L
JUNCTION R–Y
CONNECTOR
W–G
L–R
(* 4)
W–G
V
SHORT CONNECTOR
W–G
R–Y
1 1 3 4 2
P–B
TVIP BUZZER
(TVIP)
3 2
S10 [POWER WINDOW MASTER SW]
1
DOOR LOCK CONTROL SW LH
W–G
W–G
W–B
W–B
R–Y
L–R
SECURITY INDICATOR
AND GLASS
BREAKAGE SENSOR
MICROPHONE
DOOR KEY LOCK AND
UNLOCK WARNING
2 1 3 2 5
UNLOCK SW LH
UNLOCK
UNLOCK
(W/O TVIP)
3 IA4
LOCK
LOCK
W–B
SW
U1
D22
P10
1 2 1
W–B
W–B
W–B
W–B
Y–B
W–B
J23 A , J24 B
B3
A A A A A A A A
CONNECTOR
2 B
JUNCTION
C11 A , C12 B
COMBINATION
METER
A B A B A B 7 A
W–B
W–B
W–B
W–B
W–B
W–B
IE
198
2003 TOYOTA TUNDRA (EWD491U)
* 3 : W/ DAYTIME RUNNING LIGHT
* 4 : W/O DAYTIME RUNNING LIGHT
R–W
(* 4)
R–L
L–Y
B–Y
B–Y
E A
R–Y
J21 A , J22 B
(* 3)
A A D JUNCTION
J4 CONNECTOR
R–Y 1 2 R–W A D E B
JUNCTION
(* 4) (* 4) CONNECTOR
L–W
L–Y
D30 A
DIODE (UNLOCK)
W–G J7 A
R–W
L–W
JUNCTION
CONNECTOR
R–L
L–W
R–L
L–Y
W–G
W–G
R–Y
R–Y
DOOR LOCK CONTROL
DOOR KEY LOCK AND
J21 A , J22 B
DOOR LOCK MOTOR
1 3 6 5 4 2 4 2
AND DOOR UNLOCK
F A
DETECTION SW RH
DETECTION SW LH
UNLOCK SW RH
CONNECTOR
JUNCTION
UNLOCK
UNLOCK
LOCK
LOCK
M M
SW RH
D B
D23
D24
2 3 1 3 1 3
D25
D26
W–B
W–B
B–Y
B–Y
B–Y
W–B
W–B
W–B
B7 B7
W–B
W–B
B–Y
1 IF3 1 IB3
W–B
W–B
A
J13
JUNCTION
CONNECTOR
II
199
2003 TOYOTA TUNDRA (EWD491U)
TVIP AND WIRELESS DOOR LOCK CONTROL
FROM ST RELAY
CUT OFF
G–R
GR
P
T11 A , T12 B , T13 C
TVIP ECU 8 C 3 C 12 B
SRLY ST A
B–W
B–W
B
B
L
B–W
E C 2
J4 B–W C J5 D11
JUNCTION JUNCTION DIODE
CONNECTOR (*8) CONNECTOR (POWER WINDOW
SYSTEM)
E E C C
B–W
1
(*8)
(*8)
L
B–L
5 BE2 5 BE2 5 BF2
B–W
B–W
B–W
(*7)
(*8)
(*8)
(*7)
(*8)
L
B–W
(* 8)
(* 8)
(* 8)
L
B–W
B8 B9 B9
(* 8)
B–L
B–W
B–W
B–W
B–W
B–W
(* 8)
(* 8)
(* 8)
(* 8)
(* 8)
SW REAR RH LOWER
SW REAR LH LOWER
SW REAR RH UPPER
SW REAR LH UPPER
DOOR COURTESY
DOOR COURTESY
DOOR COURTESY
DOOR COURTESY
DOOR COURTESY
DOOR COURTESY
1 1 1 1 1 1
SW FRONT RH
SW FRONT LH
D16
D19
D18
D17
D21
D20
2 2 2 2
W–B
W–B
W–B
W–B
(* 8)
(* 8)
(* 8)
(* 8)
BJ BK
200
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
* 7 : STANDARD CAB
* 8 : ACCESS CAB
1
10A
DOME
L–Y L–Y
B4
L–Y
L–Y
L–Y
2 3
6 1E
INTERIOR LIGHT
DOOR
OFF
ON
I26
3 1A
PERSONAL LIGHT
B–W
1
L–Y
B
P8
B–W
2 1
J21 A , J22 B
JUNCTION
CONNECTOR
B B
B–W
B4
W–B
B–W
B A B A
B
2 IC1
B
1 1H 2 1A
B–W
B–W
2
B
D29 B J4
DIODE JUNCTION
9 1B (TVIP) CONNECTOR 8 1J
1 B
B–L B–W
W–B
A
J3
JUNCTION
CONNECTOR
IF
201
2003 TOYOTA TUNDRA (EWD491U)
TVIP AND WIRELESS DOOR LOCK CONTROL
SERVICE HINTS
T11 (A), T12 (B), T13 (C) TVIP ECU
(B) 3–GROUND : Approx. 12 volts with the ignition SW at ON position
(A) 1, (B) 11–GROUND : Always approx. 12 volts
(A) 7–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 A 34 D24 37 (Standard Cab) J22 B 35
C12 B 34 36 (Access Cab) J23 A 35
D25
D11 34 37 (Standard Cab) J24 B 35
36 (Access Cab) 36 (Access Cab) 36 (Access Cab)
D16 D26 P8
37 (Standard Cab) 37 (Standard Cab) 37 (Standard Cab)
36 (Access Cab) D29 34 36 (Access Cab)
D17 P10
37 (Standard Cab) D30 34 37 (Standard Cab)
D18 36 (Access Cab) 36 (Access Cab) S9 35
I26
D19 36 (Access Cab) 37 (Standard Cab) S10 35
D20 36 (Access Cab) J3 35 31 (2UZ–FE)
T10
D21 36 (Access Cab) J4 35 33 (5VZ–FE)
36 (Access Cab) J5 35 T11 A 35
D22
37 (Standard Cab) J7 35 T12 B 35
36 (Access Cab) J10 35 T13 C 35
D23
37 (Standard Cab) J13 35 U1 35
D24 36 (Access Cab) J21 A 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1A Roof Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1B
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1C
26 (*1)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1G
26 (*1)
22 (*2)
1H Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
22 (*2)
1K Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
1L 23 (*2)
1N Cowl Wire and Driver Side J/B (Lower
( Finish Panel))
27 (*1)
1O
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
202
2003 TOYOTA TUNDRA (EWD491U)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
IA4
44 Engine Room Main Wire and Cowl Wire (Left Kick Panel)
IA5
IB3
44 Front Door LH Wire and Cowl Wire (Left Kick Panel)
IB4
IC1 44 Cowl Wire and Roof Wire (Left Side of Instrument Panel)
IF3
46 Front Door RH Wire and Cowl Wire (Right Kick Panel)
IF4
BE2 48 (Access Cab) Floor No.2 Wire and Cowl Wire (Center of Left Rocker Panel)
BF2 48 (Access Cab) Floor No.1 Wire and Cowl Wire (Center of Right Rocker Panel)
BG2 48 (Access Cab) Floor No.2 Wire and Rear Door No.1 Wire LH (Under the Left Quarter Panel)
BH1 48 (Access Cab) Floor No.1 Wire and Rear Door No.1 Wire RH (Under the Right Quarter Panel)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
48 (Access Cab) 48 (Access Cab)
B3 Front Door LH Wire B7 Front Door RH Wire
50 (Standard Cab) 50 (Standard Cab)
48 (Access Cab) B8 48 (Access Cab) Rear Door No.1 Wire LH
B4 Roof Wire
50 (Standard Cab) B9 48 (Access Cab) Rear Door No.1 Wire RH
203
2003 TOYOTA TUNDRA (EWD491U)
J4
JUNCTION
204
CONNECTOR
E
E
L L L L
5 BE2
4 BG2
D16 (* 2) (*2) (* 2)
E
DOOR COURTESY SW
FRONT LH
1
L L
(* 1) (* 1)
D19
DOOR COURTESY SW
REAR LH UPPER
2
1
W–B B–W
(* 2) (* 2)
D18 J5
POWER WINDOW
2
1
C
W–B B–W B–W B–W B–W
BJ
B8
4 BE2
5 BG2
(* 2) (* 2) (* 2) (*2) (* 2)
14
9
L
7 1H
D21
DOOR COURTESY SW
REAR RH UPPER
5A
2
1
15
C
C
W–B B–W B–W B–W B–W B–W
6 1H
ECU IG
B9
5 BF2
4 BH1
(* 2) (* 2) (* 2) (*2) (* 2)
C
RELAY
(* 2)
B–W
D20
INTEGRATION
3
2
1
DOOR COURTESY SW
REAR RH LOWER
2
1
W–B B–W
BK
B9
(* 2) (* 2)
30A
8
2
POWER
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
D17
DOOR COURTESY SW B–W(*2)
FRONT RH
1
B–W B–W
(* 1) (* 1)
RELAY
POWER
W–B
8 1J
3
5
2 1C
3
G–B G–B
1 BF2
OPN
P22
1
1
1
L–R L–R
1C
C B
A A
M
(*3)
L–R
(*4)
(BACK WINDOW)
6
R–L R–L L–R
A A
4 BF2
CLS
(*4)
P21
A
JUNCTION
A
2
W–B
CONNECTOR
IF
(BACK WINDOW)
E1
J21 A , J22 B
J3
POWER WINDOW SW
L–R
L–R
JUNCTION
CONNECTOR
* 1 : STANDARD CAB
* 2 : ACCESS CAB
* 3 : 5VZ–FE W/O DAYTIME RUNNING LIGHT M/T
* 4 : EXCEPT * 3
L–R
L–R L–R
P10
9 POWER WINDOW MASTER SW
UP DOWN
LOCK SW
WINDOW
DOWN
UP
IC DOWN
UP
1 3 4 8 10
R–W
R–B
W–B
2 IB4 1 IB4
L–Y
LG
R–W
R–B
L–R
2 1
M
1 IB3
P11 2 IF4 1 IF4 3 IF4
POWER WINDOW
MOTOR FRONT LH
R–W
W–B
R–B
L–R
5 2
4
CONTROL SW RH
POWER WINDOW
A B
J23 A , J24 B
DOWN
UP
JUNCTION
CONNECTOR
P9
A A
3 1
L–Y
LG
W–B
1 2
M
P12
POWER WINDOW
MOTOR FRONT RH
IE
205
2003 TOYOTA TUNDRA (EWD491U)
POWER WINDOW
SYSTEM OUTLINE
With the ignition SW turned on, current flows through the ECU IG fuse to TERMINAL 9 of the integration relay to TERMINAL
2 to TERMINAL 1 of the power relay to TERMINAL 2 to GROUND, activating the power relay, and the current flowing from
TERMINAL 5 of the power relay flows to TERMINAL 3 to TERMINAL 9 of the power window master SW and TERMINAL 4 of
the power window control SW RH.
1. MANUAL OPERATION (DRIVER’S WINDOW)
With the ignition SW turned on and with the power window master SW (Manual SW) in UP position, the current flowing to
TERMINAL 9 of the power window master SW flows to TERMINAL 3 to TERMINAL 2 of the power window motor LH to
TERMINAL 1 to TERMINAL 4 of the master SW to TERMINAL 1 to GROUND and causes the power window motor to rotate
in the up direction. The window ascends only while the SW is being pushed.
In down operation, the current flowing from TERMINAL 9 of the power window master SW to TERMINAL 4 flows to
TERMINAL 1 of the motor LH to TERMINAL 2 to TERMINAL 3 of the master SW to TERMINAL 1 to GROUND, flowing in the
opposite direction to manual up operation, causing the motor to rotate in reverse and lowering the window.
2. AUTO DOWN OPERATION (DRIVER’S WINDOW)
With the ignition SW on and with the auto SW of the power window master SW in DOWN position, the current flowing to
TERMINAL 9 of the master SW flows to TERMINAL 4 of the master SW to TERMINAL 1 of the power window motor LH to
TERMINAL 2 to TERMINAL 3 of the master SW to TERMINAL 1 to GROUND, causing the motor to rotate towards the down
side.
Then the solenoid in the master SW is activated and it locks the auto SW being pushed, causing the motor to continue to
rotate in auto down operation.
When the window has completely descended, the current flowing between TERMINAL 3 of the master SW and TERMINAL 1
increases. As a result, the solenoid stops operating, the auto SW turns off and the flowing from TERMINAL 9 of the master
SW to TERMINAL 4 is cut off, stopping the motor so that auto stop occurs.
3. STOPPING OF AUTO DOWN AT DRIVER’S WINDOW
When the manual SW (Driver’s) is pushed to the up side during auto down operation, a ground circuit opens in the master
SW and current does not flow from TERMINAL 3 of the master SW to TERMINAL 1, so the motor stops, causing auto down
operation to stop. If the manual SW is pushed continuously, the motor rotates in the up direction in manual up operation.
4. MANUAL OPERATION BY POWER WINDOW CONTROL SW (PASSENGER’S WINDOW)
With the power window control SW RH is pushed to the up side, the current flowing from TERMINAL 4 of the power window
control SW RH flows to TERMINAL 3 of the power window control SW RH to TERMINAL 1 of the power window motor RH to
TERMINAL 2 to TERMINAL 1 of the power window control SW RH to TERMINAL 2 to TERMINAL 10 of the master SW to
TERMINAL 1 to GROUND. This causes the power window motor RH to rotate in the up direction. Up operation is continuous
only while the power window control SW RH is pushed to the up side. When the window descends, the current flowing to the
motor flows in the opposite direction, from TERMINAL 1 to TERMINAL 2, and the motor rotates in revers.
When the window lock SW is pushed to the lock side, the ground circuit to the passenger’s window becomes open. As a
result, even if Open/Close operation of the passenger’s window is tried, the current from TERMINAL 9 of the power window
master SW is not grounded and the motor does not rotate, so the passenger’s window can not be operated and window lock
occurs.
5. KEY OFF POWER WINDOW OPERATION
With the ignition SW turned from on to off, the integration relay operates for about 43 seconds and current flows from
TERMINAL 1 of the power relay to TERMINAL 2 to GROUND. For this period, current also flows TERMINAL 5 to TERMINAL
3. This current flows to TERMINAL 9 of the power window master SW and to TERMINAL 4 of the power window control SW
RH. As a result, for about 43 seconds after the ignition SW is turned off, it is possible to raise and lower the power window by
the functioning of the integration relay. Also, by opening the door (Door courtesy SW on) within about 43 seconds after
turning the ignition SW to off, a signal is input to TERMINAL 3, 14 or 15 of the integration relay. As a result, the integration
relay turns off, and up and down movement of the window stops.
206
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
D16, D17 DOOR COURTESY SW LH, RH
1–GROUND : Continuity with door open
INTEGRATION RELAY
9–GROUND : Approx. 12 volts with ignition SW at ON position
3–GROUND : Always approx. 12 volts
14–GROUND : Continuity with front LH door open
15–GROUND : Continuity with front RH door open (Standard cab)
15–GROUND : Continuity with front RH, rear LH, RH door open (Access cab)
P9 POWER WINDOW CONTROL SW RH
4–GROUND : Approx. 12 volts with ignition SW on and stays at 12 volts for 41.5 –44.5 seconds after the ignition SW is turned
off, but if a door is open in the 45 seconds period, voltage will drop to 0 volts
P10 POWER WINDOW MASTER SW
1–GROUND : Always continuity
9–GROUND : Approx. 12 volts with ignition SW on and stays at 12 volts for 41.5 –44.5 seconds after the ignition SW is turned
off, but if a door is opened in this 41.5 –44.5 seconds period, voltage will drop to 0 volts
3–GROUND : Approx. 12 volts with ignition SW at ON position and master SW at UP position
4–GROUND : Approx. 12 volts with ignition SW at ON position and master SW at DOWN or AUTO DOWN position
WINDOW LOCK SW
Open with window lock SW at LOCK position
: PARTS LOCATION
Code See Page Code See Page Code See Page
36 (Access Cab) J4 35 P10 37 (Standard Cab)
D16
37 (Standard Cab) J5 35 36 (Access Cab)
P11
36 (Access Cab) J21 A 35 37 (Standard Cab)
D17
37 (Standard Cab) J22 B 35 36 (Access Cab)
P12
D18 36 (Access Cab) J23 A 35 37 (Standard Cab)
D19 36 (Access Cab) J24 B 35 P21 35
D20 36 (Access Cab) 36 (Access Cab) P22 36 (Access Cab)
P9
D21 36 (Access Cab) 37 (Standard Cab)
J3 35 P10 36 (Access Cab)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1C
26 (*1)
22 (*2)
1H Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
207
2003 TOYOTA TUNDRA (EWD491U)
POWER WINDOW
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
B8 48 (Access Cab) Rear Door No.1 Wire LH B9 48 (Access Cab) Rear Door No.1 Wire RH
208
2003 TOYOTA TUNDRA (EWD491U)
MEMO
209
2003 TOYOTA TUNDRA (EWD491U)
KEY REMINDER AND SEAT BELT WARNING
2 5 1F
L–Y
6 1E
B–Y
3 1F
L–Y
C11 A , C12 B , C13 C
COMBINATION METER 5 B 9 A
SEAT BELT
7 A 2 B 1 C 12 B 8 B 13 B
CONNECTOR
B
W–B
L
Y–B
P–B
(* 6)
BR
JUNCTION
B
CONNECTOR
CONNECTOR
J10
E E
JUNCTION
JUNCTION
E L
B
(* 1)
(*3, * 4)
J7
J4
E E
B
(* 2)
L
P–B
(* 7)
1
WARNING SW
3 BI1
5 BE2
UNLOCK
U1
(*2)
(*3, * 4)
L
(*5)
2
B
4 BG2
P–B
(* 6)
1 A (*3)
BUCKLE SW LH
BUCKLE SW LH
3 C 2 B (*4)
B
A B
B7 A ,
(*2)
J23 A , J24 B
B7 C
JUNCTION
CONNECTOR
A A 4 C 2 A (*3)
1 B (*4)
BR
L
DOOR COURTESY
(* 1)
CONNECTOR
(*3, * 4)
C 1
W–B
W–B
W–B
(*5)
SW FRONT LH
JUNCTION
J8
C
D16
4 BI1
BR
W–B
(* 3, *4)
IE IH
210
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM OUTLINE
Current always flows to TERMINAL (B) 5 of the combination meter through the DOME fuse.
1. SEAT BELT WARNING SYSTEM
When the ignition SW is turned on, current flows from the GAUGE fuse to TERMINAL (A) 9 of the combination meter. This
current activates the combination meter and the current flowing through the seat belt warning light flows from TERMINAL (B)
8 to GROUND, causing the warning light to light up. A buckle SW off signal is input to TERMINAL (B) 12 of the combination
meter to TERMINAL (B) 8 to GROUND, causing the warning light to light up. A buckle SW off signal is input to TERMINAL
(B) 12 of the combination meter, the current flowing to TERMINAL (B) 5 of the combination meter flows from TERMINAL (B)
8 to GROUND and the seat belt warning buzzer sounds. However, if the seat belt is put on during this period (While the
buzzer is sounding), signal input to TERMINAL (B) 12 of the combination meter stops and the current flow from TERMINAL
(B) 5 of the combination meter to TERMINAL (B) 8 to GROUND is cut, causing the buzzer to stop.
2. KEY REMINDER SYSTEM
With the ignition key inserted in the key cylinder (Unlock warning SW on), the ignition SW still off and driver’s door open
(Door courtesy SW on), when a signal is input to TERMINAL (B) 13 of the combination meter, the combination meter
operates, current flows from TERMINAL (B) 5 of the combination meter to TERMINAL (B) 8 to GROUND and key reminder
buzzer sounds.
SERVICE HINTS
B7 (A), (B) BUCKLE SW LH
(A) 1–(A) 2, (B) 2–(B) 1 : Closed with driver’s seat belt in use
D16 DOOR COURTESY SW FRONT LH
1–GROUND : Closed with front LH door open
U1 UNLOCK WARNING SW
1–2 : Closed with ignition key in cylinder
C11 (A), C12 (B), C13 (C) COMBINATION METER
(A) 7, (B) 8–GROUND : Always continuity
(B)13–GROUND : Continuity with the front LH door open
(C) 1–GROUND : Continuity with the ignition key in cylinder
(B)12–GROUND : Continuity with the driver’s seat belt in use
(B) 5–GROUND : Always approx. 12 volts
(A) 9–GROUND : Approx. 12 volts withe ignition SW at ON or ST position
: PARTS LOCATION
Code See Page Code See Page Code See Page
A 38 (w/ Power Seat) C12 B 34 J8 35
36 (Access Cab *3) C13 C 34 J10 35
B
B7 37 (Standard Cab *3) 36 (Access Cab) J23 A 35
D16
36 (Access Cab *4) 37 (Standard Cab) J24 B 35
C
37 (Standard Cab *4) J4 35 U1 35
C11 A 34 J7 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
211
2003 TOYOTA TUNDRA (EWD491U)
KEY REMINDER AND SEAT BELT WARNING
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
Code See Page Joining Wire Harness and Wire Harness (Connector Location)
BE2 48 (Access Cab) Floor No.2 Wire and Cowl Wire (Center of Left Rocker Panel)
BG2 48 (Access Cab) Floor No.2 Wire and Rear Door No.1 Wire LH (Under the Left Quarter Panel)
48 (Access Cab)
BI1 50 (Standard Cab) Cowl Wire and Seat No.1 Wire ((Under the Driver’s Seat))
52
: GROUND POINTS
212
2003 TOYOTA TUNDRA (EWD491U)
MEMO
213
2003 TOYOTA TUNDRA (EWD491U)
CIGARETTE LIGHTER AND POWER OUTLET
* 1 : W/ CIGARETTE LIGHTER ILLUMINATION FROM POWER SOURCE SYSTEM (SEE PAGE 56)
* 2 : W/O CIGARETTE LIGHTER ILLUMINATION
* 3 : TOWING PACKAGE
* 4 : EXCEPT TOWING PACKAGE
15A
ACC
6 1G 12 1G
GR
B–L
(*3)
B
(* 4) 16 IA4
GR
2 2 2
GR
1 1 1
140A ALT (* 3)
100A ALT (* 4)
15A 15A
PWR PWR
OUTLET1 OUTLET2
2 2 2
2 2
POWER OUTLET
5 2
G–B
G
1 ID2 (* 1)
RELAY
1 ID1 (* 2)
2 IA4 10 IA5 3 1
2 2
G–B
GR
G
W–B
2 2
P6 P7 B 2
POWER POWER C7
OUTLET OUTLET CIGARETTE
LIGHTER
1 1 1
W–B
W–B
W–B
B–L
(*3)
(*4)
B
I2
CONNECTOR
JUNCTION
A 2 ID2 (* 1)
2 ID1 (* 2)
W–B
J18
A
W–B
BATTERY
W–B
I2
W–B
W–B
A
J3
JUNCTION
CONNECTOR
EA IF
214
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
C7 CIGARETTE LIGHTER
2–GROUND : Approx. 12 volts with ignition SW at ON or ACC position
1–GROUND : Always continuity
P6, P7 POWER OUTLET
2–GROUND : Approx. 12 volts with the ignition SW at ON or ACC position
1–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
C7 34 31 (2UZ–FE) P6 35
J18
J3 35 33 (5VZ–FE) P7 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1G Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I2 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
215
2003 TOYOTA TUNDRA (EWD491U)
CLOCK
2
6
INTEGRATION 2 10 1G
RELAY
L–Y
GR
4
4 1G 6 1E
4 1F
G
L–Y
E B A
J10 J23 A , J24 B
JUNCTION JUNCTION
CONNECTOR CONNECTOR
E
C B
L–Y
GR
G
5 B 13 B
B ACC
I24 A , I25 B
INTEGRATION CONTROL
AND PANEL
ILL+ GND
7 A 1 B
W–B
G
W–B
A
J13
JUNCTION
CONNECTOR
II
216
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
I24 (A), I25 (B) INTEGRATION CONTROL AND PANEL
(B) 5–GROUND : Always approx. 12 volts (Power for clock)
(B)13–GROUND : Approx. 12 volts with ignition SW at ON or ACC position (Power for indication)
(A) 7–GROUND : Approx. 12 volts with light control SW at TAIL or HEAD position (Signal of indication)
(B) 1–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
I24 A 35 J10 35 J23 A 35
I25 B 35 J13 35 J24 B 35
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1G
26 (*1)
: GROUND POINTS
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
217
2003 TOYOTA TUNDRA (EWD491U)
HORN
10A
HORN
INTEGRATION
RELAY
12 1N (*2, * 4)
12 1L (*5) 8 1E
G–R
A
G–R
(* 3)
J10
JUNCTION
CONNECTOR
A
G–R
(* 1)
6 B
C16 1 1
HORN SW
[COMB. SW]
H8 H7
HORN RH HORN LH
218
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
C16 HORN SW [COMB. SW]
6–GROUND : Continuity with horn SW on
: PARTS LOCATION
Code See Page Code See Page Code See Page
C16 34 H7 32 (5VZ–FE) H8 32 (5VZ–FE)
H7 30 (2UZ–FE) H8 30 (2UZ–FE) J10 35
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
1L 23 (*2)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
1N 27 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
219
2003 TOYOTA TUNDRA (EWD491U)
WIPER AND WASHER (w/ INT TIME SW MECHANISM)
C17
WIPER AND WASHER SW[COMB. SW]
LOW
HIGH
3 1G 3 1E 2 1G 5 1F
WASHER
B–Y
L
L
WIPER RELAY
WASHER MOTOR
9
WARNING LIGHT
[COMB. METER]
WASHER LEVEL
L
3
W2
4
C11
1
17 8 7 16 2 11
LG–R
L–R
W–B
L–W
L–R
L–B
Y–L
L
23 IA4
10 IA4
L–R
L–R
LG–R
L
WASHER LEVEL SENSOR
[WASHER MOTOR]
1
W–B
L–W
Y–L
L–B
W2
3 5 2 1 4
+2 +1 B S E 2
M
W–B
W–B
W–B
W4
WIPER MOTOR
A A
J3 J13
JUNCTION JUNCTION
CONNECTOR CONNECTOR
IF II EA
220
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM OUTLINE
With the ignition SW turned on, current flows to TERMINAL 17 of the wiper and washer SW, TERMINAL 3 of the washer
motor and TERMINAL 2 of the wiper motor through the WIP fuse.
1. LOW SPEED POSITION
With wiper SW turned to LOW position, current flows from TERMINAL 17 of the wiper and washer SW to TERMINAL 7 to
TERMINAL 5 of the wiper motor to TERMINAL 4 to GROUND and causes the wiper motor to run at low speed.
2. HIGH SPEED POSITION
With wiper SW turned to HIGH position, current flows from TERMINAL 17 of the wiper and washer SW to TERMINAL 8 to
TERMINAL 3 of the wiper motor to TERMINAL 4 to GROUND and causes the motor to run at high speed.
3. INT POSITION
With wiper SW turned to INT position, the relay operates and the current which is connected by relay function flows from
TERMINAL 17 of the wiper and washer SW to TERMINAL 2 to GROUND. This flowing the intermittent circuit and current
flows from TERMINAL 17 of the wiper and washer SW to TERMINAL 7 to TERMINAL 5 of the wiper motor to TERMINAL 4 to
GROUND and the wiper functions.
The intermittent operation is controlled by charging and discharging of the condenser installed in the relay and the
intermittent time is controlled by a time control SW to change the charging time of the condenser.
4. WASHER INTERLOCKING OPERATION
With the washer SW turned to on, current flows from TERMINAL 3 of the washer motor to TERMINAL 4 to TERMINAL 11 of
the wiper and washer SW to TERMINAL 2 to GROUND and causes to the washer motor to run, and the window washer is
jetted.
This causes current to flow to washer continuous operation circuit in TERMINAL 17 of the wiper and washer SW to
TERMINAL 7 to TERMINAL 5 of the wiper motor to TERMINAL 4 to GROUND and the wiper functions.
SERVICE HINTS
C17 WIPER AND WASHER SW [COMB. SW]
2–GROUND : Always continuity
17–GROUND : Approx. 12 volts with ignition SW at ON position
7–GROUND : Approx. 12 volts with wiper and washer SW at LOW position
Approx. 12 volts every approx. 1.6 to 10.7 seconds intermittently with wiper SW at INT position
16–GROUND : Approx. 12 volts with ignition SW on unless wiper motor at STOP position
8–GROUND : Approx. 12 volts with ignition SW on and wiper and washer SW at HIGH position
11–2 : Continuity with washer SW on
W4 WIPER MOTOR
1–2 : Closed unless wiper motor at STOP position
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 34 J13 35 31 (2UZ–FE)
W4
C17 34 31 (2UZ–FE) 33 (5VZ–FE)
W2
J3 35 33 (5VZ–FE)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1G
26 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
221
2003 TOYOTA TUNDRA (EWD491U)
WIPER AND WASHER (w/ INT TIME SW MECHANISM)
: GROUND POINTS
222
2003 TOYOTA TUNDRA (EWD491U)
MEMO
223
2003 TOYOTA TUNDRA (EWD491U)
WIPER AND WASHER (w/o INT TIME SW MECHANISM)
C17
WIPER AND WASHER SW[COMB. SW]
20A 10A
WIP GAUGE
MIST
OFF
LO
3 1G 3 1E 2 1G 5 1F
HIGH
WASHER
B–Y
L
L
9
WARNING LIGHT
[COMB. METER]
WASHER LEVEL
L
3
WASHER
MOTOR
M
W2
17 8 7 16 2 11 4
C11
1
W–B
L–W
L–R
Y–L
L–B
L
LG–R
L–R
23 IA4
10 IA4
L–R
L–R
LG–R
L
WASHER LEVEL SENSOR
W–B
[WASHER MOTOR]
1
W–B
L–W
Y–L
L–B
W2
3 5 2 1 4
+2 +1 B S E 2
M
W–B
W–B
W–B
W4
WIPER MOTOR
A A
J3 J13
JUNCTION JUNCTION
CONNECTOR CONNECTOR
IF II EA
224
2003 TOYOTA TUNDRA (EWD491U)
SYSTEM OUTLINE
With the ignition SW turned on, current flows to TERMINAL 17 of the wiper and washer SW, TERMINAL 3 of the washer
motor and TERMINAL 2 of the wiper motor through the WIP fuse.
1. LOW SPEED POSITION
With wiper SW turned to LOW position, current flows from TERMINAL 17 of the wiper and washer SW to TERMINAL 7 to
TERMINAL 5 of the wiper motor to TERMINAL 4 to GROUND and causes the wiper motor to run at low speed.
2. HIGH SPEED POSITION
With wiper SW turned to HIGH position, current flows from TERMINAL 17 of the wiper and washer SW to TERMINAL 8 to
TERMINAL 3 of the wiper motor to TERMINAL 4 to GROUND and causes the motor to run at high speed.
3. MIST POSITION
With the wiper SW turned to MIST position, current flows from TERMINAL 17 of the wiper and washer SW to TERMINAL 7 to
TERMINAL 5 of the wiper motor to TERMINAL 4 to GROUND and causes the wiper motor to run at low speed.
4. WASHER INTERLOCKING OPERATION
With the washer SW turned to on, current flows from TERMINAL 3 of the washer motor to TERMINAL 4 to TERMINAL 11 of
the wiper and washer SW to TERMINAL 2 to GROUND and causes to the washer motor to run, and the window washer is
jetted.
SERVICE HINTS
C17 WIPER AND WASHER SW [COMB. SW]
2–GROUND : Always continuity
17–GROUND : Approx. 12 volts with ignition SW at ON position
7–GROUND : Approx. 12 volts with wiper and washer SW at LOW or MIST position
16–GROUND : Approx. 12 volts with ignition SW on unless wiper motor at STOP position
8–GROUND : Approx. 12 volts with ignition SW on and wiper and washer SW at HIGH position
11–GROUND : Continuity with washer SW on
W4 WIPER MOTOR
1–2 : Closed unless wiper motor at STOP position
: PARTS LOCATION
Code See Page Code See Page Code See Page
C11 34 J13 35 31 (2UZ–FE)
W4
C17 34 31 (2UZ–FE) 33 (5VZ–FE)
W2
J3 35 33 (5VZ–FE)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
22 (*2)
1G
26 (*1)
: GROUND POINTS
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
225
2003 TOYOTA TUNDRA (EWD491U)
MIRROR HEATER
10A 15A
GAUGE MIR HTR
9 1F 2
B–Y
J11
JUNCTION
CONNECTOR
E CONNECTOR
JUNCTION
E B–Y D D
R–W
J8
E D
16 IA5
R–W
R–W
R–W
B–Y
B–Y
M4
2 MIRROR HEATER SW 2 3
R–W
R–W
R–W
[REMOTE CONTROL MIRROR RH]
[REMOTE CONTROL MIRROR LH]
IG
MIR HTR
RELAY
2 2
MIRROR HEATER RH
E D
MIRROR HEATER LH
1 5
4 6
2 2
P–G
6 6
R8
R9
R–W
W–B
W–B
W
W–B
P–G
W–B
W–B
W–B
A B A B
J23 A , J24 B
JUNCTION
CONNECTOR
A A
W–B
A
J13
JUNCTION
CONNECTOR
IE II
226
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
MIR HTR RELAY
5–3 : Closed with the ignition SW on and the mirror heater SW on
M2 MIRROR HEATER SW
2–GROUND : Approx. 12 volts with the ignition SW on
4–GROUND : Always continuity
R8, R9 MIRROR HEATER LH, RH [REMOTE CONTROL MIRROR LH, RH]
2–GROUND : Approx. 12 volts with the ignition SW on and the mirror heater SW on
6–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
J8 35 J24 B 35 36 (Access Cab)
R9
J11 35 M4 35 37 (Standard Cab)
J13 35 36 (Access Cab)
R8
J23 A 35 37 (Standard Cab)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
227
2003 TOYOTA TUNDRA (EWD491U)
REMOTE CONTROL MIRROR
15A
ACC
11 1G
GR
(A/T)
A
J9
(M/T)
GR
JUNCTION
CONNECTOR
A
GR
(A/T)
7 IB3
GR
R10
REMOTE CONTROL
8 MIRROR SW
OPERATION SW
DOWN/
DOWN
RIGHT
RIGHT
LEFT
LEFT
UP
UP/
SELECT SW
LH RH LH RH
5 2 4 3 6 7
LG–R
W–B
P–G
Y–B
L–B
R
L–B
P–G
Y–B
B2
Y–B
Y–B
Y–B
L–B
R
W–B
Y–B
L–B
A B J23 A , J24 B
3 A 1 A 5 A (* 1) 3 A 1 A 5 A (* 1)
JUNCTION
2 B 3 B 1 B (* 2) 2 B 3 B 1 B (* 2) CONNECTOR
A A
M M M M
W–B
R8 A , B R9 A , B
REMOTE CONTROL MIRROR LH REMOTE CONTROL MIRROR RH
IE
228
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
R10 REMOTE CONTROL MIRROR SW
8–GROUND : Approx. 12 volts with ignition SW at ACC or ON position
6–7 : Continuity with operation SW at UP or LEFT position
8–6 : Continuity with operation SW at DOWN or RIGHT position
: PARTS LOCATION
Code See Page Code See Page Code See Page
J9 35 A 37 (Standard Cab) R9 B 37 (Standard Cab)
R8
J23 A 35 B 37 (Standard Cab) 36 (Access Cab)
R10
J24 B 35 36 (Access Cab) 37 (Standard Cab)
A
A 36 (Access Cab) R9 37 (Standard Cab)
R8
B 36 (Access Cab) B 36 (Access Cab)
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1G Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
B2 48 (Access Cab) Front Door LH Wire B2 50 (Standard Cab) Front Door LH Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
229
2003 TOYOTA TUNDRA (EWD491U)
POWER SEAT
30A
POWER
4 1C
W–G
C A
C W–G W–B
A
J23 A 1 2
JUNCTION
CONNECTOR S8
SHORT
PIN
3
2
W–G L–W A A L–W
BI1
J16
A JUNCTION
CONNECTOR
L–W
L3
P16 LUMBAR SUPPORT
POWER SEAT CONTROL SW CONTROL SW
(DRIVER’ S SEAT) 1 4 (DRIVER’ S SEAT)
FRONT
FRONT
REAR
DOWN
DOWN
REAR
UP
UP
FRONT REAR
SLIDE VERTICAL VERTICAL RECLINING
9 6 10 5 7 8 3 2 4 3 1 2
JUNCTION CONNECTOR
W–B
W–B
A
A
W–G
W–R
Y–G
B–R
Y–R
L–R
A 1 BJ1 2 BJ1
B
J17
L
POWER SEAT MOTOR
1
(DRIVER’ S SEAT
1 BI1
M
1 2 1 2 2 1 2 1
W–B
M M M M 2
P20
A A W–B
A B
J23 A , J24 B
W–B
JUNCTION
CONNECTOR
IE
230
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
P16 POWER SEAT CONTROL SW (DRIVER’S SEAT)
1–9 : Closed with driver’s seat at front slide operation
1–6 : Closed with driver’s seat at rear slide operation
1–3 : Closed with driver’s seat at front reclining operation
1–2 : Closed with driver’s seat at rear reclining operation
1–10 : Closed with driver’s seat at front vertical up operation
1–5 : Closed with driver’s seat at front vertical down operation
1–7 : Closed with driver’s seat at rear vertical up operation
1–8 : Closed with driver’s seat at rear vertical down operation
4–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
J16 38 L3 38 P18 38
J17 38 P15 38 P19 38
J23 A 35 P16 38 P20 38
J24 B 35 P17 38 S8 35
,,,
,,,
,,,
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1C Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I1 46 Cowl Wire
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
231
2003 TOYOTA TUNDRA (EWD491U)
RADIO AND PLAYER
FROM POWER SOURCE SYSTEM (SEE PAGE 56) * 1 : W/ DOOR LOCK CONTROL
* 2 : W/O DOOR LOCK CONTROL
* 3 : ACCESS CAB
1
I25
20A 15A INTEGRATION CONTROL
RADIO ACC AND PANEL
ACC ACC1
2 13 14
C16
2 10 1G STEERING PAD SW
[COMB. SW]
GR
GR
GR
R
G–B
R
L
5 II1 3 II1 4 II1
R
G–B
GR
L
R 1 A , R 2 B , R11 C
4 B RADIO AND PLAYER 3 B 6 C 7 C 8 C
B ACC SWG SW1 SW2
(*3)
(*3)
(*3)
LG
W
R
P
Y
L
(* 1)
(* 2)
(* 1)
(* 3)
(* 3)
(* 3)
(* 3)
BR
LG
LG
W
R
P
Y
L
LG
L
LG 2 1 L LG 2 1 L
(*3)
(*3)
(*3)
(*3)
W
R
B
B5 B5 B1 B1
T8 T7
TWEETER RH TWEETER LH
LG
LG
L
1 2 1 2 1 2 1 2
F9 F8 R6 R7
FRONT DOOR SPEAKER FRONT DOOR SPEAKER REAR DOOR SPEAKER REAR DOOR SPEAKER
IG RH LH LH RH
232
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
R2 (B) RADIO AND PLAYER
(B) 3–GROUND : Approx. 12 volts with ignition SW at ON or ACC position
(B) 4–GROUND : Always approx. 12 volts
(B) 7–GROUND : Always continuity
S7 (D) STEREO COMPONENT AMPLIFIER
(D) 3–GROUND : Approx. 12 volts with ignition SW at ON or ACC position
(D) 4–GROUND : Always approx. 12 volts
(D) 7–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
C16 34 I25 35 R11 C 35
36 (Access Cab) R1 A 35 36 (Access Cab)
F8 T7
37 (Standard Cab) R2 B 35 37 (Standard Cab)
36 (Access Cab) R6 36 (Access Cab) 36 (Access Cab)
F9 T8
37 (Standard Cab) R7 36 (Access Cab) 37 (Standard Cab)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1G Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
48 (Access Cab) 48 (Access Cab)
B1 Speaker Tweeter Wire LH B5 Speaker Tweeter Wire RH
50 (Standard Cab) 50 (Standard Cab)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
233
2003 TOYOTA TUNDRA (EWD491U)
COMBINATION METER
E3 A , E4 B 1
F7
INTEGRATION 4WD CONTROL ENGINE CONTROL
RELAY ECU MODULE
10A 10A
GAUGE DOME
SPD(*1)
SPD SP1(*2) 2
3 17 B (* 1)
6 A (* 2)
G–O
8 1F 5 1F 11 1N 11 1L 2
(* 1)
G–O
L–Y
G–O
G–O
B–Y
(*5)
(*8)
D D 6 1E
D
B–Y
D J9
JUNCTION
CONNECTOR 3 1F
G–O
L–Y
C11 A , C12 B , C13 C , C14 D
9 A 3 C COMBINATION METER 5 B
SPEEDOMETER TACHOMETER
LCD
SEAT BELT
DOOR
SRS
2 C 13 C 12 B 13 B 9 B 1 C 4 C 6 B 7 B 10 C
W–L
B–Y
R
(*2)
B
G–B
B–Y
P–B
R–L
P–L
P–L
L–B
(*1)
(*2)
(*2)
(*1)
TO IGNITION KEY
TO DOOR COURTESY
SENSOR ASSEMBLY
5 IE1
TO CENTER AIRBAG
CYLINDER LIGHT
TO UNLOCK WARNING
2 4 IE3 6
TO BUCKLE SW
CYLINDER LIGHT
B–Y
G–B
R–L
P–L
P–L
(*1)
(*2)
(*2)
(*1)
SW
L–W
(* 2)
(* 1)
B
SW LH
SW
3 2
ENGINE CONTROL
B–Y
8 5 A
1 V2 TACH
MODULE
VEHICLE SPEED
IGNITER
E3 A
B–Y SENSOR
(COMBINATION
I2
METER)
234
2003 TOYOTA TUNDRA (EWD491U)
W3 A , B
WATER TEMP. SENDER
WATER TEMP.
10
13
Y–R Y–R
6 A
1 B (* 2)
1 A (* 1)
IE1 (* 2)
IE1 (* 1)
FUEL
BR BR
8 B
2
Y–R Y–R
F10
6 C
BR
FUEL
4 BB1
SENDER
C
FUEL
3
1
C
C
BR BR BR B–R B–R
5 C
IH
6 BB1
5 BB1
J8
O/D OFF
TO ENGINE CONTROL L–O
3 D
MODULE
JUNCTION
CONNECTOR
1
Y–B
(*6) OIL
HEAT WIRE
O6 (* 6) (* 6)
OIL PRESSURE SENDER
8
24
OIL
1
Y–B Y–B
12 A
COMBINATION METER
(*7) (* 7) (* 7)
IE1 (* 2)
IE1 (* 1)
SW
O2
WASHER
LG–R
1 A
C11 A , C12 B , C13 C , C14 D
SENSOR
OIL PRESSURE
*
*
*
*
*
*
*
*
4LO
FROM INTEGRATION CONTROL BR–Y
8 A
AND PANEL (*1) (* 1) (*1) (* 1)
2 : 5VZ–FE
1 : 2UZ–FE
BR–Y
1 D
3 : 5VZ–FE A/T
(*1) (* 1)
4HI (*1)
6 : W/ TACHOMETER
4WD (*2)
7 : W/O TACHOMETER
Y–B
8 : W/O DAYTIME RUNNING LIGHT
10 B
GR
TO ADD DETECTION SW (*2)
(*2)
235
236
A/T OIL TEMP.
Y–R
10 D
TO ENGINE CONTROL
MODULE MALFUNCTION
INDICATOR LAMP
V–G
8 C
B–R
(*1)
TO ENGINE CONTROL
MODULE CRUISE
Y
9 C
(*2)
J18
JUNCTION
CONNECTOR BRAKE
COMBINATION METER
A
A
2
1
W–B W–B G–W G–W
11 A
4 1E
5 1B
EA
A
B2
BRAKE FLUID LEVEL
6
WARNING SW
1B
W–B
18
IA5
1
R–W
(*8 A/T)
W–B
P5
(*5)
Y–B
R–W
G–W
2 B
FROM UNLOCK WARNING SW
(* 8 M/T)
BRAKE
SW (A/T)
PARKING
A
A
2
1
W–B W–B
IF
I2
(M/T)
J3
P5
R–W
SW (M/T)
PARKING
RELAY
(* 5 A/T)
JUNCTION
R–W
CONNECTOR
(* 5 M/T)
1 1N
13 1N
A
W–B
II
ABS
B–L
7 C
TO ABS ACTUATOR WITH ECU
COMBINATION METER
J13
VOLT
JUNCTION
W–B
CONNECTOR
13 A
C11 A , C12 B , C13 C , C14 D
HIGH BEAM
R–G FROM INTEGRATION RELAY (* 5)
16 B
W–B
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
5A
IGN * 1: 2UZ–FE
* 2: 5VZ–FE
* 5: W/ DAYTIME RUNNING LIGHT
* 8: W/O DAYTIME RUNNING LIGHT
FROM TURN SIGNAL
10 1F
FROM INTEGRATION
FLASHER
RELAY
[PARK/NEUTRAL POSITION SW]
LG–B
W–R
G–Y
G–B
R–B
L–Y
LG
G
L
12 C 1 B 3 B 9 D 8 D 7 D 6 D 5 D 4 D 15 B
(*2)
ILLUMINATION
TURN RH
TURN LH
CHARGE
A/T P
D
P
L
(* 2)
(*2)
7 A 4 B 2 D 14 B
C11 A , C12 B , C13 C , C14 D
COMBINATION METER
W–G
W–B
Y–G
R–Y
(*2)
(TRANSFER NEUTRAL
TO RHEOSTAT
TO GENERATOR
TO DETECTION SW
W–B
I1
POSITION)
W–B
A B
J23 A , J24 B
JUNCTION
CONNECTOR
A A
W–B
IE
237
2003 TOYOTA TUNDRA (EWD491U)
COMBINATION METER
SERVICE HINTS
B2 BRAKE FLUID LEVEL WARNING SW
1–2 : Closed with float down
P5 PARKING BRAKE SW
1–GROUND : Closed with parking brake lever pulled up
C11 (A), C12 (B), C13 (C) COMBINATION METER
(B) 5–GROUND : Always approx. 12 volts
(A) 9, (B) 3–GROUND : Approx. 12 volts with ignition SW at ON or ST position
(A) 7, (A)13, (B) 8–GROUND :Always continuity
W3 (A), (B) WATER TEMP. SENDER
(A) 1, (B) 1-GROUND : Approx. 160–240 Ω (50°C, 122°F)
: Approx. 17.1–21.2 Ω (120°C, 248°F)
: PARTS LOCATION
Code See Page Code See Page Code See Page
30 (2UZ–FE) 36 (Access Cab) J23 A 35
B2 F10
32 (5VZ–FE) 37 (Standard Cab) J24 B 35
C11 A 34 I2 33 (5VZ–FE) 31 (2UZ–FE)
O2
C12 B 34 J3 35 33 (5VZ–FE)
C13 C 34 J8 35 P5 35
C14 D 34 J9 35 31 (2UZ–FE)
V2
E3 A 34 J13 35 33 (5VZ–FE)
E4 B 34 31 (2UZ–FE) A 31 (2UZ–FE)
J18 W3
F7 35 33 (5VZ–FE) B 33 (5VZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1B Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
1L 23 (*2)
1N 27 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
238
2003 TOYOTA TUNDRA (EWD491U)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
I1 46 Cowl Wire I2 46 Cowl Wire
239
2003 TOYOTA TUNDRA (EWD491U)
AIR CONDITIONING
B–Y
B–Y
J8
JUNCTION
E CONNECTOR
B–Y E E
B–Y
B–Y
B–Y
5
+
DEFROSTER SW
M 6
[BLOWER SW]
A15
AIR INLET
CONTROL
SERVO MOTOR
B6
7
FRS REC
2 1
B–L
B–W
B–Y
15 A 13 A 4 B 9 B
FRS REC IG L
I24 A , I25 B
INTEGRATION CONTROL AND PANEL
AIND(*1) A/CM(* 1)
ACT(* 2) A/CS AC1(* 2) MGC E IN
18 A 21 A 19 A 8 A 10 A 20 A
L–B
L–Y
(* 1)
W–L
L
L–R
(* 1)
(* 2)
16 IE2 (*3)
W–G
(*2)
IE3 (*4)
(* 2)
4 IE1 8
B–L
G–W
B–W
W–L
L–R
(* 1)
(* 1)
(* 1)
(* 2)
2 B (* 1) 3 A (* 1)
B–W
33 B 31 B 2 A 1 A
(*1)
3 A 9 A (* 2) 1 B (* 2)
ACID(*1) A/CS ACMG(* 1)
A/C LOCK SENSOR
ACT(* 2) AC1(* 2)
A/C MAGNETIC
1
A/C THERMISTOR
LCK1 E2
CLUTCH
23 C 28 E
E3 A , E4 B ,
A13
E5 C , E7 E 2
ENGINE CONTROL
G–W
MODULE
(*1)
A2 B
A/C MAGNETIC CLUTCH
A3 A
A/C MAGNETIC CLUTCH
AND LOCK SENSOR
240
2003 TOYOTA TUNDRA (EWD491U)
FROM POWER SOURCE SYSTEM (SEE PAGE 56)
B–Y 1
2 2
L–R
9 1F 5 1E 2
10A
B–Y
B–Y
R
A/C
C
2
J1
2 13 IA4 JUNCTION
2 CONNECTOR
C
W–L
PRESSURE SW
B–Y
A/C DUAL
L–R
* 1: 2UZ–FE
R
* 2: 5VZ–FE
A1
* 3: 5VZ–FE A/T
* 4: 5VZ–FE M/T 2 2
2 5
1 1
B4 4
W–L
(*2)
(*2)
BLOWER HTR
O
M
MOTOR RELAY
2
8 IA4 17 IA4 2 IA5 1 3
2 2 2
L–W
W–L
(* 2)
(* 2)
O
L–R
L–B
W–B
Y–R
6 A 11 B 12 B
IG+ AC+2 B
19 IA4
B5
I24 A , I25 B BLOWER RESISTOR
INTEGRATION CONTROL AND PANEL L–B 4 1 W–B
Y–R
I16
GND 2 3
1 B
L–R
L–B
L–Y
8 4
W–B
H1 M2 M1 LO
5
3 Y–R
CONNECTOR
JUNCTION
1 W–B A
J18
B6 A
BLOWER SW
W–B
I4
W–B
W–B
CONNECTOR
JUNCTION
A A
A W–B W–B A J3
W–B
JUNCTION
J13
CONNECTOR
II IF EA
241
2003 TOYOTA TUNDRA (EWD491U)
AIR CONDITIONING
SYSTEM OUTLINE
1. HEATER BLOWER MOTOR OPERATION
Current is applied at all times through the HTR fuse to TERMINAL 5 of the HTR relay.
When the ignition SW is turned on, current flows through the GAUGE fuse to TERMINAL 2 of the HTR relay to the coil side
to TERMINAL 1 to TERMINAL 3 of the blower SW.
242
2003 TOYOTA TUNDRA (EWD491U)
SERVICE HINTS
HTR RELAY
5–3 : Closed with ignition SW on and heater blower SW on
A1 A/C DUAL PRESSURE SW
1–2 : Open with refrigerant pressure at less than approx. 2.0 kgf/cm2 (196.1 kpa, 28.4 psi) or
more than approx. 32.0 kgf/cm2 (3138.1 kpa, 455 psi)
I24 (A), I25 (B) INTEGRATION CONTROL AND PANEL
(B) 4–GROUND : Approx. 12 volts with ignition SW at ON or ST position
(B)12–GROUND : Approx. 12 volts with ignition SW on and blower SW on
(B) 1–GROUND : Always continuity
: PARTS LOCATION
Code See Page Code See Page Code See Page
30 (2UZ–FE) B6 34 J1 33 (5VZ–FE)
A1
32 (5VZ–FE) E3 A 34 J3 35
A2 B 32 (5VZ–FE) E4 B 34 J8 35
A3 A 30 (2UZ–FE) E5 C 34 J13 35
A13 34 E7 E 34 31 (2UZ–FE)
J18
A15 34 I24 A 35 33 (5VZ–FE)
B4 34 I25 B 35
B5 34 J1 31 (2UZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1E Engine Room Main Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1F Cowl Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
40 (2UZ–FE) I4
E1 Engine Room Main Wire 46 Cowl Wire
42 (5VZ–FE) I16
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
243
2003 TOYOTA TUNDRA (EWD491U)
I GROUND POINT
W–B C C W–B
SUB BATT RELAY 2 A/C PRESSURE SW
(TOWING PACKAGE) (*5)
C W–B
2 ST RELAY
(*5)
C J2
W–B
JUNCTION
(*5)
CONNECTOR
A
DAYTIME RUNNING W–B A A W–B
FRONT FOG LIGHT LH
LIGHT RESISTOR (* 1)
W–B A W–B
FOG RELAY 2 FRONT FOG LIGHT RH
(* 2)
W–B A A W–B
DRL NO. 4 RELAY 2 2 POWER OUTLET RELAY
(* 1)
W–B A
EFI RELAY 2 A W–B FRONT TURN SIGNAL
LIGHT AND PARKING
LIGHT LH
W–B A
HTR RELAY 2
18
BRAKE FLUID LEVEL W–B A A W–B W–B W–B
IA5
WARNING SW
EA
IGNITER AND BR
IGNITION COIL NO. 1
IGNITER AND BR
IGNITION COIL NO. 2
IGNITER AND BR
E5
IGNITION COIL NO. 3
1
IGNITER AND BR BR BR BR CRUISE CONTROL SW
I3 IE2
IGNITION COIL NO. 4 [COMB. SW]
BR
IGNITER AND BR BR
(E1)
IGNITION COIL NO. 5
BR W–B
NOISE FILTER E5 (E01)
W–B
W–B
BR
25
BR
DATA LINK BR BR
(SG) IE1
CONNECTOR 3
(2UZ–FE) (2UZ–FE)
EC EB
244
2003 TOYOTA TUNDRA (EWD491U)
W–B W–B
PERSONAL LIGHT
W–B W–B
VANITY LIGHT RH CIGARETTE LIGHTER
W–B
VANITY LIGHT LH B4
2 ID2 (* 3)
2 ID1 (* 4)
W–B
LIGHT WIPER AND WASHER SW
[COMB. SW]
2 1A W–B W–B
POWER RELAY I2 PARKING BRAKE SW
(M/T)
8
W–B A A W–B W–B
W–B
INTEGRATION RELAY 1J POWER OUTLET
12
W–B W–B A W–B
FUEL PUMP BB1 I2 POWER OUTLET
J3 W–B
JUNCTION TURN SIGNAL SW
W–B W–B A CONNECTOR [COMB. SW]
W–B
W–B LIGHT CONTROL SW
[COMB. SW]
POWER WINDOW W–B A
CONTROL SW W–B
(BACK WINDOW) I2 DATA LINK
CONNECTOR 3
W–B A
BLOWER SW
IF
17
BR BR CRUISE CONTROL SW
IE1
[COMB. SW]
3 14
HEATED OXYGEN BR BR BR BR
SENSOR BD1 IE1 I3 (E1)
(BANK 1 SENSOR 2)
W–B
(E02)
BR
NOISE FILTER
W–B
(E03)
BR
ENGINE
CONTROL
W–B MODULE
(E05)
W–B
W–B
W–B
W–B
15 (E01)
DATA LINK W–B W–B
(SG) IE1
CONNECTOR 3
BR
(ME01)
W–B
IGNITER
(5VZ–FE)
ED
BR
* 1 : W/ DAYTIME RUNNING LIGHT RADIO AND PLAYER
* 2 : W/O DAYTIME RUNNING LIGHT
* 3 : W/ CIGARETTE LIGHTER ILLUMINATION
* 4 : W/O CIGARETTE LIGHTER ILLUMINATION
* 5 : 2UZ–FE
IG
245
2003 TOYOTA TUNDRA (EWD491U)
I GROUND POINT
W–B W–B
W–B
RHEOSTAT
19
PARK/NEUTRAL W–B W–B W–B
IE2 I1 GLOVE BOX LIGHT
POSITION SW (5AZ–FE A/T) (5AZ–FE A/T)
W–B
W–B
O/D MAIN SW
(A/T)
W–B
I1 SHORT PIN
W–B
W–B
(E1)
COMBINATION
METER
W–B W–B
I1 (E2)
W–B W–B
W–B
BACK–UP LIGHT RELAY CLUTCH START SW
(A/T) (M/T)
3
LICENSE PLATE W–B W–B W–B W–B
BB2 I1 (–S)
LIGHT LH (M/T)
CLUTCH START
W–B
CANCEL SW
LICENSE PLATE W–B W–B W–B
B10 (E)
LIGHT RH (M/T)
1 BI1
W–B
W–B
W–B
REAR COMBINATION
LIGHT LH
W–B
BL
REAR COMBINATION W–B
B10
LIGHT RH
CONNECTOR
A
JUNCTION
2
W W A W–B LUMBAR SUPPORT
TRAILER SOCKET BK1 A CONTROL SW
B (DRIVER’ S SEAT)
J17
A
DOOR LOCK MOTOR W–B A A W–B
AND DOOR UNLOCK B A
DETECTION SW W–B POWER SEAT
FRONT LH CONTROL SW
(DRIVER’ S SEAT)
W–B
W–B
6 BE2
POWER WINDOW W–B
W–B
B3
MASTER SW
W–B W–B
W–B
BJ
MIRROR HEATER LH W–B
[REMOTE CONTROL
MIRROR LH]
A W–B
A TURN SIGNAL FLASHER
W–B A A W–B
COMBINATION (BRL) B A TVIP ECU
METER
W–B A A W–B
MIRROR HEATER SW B A SHORT CONNECTOR
(TVIP)
A A 3
W–B W–B W–B
TOWING CONVERTER B A IA4 TVIP BUZZER
246
2003 TOYOTA TUNDRA (EWD491U)
W–B W–B W–B MIRROR HEATER RH
[REMOTE CONTROL
MIRROR RH]
A
W–B A J13
(GND) JUNCTION
CONNECTOR W–B DOOR LOCK CONTROL
ABS ACTUATOR SW RH
WITH ECU
1
W–B A A W–B W–B W–B DOOR KEY LOCK AND
(GND) IF3 B7
UNLOCK SW RH
A
W–B
ADD ACTUATOR
(* 6, * 7)
W–B
6 ED1 (* 6)
6 EG1 (* 7)
W–B
(*6)
W–B
W–B
6 EC1
WIPER MOTOR I4 (* 7)
W–B TRANSFER SHIFT
W–B
(* 6)
(* 6) ACTUATOR
* 5 : 2UZ–FE
* 6 : 2UZ–FE 4WD
* 7 : 5VZ–FE 4WD W–B DETECTION SW
(*6, * 7)
W–B
W–B DETECTION SW
W–B W–B I3 (TRANSFER NEUTRAL
(* 7) POSITION)
4WD CONTROL ECU I4
(* 5) (* 6, *7)
W–B W–B
W–B
6 3
W–B W–B W–B W–B W–B DOOR COURTESY SW
BLOWER RESISTOR I4 BF2 BH1
REAR RH UPPER
11
BR BR
FUEL SENDER BB1
C
COMBINATION BR C C BR
(E3) OPTION CONNECTOR
METER
J8
24 JUNCTION
BR CONNECTOR
INTEGRATION RELAY 1N
(* 1)
16
BR C C BR
INTEGRATION RELAY 1L
(* 2)
C
CENTER AIRBAG W–B
(E1)
SENSOR ASSEMBLY
W–B
BUCKLE SW LH W–B SEAT BELT WARNING
(* 9)
BR
BR
OCCUPANT DETECTION
SENSOR AND BUCKLE
4 SW RH
W–B W–B
BUCKLE SW LH BI1
(* 8) (*8)
W–B W–B
(E2) CENTER AIRBAG
W–B SENSOR ASSEMBLY
IE IH
247
2003 TOYOTA TUNDRA (EWD491U)
I GROUND POINT
: PARTS LOCATION
Code See Page Code See Page Code See Page
31 (2UZ–FE) J13 35 J23 A 35
J2
33 (5VZ–FE) J17 38 J24 B 35
J3 35 31 (2UZ–FE)
J18
J8 35 33 (5VZ–FE)
: RELAY BLOCKS
Code See Page Junction Block and Wire Harness (Connector Location)
22 (*2)
1A Roof Wire and Driver Side J/B (Lower Finish Panel)
26 (*1)
22 (*2)
1J
26 (*1)
Cowl Wire and Driver Side J/B (Lower Finish Panel)
1L 23 (*2)
1N 27 (*1)
* 1 : w/ Daytime Running Light * 2 : w/o Daytime Running Light * 3 : Bench Seat * 4 : Separate Seat, Captain Seat (w/o Power Seat)
248
2003 TOYOTA TUNDRA (EWD491U)
: GROUND POINTS
: SPLICE POINTS
Code See Page Wire Harness with Splice Points Code See Page Wire Harness with Splice Points
E5 40 (2UZ–FE) Engine Wire B3 50 (Standard Cab) Front Door LH Wire
I1 48 (Access Cab)
46 Cowl Wire B4 Roof Wire
I2 50 (Standard Cab)
I3 46 Engine Wire 48 (Access Cab)
B7 Front Door RH Wire
I4 46 Cowl Wire 50 (Standard Cab)
48 (Access Cab) 48 (Access Cab)
B2 B10 Frame Wire
50 (Standard Cab) Front Door LH Wire 50 (Standard Cab)
B3 48 (Access Cab)
249
2003 TOYOTA TUNDRA (EWD491U)
J POWER SOURCE (Current Flow Chart)
250
2003 TOYOTA TUNDRA (EWD491U)
J
251
2003 TOYOTA TUNDRA (EWD491U)
J POWER SOURCE (Current Flow Chart)
∗ These are the page numbers of the first page on which the related system is shown.
252
2003 TOYOTA TUNDRA (EWD491U)
J
Fuse System Page
Integration Control and Panel 138
Interior Light 116
Key Reminder and Seat Belt Warning 210
Mirror Heater 226
Starting (5VZ–FE) 60
10A GAUGE
Trailer Towing 132
Wiper and Washer (w/ Int Time SW Mechanism) 220
Wiper and Washer (w/o Int Time SW Mechanism) 224
4WD (2UZ–FE) 174
4WD (5VZ–FE) 180
Horn 218
10A HORN
TVIP and Wireless Door Lock Control 196
Back–Up Light 108
Cigarette Lighter and Power Outlet 214
Clock 216
Cruise Control (2UZ–FE) 160
Cruise Control (5VZ–FE) 164
Electronically Controlled Transmission and A/T Indicator (2UZ–FE) 144
Electronically Controlled Transmission and A/T Indicator (5VZ–FE) 150
15A ACC
Integration Control and Panel 138
Radio and Player 232
Remote Control Mirror 228
SRS 169
Trailer Towing 132
4WD (2UZ–FE) 174
4WD (5VZ–FE) 180
ABS 156
Cruise Control (2UZ–FE) 160
Cruise Control (5VZ–FE) 164
Electronically Controlled Transmission and A/T Indicator (2UZ–FE) 144
15A STOP Electronically Controlled Transmission and A/T Indicator (5VZ–FE) 150
Engine Control (2UZ–FE) 76
Engine Control (5VZ–FE) 88
Stop Light 122
Trailer Towing 132
Clock 216
Engine Control (2UZ–FE) 76
Headlight (w/ Daytime Running Light) 98
Illumination 112
15A TAIL
Integration Control and Panel 138
Light Auto Turn Off (w/ Daytime Running Light) 124
Light Auto Turn Off (w/o Daytime Running Light) 128
Taillight 110
∗ These are the page numbers of the first page on which the related system is shown.
253
2003 TOYOTA TUNDRA (EWD491U)
J POWER SOURCE (Current Flow Chart)
Fuse System Page
Trailer Towing 132
15A TAIL
TVIP and Wireless Door Lock Control 196
Wiper and Washer (w/ Int Time SW Mechanism) 220
20A WIP
Wiper and Washer (w/o Int Time SW Mechanism) 224
4WD (2UZ–FE) 174
20A 4WD
4WD (5VZ–FE) 180
Door Lock Control (w/ Daytime Running Light) 184
Door Lock Control (w/o Daytime Running Light) 190
Light Auto Turn Off (w/ Daytime Running Light) 124
30A POWER Light Auto Turn Off (w/o Daytime Running Light) 128
Power Seat 230
Power Window 204
TVIP and Wireless Door Lock Control 196
∗ These are the page numbers of the first page on which the related system is shown.
254
2003 TOYOTA TUNDRA (EWD491U)
J
Fuse System Page
Cruise Control (2UZ–FE) 160
Cruise Control (5VZ–FE) 164
Electronically Controlled Transmission and A/T Indicator (2UZ–FE) 144
15A EFI NO.1
Electronically Controlled Transmission and A/T Indicator (5VZ–FE) 150
Engine Control (2UZ–FE) 76
Engine Control (5VZ–FE) 88
15A ETCS (5VZ–FE) Cruise Control (5VZ–FE) 164
15A MIR HTR Mirror Heater 226
15A PWR OUTLET1 Cigarette Lighter and Power Outlet 214
15A PWR OUTLET2 Cigarette Lighter and Power Outlet 214
Fog Light (w/ Daytime Running Light) 104
20A FOG
Fog Light (w/o Daytime Running Light) 106
Trailer Towing 132
20A HAZ
Turn Signal and Hazard Warning Light 120
20A RADIO Radio and Player 232
Engine Control (2UZ–FE) 76
Engine Control (5VZ–FE) 88
Ignition (2UZ–FE) 68
30A AM2
Ignition (5VZ–FE) 72
Starting (2UZ–FE) 64
Starting (5VZ–FE) 60
30A ST3 Starting (2UZ–FE) 64
30A SUB BATT Trailer Towing 132
30A TOW BRK Trailer Towing 132
30A TOW TAIL Trailer Towing 132
30A TOWING Trailer Towing 132
40A ABS2 ABS 156
40A ABS3 ABS 156
Cruise Control (5VZ–FE) 164
40A AM1
Starting (5VZ–FE) 60
50A HTR Air Conditioning 240
Illumination 112
50A J/B
Taillight 110
Charging 74
Cigarette Lighter and Power Outlet 214
ALT Cruise Control (5VZ–FE) 164
100A (Except Towing
Package) Illumination 112
Starting (5VZ–FE) 60
Taillight 110
Charging 74
Cigarette Lighter and Power Outlet 214
140A ALT (Towing Package)
Illumination 112
Taillight 110
∗ These are the page numbers of the first page on which the related system is shown.
255
2003 TOYOTA TUNDRA (EWD491U)
K CONNECTOR LIST
*1 : Separate Seat, Captain Seat (w/o Power Seat)
A1 A2 A3 A4 A4
Gray Gray Gray (2UZ–FE) (5VZ–FE) Gray
1 1 2
1 2 1 2 1 2
3
A5 A6 A7 A8
Black Gray Gray Black
1 2 1 2 1 2 3 4
3 4 5 6 7 8 9
1 2
10 11 12 13 14 15 16
17 18
19 20 21 22 23 24 25
1 2 12
1 2 3 4 5 6 1 2 1 2
3 4
1 2
1 2 3 4 5 1 2 1 2 3 4 1 2
3 4
A20 A22 B1 B2 B3
Black Gray Gray Gray
3 3
1 2 3 4 5 6 5 1 2 5
1 2
1 2 1 2
B4 B5 B6 B7 B7 B7
Black (Bench Seat) (*1) (w/ Power Seat)
1 1 2
3 4 1 2 3
2 2 1 1 2 1 2
4 5 6 7 8 3 4
256
2003 TOYOTA TUNDRA (EWD491U)
K
C1 C2 C2 C4 C5
Gray (2UZ–FE) Gray (5VZ–FE) Black Yellow Yellow
1 2 A A B
1 2 1 2 1 2 3 4 5 6
1 2 3 4 5 6
7 8 9 1011121314151617
7 8 9 101112
1819 2021 22 23 2425 26 27 28
C6 C7 C8 C9 C10
Yellow Gray Black
1
1 2 1 2
A
2 3 456 78 1 2
1 2 3 4 5 6
7 8 9 101112
C11 C12
Blue
1 2 3 4 5 6 7 8 9 10111213 1 2 3 4 5 6 7 8 9 10111213141516
1 2 3 4 5 6 7 8 9 10111213 1 2 3 4 5 6 7 8 9 10
1 2 3 4 5 6 7 8
9 10 1112131415 16 17
1 2
1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 1 2
1 2
7 8 9 10 11 12 10 11 12 131415 16 17 18
D3 D4 D4 D5
(5VZ–FE) Blue (2UZ–FE) Gray (5VZ–FE) Blue Gray
1 2 1 2 1 2 1 2
257
2003 TOYOTA TUNDRA (EWD491U)
K CONNECTOR LIST
D6 D8 D9 D10 D11
Orange Black
1 2 3 1 2 1 2 1 2
16 15 14 13 12 11 10 9
8 7 6 5 4 3 2 1
1 2 1 2 1 1 1 2 1 2 1 2
1 2 1 2 1 2
1 2 1 2 3 4
3 3 3 4 5 6
1 2 1 2 1 2 1 2
1 2 3 4
1 2 3 4
5 6 7 8
E1 E2 E2 E3 E3
(5VZ–FE) Black (2UZ–FE) Black (5VZ–FE) Dark Gray (2UZ–FE) (5VZ–FE)
1 2 1 2
1 2 3 4
1 2 3 4 5 6 7
5 6 7 8 1 2 3 4 5 6 7
8 9 10 11 12 13 14 15 16 17
8 9 10 11 12 13 14 15
18 19 20 21 22 23 24 25
16 17 18 19 20 21 22
26 27 28 29 30 31
E4 E4 E5
(2UZ–FE) (5VZ–FE) (2UZ–FE)
1 2 3 4 5 6 1 2 3 4 5 6 7
1 2 3 4 5 6 7 8 9
7 8 9 10 11 12 13 14 15 16 8 9 10 11 12 13 14 15 16 17
10 11 12 13 14 15 16 17 18 19
17 18 19 20 21 22 23 24 25 26 27 18 19 20 21 22 23 24 25 26 27
20 21 22 23 24 25 26 27 28
28 29 30 31 32 33 34 35 28 29 30 31 32
258
2003 TOYOTA TUNDRA (EWD491U)
K
E5 E6 E6
(5VZ–FE) (2UZ–FE) (5VZ–FE)
1 2 3 4 5 6 1 2 3 4 5 6 7
1 2 3 4 5 6 7
7 8 9 10 11 12 8 9 10 11 12 13 14 15 16 17 18 19
8 9 10 11 12 13 14 15 16
20 21 22 23 24 25 26 27
13 14 15 16 17 17 18 19 20 21 22 23 24
28 29 30 31 32 33 34 35
E7 E7 F1 F2
(2UZ–FE) (5VZ–FE) Brown Brown
1 2 1 2
1 2 3 4 5 6 7
1 2 3 4 5 6 7 8 9
8 9 10 11 12 13 14 15 16 17
10 11 12 13 14 15 16 17 18 19 20 21
18 19 20 21 22 23 24 25 26 27
22 23 24 25 26 27 28 29 30 31
28 29 30 31 32 33 34
F3 F4 F5 F7 F8
Gray Gray Dark Gray
1 2 3 1 2 3 1 2 3 4 5 6 7 8 9 10 11 12 13
1 2 1
14 15 1617181920212223 24 25 26
2
F9 F10 G1 G1 G2 G3
Dark Gray (2UZ–FE) (5VZ–FE) Black
1 1
1 2 3 1 2
1 1 2
4 5 3 4
2
H1 H2 H3 H4 H5 H6
Brown Brown Dark Gray Dark Gray Dark Gray Dark Gray
1 1
2 3 2 3 1 2 1 2 1 2 1 2
3 4 3 4 3 4 3 4
H7 H8 H9 H10 I2
Black Black Dark Gray Black
1 1
1 2
1 2 3
3 4
1 2 3 4 5 6 7 8 9 10
259
2003 TOYOTA TUNDRA (EWD491U)
K CONNECTOR LIST
I3 I4 I5 I6
Black Black Black Black
1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4
I7 I8 I9 I10 I11
Black Black Black Black Black
1 2
1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4
1 2 1 2
12 12 12 12
12 12 12 12 12 12 12
12 12 12
1 2
1 2 3 4
5 6 7 8
1 2 3 4 5 6
7 8 9 1011121314 A B B C C
1 2 3 4 5 6 7 8 9 1
A A B DD D C C
101112131415161718192021 2
J2 J3 J4
Blue
A A
A B B C C
A A B DD D C C A A A A A A A B B B C C C C C
D D D D E E E E E E E
J5 J7 J8
A A A B B B C C C C C A A A B B B C C C C C A A A B B B C C C C C
D D D D E E E E E E E D D D E E E E F F F F D D D D E E E E E E E
260
2003 TOYOTA TUNDRA (EWD491U)
K
J9 J10 J11
Blue
A B B C C
A A A B B B C C C C C A A A B B B C C C C C A A B DD D C C
D D D D E E E E E E E D D D D E E E E E E E
A A
A A A B B B C C C C C A A A A A A B B C C A A B B C C
D D D D E E E E E E E D E F G H I D E F G H I
A A A A A A A A A A A A A A A A
A A A A A
A A A A A A A A A A B B C C
D D E E F F
1 1
A A B B C C A A A A A A A A A A A A
D D E E F F B B B C C C B B B C C C
K2 K2 L1 L2 L3 M1
(2UZ–FE) Dark Gray (5VZ–FE) Black Gray Gray Black
1234
1 1 1 2 1 2 1 2 3 4 5
M4 N1 O1 O2 O4
Black Gray Black Gray
1 2 321
3 4 5 6 1 2 1 2 1
O5 O6 P1 P2 P3
Gray Gray Black Yellow
1
1 2 1
1 2 3 4
1 2 3 4 5
3 4 5
6 7 8 9
261
2003 TOYOTA TUNDRA (EWD491U)
K CONNECTOR LIST
*2 : w/ Mirror Heater
*3 : w/o Mirror Heater
P4 P5 P5 P6 P7 P8
Gray (A/T) Brown (M/T)
1 1
1
1 2 1 2 2 2 1 2 3
1 2 1 2
1 2 3 4
1 2 3 4 5 5 6 7 8 9 10 1 2 1 2
1 2 3 4
1 2 5 6 7 8 9 10 1 2 1 2 1 2 1
2
P21 P22 R1 R2 R3 R4
Gray
1 2 1 2 1 2 3 4 1
3 4 5 6 3 4 5 6 5 6 7 8 9 10 1 2 3
1 2
2 3 4 5 6
R5 R6 R7 R8 R8 R9
Gray (*2) (*3) (*2)
1 2 3
1 1 2 1 3 2 1 2 1
4 5 6
2 2 4 3 4 3
6 5 6 5
R9 R10 R11 S1
(*3) (2UZ–FE)
1
3 2 1
1 2 3 4 5 6 7 8 9 10
1 2 3 4 5 6 7 8 9 10
11 12 13 14 15 16 17 18 19 20
262
2003 TOYOTA TUNDRA (EWD491U)
K
*4 : w/ Cruise Control
*5 : w/o Cruise Control
*6 : Except Towing Package
S1 S1 S2 S3 S4
(2UZ–FE) (5VZ–FE) Black Black (*4) Blue
1 1
1 1 2 1 2
3 4
S4 S5 S8 S9 S10
(*5) Brown Black
1 2 1 2 3 3 2 1 1 2 3 1 2 3 4
3 4
T1 T2 T2 T3
Gray (2UZ–FE) Black (5VZ–FE) Black Black
1234
1 2 1 2 3 4 5 6 1 2 3 4 5 6
3 4
T4 T5 T6
(*6) Black
12 3
1 2 3 4 456 7 8 1 2 3 4
5 6 7 8 9 10
T6 T7 T8 T9
(Towing Package) Black
1 2 3
1 2 1 2
4 5 6 7 8 9
1 2
3 4 5
6 7
12 3
1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 10 11 456 78
1 2
1 2
7 8 9 10 11 12 12 13 1415161718192021 22
263
2003 TOYOTA TUNDRA (EWD491U)
K CONNECTOR LIST
V1 V2 V3 V4 V6
Black Black Black Black Blue
1 2 3 1 2 3 2 1
1 2 1 2
V7 V9 W2 W3 W3 W4
Blue Blue Dark Gray (2UZ–FE) Gray (5VZ–FE) Gray Black
2 1
1 1
4 3
2 1 1 2 1 2 3
4 5
264
2003 TOYOTA TUNDRA (EWD491U)
MEMO
265
2003 TOYOTA TUNDRA (EWD491U)
L PART NUMBER OF CONNECTORS
Code Part Name Part Number Code Part Name Part Number
A1 A/C Dual Pressure SW 90980–11149 C16 Combination SW 90980–12183
A2 A/C Magnetic Clutch 90980–11271 C17 Combination SW 90980–11594
A3 A/C Magnetic Clutch and Lock Sensor 90980–11016 C18 Cruise Control Clutch SW 90980–10906
A/T Oil Temp. Sensor (2UZ–FE) 90980–11025 D2 Daytime Running Light Resistor 90980–10928
A4
A/T Oil Temp. Sensor (5VZ–FE) 90980–10498 Detection SW (Transfer 4WD Position)
90980–11250
(2UZ–FE)
A5 ABS Actuator with ECU 90980–11861 D3
Detection SW (Transfer 4WD Position)
A6 ABS Speed Sensor Front LH 90980–11156
90980–11075 (5VZ–FE)
A7 ABS Speed Sensor Front RH
Detection SW (Transfer L4 Position)
90980–11025
A8 Accel Position Sensor 90980–11150 (2UZ–FE)
D4
A9 ADD Actuator 90980–11858 Detection SW (Transfer L4 Position)
90980–11156
(5VZ–FE)
A10 Air Fuel Ratio Sensor (Bank 1 Sensor 1) 90980–11178
D5 Detection SW (Transfer Neutral Position) 90980–10923
A11 Airbag Sensor Front LH
90980–11898 D6 Data Link Connector 3 90980–11665
A12 Airbag Sensor Front RH
D8 Diode (A/T) 90980–11071
A13 A/C Thermistor 90980–11918
D9 Diode (Door Courtesy)
A15 Air Inlet Control Servo Motor 90980–11909 90980–11608
D10 Diode (Idle–Up)
Airbag Squib (Front Passenger Airbag
A16 90980–11884
Assembly) D11 Diode (Power Window System) 90980–10962
A17 Airbag Squib (Steering Wheel Pad) 90980–12160 D14 Door Courtesy Light LH
90980–11148
A18 Ashtray Illumination – D15 Door Courtesy Light RH
A19 ABS Speed Sensor Rear 90980–10942 D16 Door Courtesy SW Front LH
90980–10871
A20 Accelerator Pedal Position Sensor 90980–11858 D17 Door Courtesy SW Front RH
A22 ACC Cut Relay 82660–53010 D18 Door Courtesy SW Rear LH Lower
B1 Back–Up Light SW 90980–11250 D19 Door Courtesy SW Rear LH Upper
90980–11003
B2 Brake Fluid Level Warning SW 90980–11207 D20 Door Courtesy SW Rear RH Lower
B3 Back–UP Light Relay 82660–20340 D21 Door Courtesy SW Rear RH Upper
B4 Blower Motor 90980–10214 D22 Door Key Lock and Unlock SW LH
90980–11245
B5 Blower Resistor 90980–10171 D23 Door Key Lock and Unlock SW RH
B6 Blower SW and Defroster Mode SW 90980–10877 D24 Door Lock Control SW RH 90980–10797
Buckle SW LH (Bench Seat) 90980–10824 Door Lock Motor and Door Unlock
D25
Detection SW LH
Buckle SW LH (Separate Seat, Captain 90980–11150
B7 90980–10795
Seat (w/o Power Seat)) Door Lock Motor and Door Unlock
D26
Detection SW RH
Buckle SW LH (w/ Power Seat) 90980–10825
D27 Diode (Step Light)
C1 Camshaft Position Sensor 90980–10947 90980–10962
D28 Diode (Door Lock)
Crankshaft Position Sensor (2UZ–FE) 90980–11162
C2 D29 Diode (TVIP) 90980–11608
Crankshaft Position Sensor (5VZ–FE) 90980–10947
D30 Diode (Unlock Warning) 90980–10962
C4 Center Airbag Sensor Assembly 90980–11873
Electronically Controlled Transmission
C5 Center Airbag Sensor Assembly 90980–11872 E1 90980–10891
Solenoid
C6 Center Airbag Sensor Assembly 90980–11871
Engine Coolant Temp. Sensor (2UZ–FE) 90980–10736
C7 Cigarette Lighter 90980–10760 E2
Engine Coolant Temp. Sensor (5VZ–FE) 90980–10737
C8 Cigarette Lighter Illumination 90980–11148
Engine Control Module (2UZ–FE) 90980–12142
C9 Clutch Start Cancel SW 90980–11533 E3
Engine Control Module (5VZ–FE) 90980–11638
C10 Clutch Start SW 90980–10825 Engine Control Module (2UZ–FE) 90980–12146
C11 Combination Meter 90980–11114 E4
Engine Control Module (5VZ–FE) 90980–11637
C12 Combination Meter 90980–11113 Engine Control Module (2UZ–FE) 90980–12143
C13 Combination Meter 90980–11115 E5
Engine Control Module (5VZ–FE) 90980–11586
C14 Combination Meter 90980–11116
C15 Combination SW 90980–11672
Note: Not all of the above part numbers of the connector are established for the supply.
266
2003 TOYOTA TUNDRA (EWD491U)
L
Code Part Name Part Number Code Part Name Part Number
Engine Control Module (2UZ–FE) 90980–12145 I20 Injector No.7
E6 90980–11153
Engine Control Module (5VZ–FE) 90980–11476 I21 Injector No.8
Engine Control Module (2UZ–FE) 90980–12144 I22 Ignition Key Cylinder Light 90980–10906
E7
Engine Control Module (5VZ–FE) 90980–11421 I23 Ignition SW 90980–11615
F1 Front Fog Light LH I24 Integration Control and Panel 90980–11125
90980–11096
F2 Front Fog Light RH I25 Integration Control and Panel 90980–10807
Front Turn Signal Light and Parking Light I26 Interior Light 90980–10935
F3
LH
90980–11020 J1 Junction Connector
Front Turn Signal Light and Parking Light 90980–11714
F4 J2 Junction Connector
RH
J3 Junction Connector 90980–10976
F5 Fuel Pump Resistor 90980–10901
J4 Junction Connector
F7 4WD Control ECU 90980–11423
J5 Junction Connector
F8 Front Door Speaker LH
90980–10935 J7 Junction Connector
F9 Front Door Speaker RH 90980–11915
J8 Junction Connector
F10 Fuel Pump and Sender 90980–11077
J9 Junction Connector
Generator (2UZ–FE) 90980–09365
G1 J10 Junction Connector
Generator (5VZ–FE) 90980–09212
J11 Junction Connector 90980–11714
G2 Generator 90980–11964
J12 Junction Connector 90980–11915
G3 Glove Box Light 90980–11148
J13 Junction Connector 90980–10976
H1 Headlight LH
90980–11314 J14 Junction Connector
H2 Headlight RH 90980–11661
J15 Junction Connector
H3 Heated Oxygen Sensor (Bank 1 Sensor 1) 90980–10869
J16 Junction Connector
H4 Heated Oxygen Sensor (Bank 1 Sensor 2) 90980–11028 90980–11398
J17 Junction Connector
H5 Heated Oxygen Sensor (Bank 2 Sensor 1) 90980–10869
J18 Junction Connector 90980–11542
H6 Heated Oxygen Sensor (Bank 2 Sensor 2) 90980–11028
J19 Junction Connector
H7 Horn LH 90980–11398
90980–10619 J20 Junction Connector
H8 Horn RH
J21 Junction Connector
H9 Heated Oxygen Sensor (Bank 1 Sensor 2) 90980–11028
J22 Junction Connector
H10 High Mounted Stop Light and Cargo Light 90980–11296 90980–11661
J23 Junction Connector
I2 Igniter 90980–11653
J24 Junction Connector
I3 Igniter and Ignition Coil No.1
K1 Knock Sensor 1
I4 Igniter and Ignition Coil No.2 90980–11166
K2 Knock Sensor 2
I5 Igniter and Ignition Coil No.3
L1 License Plate Light LH
I6 Igniter and Ignition Coil No.4 90980–11162
90980–11885 L2 License Plate Light RH
I7 Igniter and Ignition Coil No.5
L3 Lumber Support Control SW (Driver’s Seat) 90980–10601
I8 Igniter and Ignition Coil No.6
M1 Mass Air Flow Meter 90980–11317
I9 Igniter and Ignition Coil No.7
M4 Mirror Heater SW 90980–10797
I10 Igniter and Ignition Coil No.8
N1 Noise Filter 90980–10843
I11 Ignition Coil No.1
O1 O/D Direct Clutch Speed Sensor 90980–11156
I12 Ignition Coil No.2 90980–11246
O2 Oil Pressure SW 90980–11363
I13 Ignition Coil No.3
O4 O/D Main SW 90980–11470
I14 Injector No.1
O5 Option Connector 90980–11603
I15 Injector No.2
O6 Oil Pressure Sender 90980–11363
I16 Injector No.3
90980–11153 P1 Park/Neutral Position SW 90980–11784
I17 Injector No.4
P2 Power Steering Oil Pressure SW 90980–11428
I18 Injector No.5
P3 Passenger Airbag Manual On–Off SW 90980–12017
I19 Injector No.6
267
2003 TOYOTA TUNDRA (EWD491U)
L PART NUMBER OF CONNECTORS
Code Part Name Part Number Code Part Name Part Number
P4 Passenger Airbag Manual On–Off SW 90980–10906 Security Indicator and Glass Breakage
S10 90980–11013
Sensor Microphone
Parking Brake SW (A/T) 90980–10871
P5 T1 Throttle Control Motor 90980–10942
Parking Brake SW (M/T) 90980–10825
Throttle Position Sensor (2UZ–FE) 90980–11858
P6 Power Outlet T2
90980–10760 Throttle Position Sensor (5VZ–FE) 90980–10711
P7 Power Outlet
T3 Transfer Shift Actuator 90980–11858
P8 Personal Light 90980–10908
T4 Transmission Control Relay 90980–10801
P9 Power Window Control SW RH 90980–10789
T5 Turn Signal Flasher 90980–10799
P10 Power Window Master SW 90980–10997
Trailer Socket (Except Towing Package) 82824–34040
P11 Power Window Motor Front LH T6
90980–10860 Trailer Socket (Towing Package) 82824–34030
P12 Power Window Motor Front RH
T7 Tweeter LH
P13 Pretensioner LH 90980–10906
90980–11862 T8 Tweeter RH
P14 Pretensioner RH
T9 Trailer Converter 90980–11535
Power Seat Motor (Driver’s Seat Front
P15 90980–10825
Vertical Control) T10 TVIP Buzzer 90980–11051
P16 Power Seat Control SW (Driver’s Seat) 90980–10997 T11 TVIP ECU 90980–11424
Power Seat Motor (Driver’s Seat Rear T12 TVIP ECU 90980–11392
P17
Vertical Control)
T13 TVIP ECU 90980–10799
Power Seat Motor (Driver’s Seat Reclining
P18 90980–10825 U1 Unlock Warning SW 90980–10860
Control)
V1 Vapor Pressure Sensor
Power Seat Motor (Driver’s Seat Slide 90980–11143
P19
Control) V2 Vehicle Speed Sensor (Combination Meter)
Power Seat Motor (Driver’s Seat Lumber Vehicle Speed Sensor (Electronically
P20 90980–10935 V3
Support Control) Controlled Transmission) 90980–11156
90980 11156
P21 Power Window Control SW (Back Window) 90980–10996 V4 VSV (EVAP)
P22 Power Window Motor (Back Window) 90980–10860 V6 Vanity Light LH
90980–11368
R1 Radio and Player 90980–10996 V7 Vanity Light RH
R2 Radio and Player 90980–10997 V9 VSV (Canister Closed Valve) 90980–11859
R3 Rheostat 90980–10216 W2 Washer Motor and Washer Level Sensor 90980–11177
R4 Rear Combination Light LH Water Temp. Sender (2UZ–FE) 90980–11428
90980–10988 W3
R5 Rear Combination Light RH Water Temp. Sender (5VZ–FE) 90980–10359
R6 Rear Door Speaker LH W4 Wiper Motor 90980–11599
90980–10935
R7 Rear Door Speaker RH
Remote Control Mirror LH (w/ Mirror Heater) 90980–11452
R8 Remote Control Mirror LH (w/o Mirror
90980–10907
Heater)
Remote Control Mirror LH (w/ Mirror Heater) 90980–11452
R9 Remote Control Mirror RH (w/o Mirror
90980–10907
Heater)
R10 Remote Control Mirror SW 90980–11657
R11 Radio and Player 90980–12259
Starter (2UZ–FE) 90980–09585
S1
Starter (5VZ–FE) 90980–09507
S2 Starter 90980–11400
S3 Step Light 81945–33010
S4 Stop Light SW 90980–11118
Seat Belt Warning Occupant Detection
S5 90980–11296
Sensor
S8 Short Pin 90980–10907
S9 Short Connector (TVIP) 90980–10908
Note: Not all of the above part numbers of the connector are established for the supply.
268
2003 TOYOTA TUNDRA (EWD491U)
L
Code Part Name Part Number Code Part Name Part Number
269
2003 TOYOTA TUNDRA (EWD491U)
1 TOYOTA TUNDRA ELECTRICAL WIRING DIAGRAM
1 2 B–R 3 4
B
B–Y
ACC
B–R
W 2 AM1 IG1 4 B–Y * 1 : Towing Package
* 2 : Except Towing Package
* 3 : w/ Daytime Running Light
* 4 : w/o Daytime Running Light 2 1I 4 1I
* 5 : w/ Wireless Door Lock Control
* 6 : w/o Wireless Door Lock Control
W–R 7 AM2 IG2 6 B–R
GAUGE IGN
W
W
B
I23
2 2 2 2 IGNITION SW
B
7 1F 5 1E J1 10 1F
2 2
2003 TOYOTA TUNDRA (EWD491U)
JUNCTION
CONNECTOR
7. 5A ALT–S
(M/T)
G–B
B–O
B–Y
(M/T)
[COMB. METER]
LIGHT
CHARGE WARNING
C12
3
Relay<7–3>
To Integration
1 7
1 1
W
+S IG
2 2
(M/T)
(A/T)
W–B
W–B
W–B
2 2
3 2
100A ALT(*2)
140A ALT(*1)
4
30A AM2
ST RELAY
19 IE2
Y–G
Y–G
(*3)
(*3)
(A/T)
W–B
1 1 5 1
CONNECTOR
JUNCTION
J11
J2 CLUTCH START SW A
C10
Y–G(*4)
JUNCTION 2 2 2 6 A
POSITION SW
PARK/NEUTRAL
P1
CONNECTOR
2 B–W C C B–W P 4 EB1 1 EB1
G–R
A
N –S E
C
B–W
3 EB1 24 IA4 C9
1 9 3 5
Y–G
(*3)
CLUTCH START
B–L(*1)
B (*2)
3 1I CANCEL SW
B–W
(A/T)
P
(M/T)
(M/T)
W–B
W–B
B–Y
1 B
B
1
B–L 12 IE2
(M/T)
5A STA
(*6)
A 7 IA5
P
W–B W–B
G–R
(*5)
(A/T)
W–B
Y–G
BATTERY
S1 A , S2 B
6 1F
STARTER
P(* 6) A B 2 EB1
A J23 A , J24 B 3 B
B
<23–3>
To TVIP ECU
P A A P JUNCTION S B A
(*5) (M/T) CONNECTOR 1
J8 A A IG B
2 Y–G
JUNCTION L B
CONNECTOR 4
<6–9>
Control Module
To Engine
(A/T)
P
W–B
G1 A , G2 B
ECU<23–3>
From TVIP
GENERATOR
From Engine Control IE Left kick
Module<6–9> panel
M
2 TOYOTA TUNDRA
P ow e r S o urc e S ta rtin g (2 U Z – F E )
1 2 3 4
7 AM2 IG2
ST2 8 B–W
* 1 : Towing Package
W–R
* 2 : Except Towing Package
* 3 : w/ Wireless Door Lock Control
I23
B–W
* 4 : w/o Wireless Door Lock Control
IGNITION SW
3 1I
5A
STA
6 1F
B To Engine Control
Module(STSW)<5–14>
G–Y
G–Y
W–B
W–R
A J20
JUNCTION
CONNECTOR
2 2 A A
2 2
W–B
2
W–B
W–B
3 2 C
J2
W–B
JUNCTION
CONNECTOR
C
30A ST3
30A AM2
ST RELAY
1 5 1
2 2 6 P1
2 B–W P
To Engine Control
To Engine Control
N
Module(STAR)<5–10>
M OVERALL ELECTRICAL WIRING DIAGRAM
G–R
POSITION SW
3 EB1
W–B
9
PARK/NEUTRAL
24 IA4
P
B–W
B (*2)
B–L(*1)
1 B
1
B P From Engine Control
A
Module(STA)<5–14>
A
J18
JUNCTION
P
P
(*3)
(*4)
G–R
S1 A , S2 B CONNECTOR
A
BATTERY STARTER
12 IE1
P To TVIP ECU
(*3) <23–3>
W–B
<23–3>
P
(*4)
B–R BR
1
L–W
I9
B–R
<5–13>
4
IGNITER AND
IGNITION COIL NO. 7
R–W L–B L–B
* 2 : Except Towing Package
B–R BR
* 1 : Towing Package
4
B–R
L–B
BR
I8
IGNITER AND
IGNITION COIL NO. 6
P–L L–B
3
B–R BR
1
4
B–R
I7
L–W
L–B
BR
IGNITER AND
IGNITION COIL NO. 5
G–W L–W
3
2
From Engine Control Module
B–R BR
1
4
3
Ign ition (2 U Z – F E )
B–R
<5–13><5–14>
I6
BR
IGNITER AND
IGNITION COIL NO. 4
B–L L–B
3
B–R BR
1
4
B–R
I5
L–B
L–W
IGNITER AND BR
IGNITION COIL NO. 3
G–B L–W
3
B–R BR
1
4
B–R
I4
BR
IGNITER AND
IGNITION COIL NO. 2
2
LG–B L–W
3
B–R BR
1
4
B–R
BR
Rear bank of
IGNITER AND
IGNITION COIL NO. 1
G–R L–B
3
2
B–R B–R B–R BR BR
21 IE1
EC
7 1J
4 1I
BR
N1
NOISE FILTER
B–R BR
B–R
2
IG2 6
1
3 TOYOTA TUNDRA
ST2
IGNITION SW
P ow er S ou rc e
I23
BATTERY
7 AM2
30A AM2
B–L(*1)
W–R B (*2)
2
2
1
2003 TOYOTA TUNDRA (EWD491U)
M OVERALL ELECTRICAL WIRING DIAGRAM
4
Ign ition (5 V Z – F E )
IGNITER
I2
To Combination Meter B B–Y
<29–3>
8
B–R LG
<6–9><6–10>
I13
IGNITION COIL NO. 3
B–R W–G R–L
1
6
2
B–R
I12
IGNITION COIL NO. 2
B–R L B–L
Intake manifold left
1
7
B–R
I11
IGNITION COIL NO. 1
B–R B–R B–R R W–B W–B
1 IE1
ED
7 1J
4 1I
10
3
B–R
N1
IG2 6
NOISE FILTER
ST2
B–R BR
IGNITION SW
2
I23
7 AM2
P o w e r S o urc e
BATTERY
4 TOYOTA TUNDRA
AM2
30A
W–R B
2
2
2
P o w e r S o urc e E ng in e C o n trol (2 U Z – F E )
1 2 3 4 G–Y
A
W–G
B
B–R
C
ACC 3 L–R B–Y
D
2 AM1 IG1 4 B–Y B–Y
E
B–R
W–R
F
B–W
G
9 IA4 17 IA5
W–R
7 AM2 IG2 6 B–R B–L
H
2
ST2
W–L
2 I
I23
(*4)
(*3)
IGNITION SW
L–R
W–R
W–R
5A W–G From ABS
ECU–B Actuator
with ECU<16–3>
Y
1 From Center
W–G
D A Airbag Sensor
B–W
Assembly<17–4>
W–L
2 4 1B B–W
B–Y
W–L
W–L
D D
JUNCTION
D W–G
CONNECTOR
2 2 F B 2 2 2 2
B
W
From Center Airbag
W–R
W–G
7. 5A
J21 A , J22 B
J8
B–R
OBD 5 2 3 2 2 3 D
Sensor Assembly<17–4>
JUNCTION
CONNECTOR
Y
2 2 2 2 4
W–G
L–W
B–L
B–W
2 1K
(*3)
W–R
EFI RELAY
2 F/PMP RELAY
C/OPN RELAY
B–Y
3 1 5 1 1 5 16 11 13 15
2
BAT A/B TC WFSE
2 2 2 2 2 2
L–R
D6
L–O
W–G
40A AM1
DATA LINK
CONNECTOR 3
Y
3 2
5 IA4
B–R
B–W
1
2 CG TS SG SIL
A22
From Center
2 RELAY
Airbag Sensor
2
L–B
L–O
L–O
W–L
with ECU<16–3>
W–B
L–W
Assembly<17–4>
2 2 4 1 J
W–B
26 IA4 1 3 BB1
L–O
SHORT PIN
10A ETCS
50A J/B
1
100A ALT(*2)
140A ALT(*1)
F5
G–Y
1 1 FUEL PUMP
W
W
W
BR
L–O
1 RESISTOR 4
30A AM2
F10
8 IE1
with ECU<16–4>
From ABS Actuator
5
FUEL PUMP
A J5
J18
D
2 JUNCTION
W–B
W–G
W
G–Y CONNECTOR K
JUNCTION
A 12 BB1
W
CONNECTOR
L
B (*2)
B–L(*1)
Y
* 1 : Towing Package M
* 2 : Except Towing Package
* 3 : w/ Door Lock Control
W–B
W–B
W–B
CONNECTOR
Front left fender EA Left kick panel IF EC Rear bank of
left cylinder head
M
(Cont. next page)
D
A
E
B–W
B–O
BR
R
I21 H3
* 5 : Shielded
OX1A
B B–W
OX2
E1
23 D
I19
3
INJECTOR NO. 6
B–R Y
#6
3 D
G–Y R
HT1A
HTL
1
+B
4 D
2
B–R
I17
INJECTOR NO. 4
(*5)
8
B–R R–B H5
#4
R
4 E
(Bank 2 Sensor 1)
B–R
I15
E3 A , E4 B , E5 C , E6 D , E7 E
OX
E1
22 D
4
3 IE1
#2
2 E
1
2
B–R
I20 Y–G R
HT2A
HTR
+B
33 D
INJECTOR NO. 7
1
B–R L–R
#7
6 C
1
Y
FC
B–R
10 A
I18
INJECTOR NO. 5
B–R L W
SIL
#5
5 E
18 A
1
2
B–R
I16 W–G
TC
2 A 20 A
INJECTOR NO. 3
B–R G
#3
3 E
W–L
+B2
1
2
B–R
I14
INJECTOR NO. 1 W–L
+B
1 A
B–R R
#1
1 E
1
L–W
CCV
16 IE1
27 E
7
FPR
8 EA1
1 IA5
23 IE1
6 B
33 E
PI
3 A
13 B
E n gine C on tro l (2 U Z – F E )
B–L
V–G
W
11 A
MREL
B–Y B–Y
15 IA4
8 A
IGSW WFSE
L–W
19 A
ACCR
B–O
15 E
9 A
R
B–O
B–R
7 1J
IGN
5A
J5
6
JUNCTION
CONNECTOR
6 1K
B–W
MALFUNCTION
INDICATOR LAMP
V–G
GAUGE
8 C
10A
CRUISE
B–Y B–Y B–R
5 1F
9 C
2 1I
9 A
C11 A , C13 C
COMBINATION METER
L–W
J14 A , J15 B V9 J14 A , J15 B
J8 VSV
5 TOYOTA TUNDRA (Cont’ d)
R
R R R L–W
18 IA4
H A
H B
F B
G A
A
2
R R
1 IE1
5
NO. 2
A
10A
R
EFI
W–L W–L W–L
14 IA4
2
B
2
1
J1
B
JUNCTION
W–L CONNECTOR
W–G
W–G
B–W
L–W
G–Y
W–L
B–R
B–R
B–Y
B–Y
B–L
Y
M
G
C
H
A
K
F
L
J
I
2003 TOYOTA TUNDRA (EWD491U)
5 TOYOTA TUNDRA (Cont. next page)
E n gine C o ntro l (2 U Z – F E )
* 5 : Shielded
B–O 9 10 11 12 B–O
A A
R B–W B–W
B B
G–B
C
B–W
R
B–W
B–W
3
M1 E2
T2
R
3 MASS AIR FLOW METER
1
E2
SENSOR
TEMP. SENSOR
2 4 5 1 2
THROTTLE POSITION
2 M– M+ VTA1 VTA2 VC
ENGINE COOLANT
1 2 6 4 5
V4
<9–4>
B–W
B–W
<18–4>
VSV(EVAP)
and Panel<30–3>
G–B
To Integration Control
To Detection SW
R
G–B
W
From Park/Neutral
From Park/Neutral
G
Position SW<2–3>
Position SW<2–3>
(Transfer L4 Position)
P–L
B–Y
B–Y
Y–G
R–W
(*5)
G–B
B–W
L–B
L–Y
G–Y
W–G
L–R
W–B
W–B
BR
34 E 12 A 33 B 2 B 9 D 4 B 16 E 20 E 29 E 30 E 28 E 19 E 17 C 2 C 3 C 21 E 31 E 18 E
PRG ELS ACLD ACMG STAR L4 NSW THA E2G VG E2 THW GE01 M– M+ VTA1 VTA2 VC
E3 A , E4 B , E5 C , E6 D , E7 E
ENGINE CONTROL MODULE
HT2B OX2B HT1B OX1B E1 KNK1 KNK2 G2 G2– NE– NE+ ME01 E03 E02 E01
25 D 21 D 5 D 29 D 1 C 1 D 2 D 27 C 32 C 24 C 25 C 4 C 7 C 6 E 7 E
(*5)
BR BR
C (*5) (*5)
BR
GR
BR
BR
L
Y
R
G
B
(*5)
3 EC2 2 EC2 1 EC2
W
BR
Y–B
R–Y
(*5) BR
1 2 2 1
BR
GR
(*5)
W–B
W–B
W–B
W–B
B
(*5)
C1 C2
CAMSHAFT POSITION CRANKSHAFT POSITION
1 3 1 3 1 1 SENSOR SENSOR
H6
H4
K2
K1
Sensor 2)
Sensor 2)
(*5)
(*5)
+B E1 +B E1
BR
A
SENSOR(Bank 2
SENSOR(Bank 1
J19
2 4 2 4 A
HEATED OXYGEN
HEATED OXYGEN
KNOCK SENSOR 2
KNOCK SENSOR 1
BR
R
R
B–W
B–W
B–W
JUNCTION
A D
BR
CONNECTOR
BR
D
R
E
Rear bank of EC Rear bank of EB
left cylinder head right cylinder head
5 TOYOTA TUNDRA (Cont’ d)
C ru is e C o n trol
E n gine C on tro l (2 U Z – F E )
(2 U Z – F E )
B–O 13 14 15 16
A
B–W B–W B–W B–W B–W
B
G–B G–B
B–W
C
B–L
B–W
See Stop Light
22 IE1 System<13–4>
2
A/C THERMISTOR
A13
B–W
18 IE1
CONNECTOR
JUNCTION
J9
B
<2–3>
From ” STA” Fuse
B–O
A/C LOCK SENSOR
A3
B 1
A20 SSR–
G–B
ACCEL PEDAL POSITION SENSOR
R–L
B 1
<29–3>
To Combination Meter
3 2
B–W
SSR+
CONNECTOR
JUNCTION
B–W
J14 A , J15 B
2
SW
STOP LIGHT
S4
E A D A F A
EPA2 VCP2 VPA2 EPA VCPA VPA
R–L
2 1 3 5 4 6
H B I B G B
B
4 1
2003 TOYOTA TUNDRA (EWD491U)
G–W
B–W
G–B
R–L
2 II1
LG–R
G–R
R–G
V–R
P–G
2 3 1 15 IE1
L
G
G–O
L–W
B–L
L–B
G
B
V1
VAPOR PRESSURE SENSOR
29 A 27 A 23 A 28 A 26 A 22 A 21 A 32 B 12 C 17 B 5 A 23 C 12 B 24 B 5
EPA2 VCP2 VPA2 EPA VCPA VPA PTNK THE STSW SPD TACH LCK1 STI– CCS CCS
CRUISE
E3 A , E4 B , E5 C , E6 D , E7 E
RES/
ENGINE CONTROL MODULE ACC
IGF1 IGF2 IGT2 IGT1 IGT3 IGT4 IGT5 IGT6 IGT7 IGT8 STP STA F/PS A/CS 4WD HP
24 E 23 E 8 E 9 E 25 E 11 E 12 E 26 E 13 E 10 E 19 B 17 E 14 A 31 B 8 D 1 B SET/
COAST
LG–B
G–W
R–W
G–W
L–W
G–R
G–B
L–W
R–B
L–B
B–L
P–L
GR
LG
L
CANCEL
1 II1 17 IA4
ECC
4 C16
<13–4>
From Stop Light SW
Position SW<2–3>
To Park/Neutral
R–B
and Panel<30–5>
To Integration Control
SW<18–6>
To ADD Detection
C CRUISE CONTROL SW
W–L
To Igniter and Ignition Coil
No. 8<3–4>
No. 5, No. 6, No. 7 and
No. 1, No. 2, No. 3, No. 4
Ignition Coil
From Igniter and
J2
No. 1, No. 2, No. 3, No. 4 [COMB. SW]
JUNCTION
No. 5, No. 6, No. 7 and No. 8 1 CONNECTOR
<3–2><3–3><3–4> C
BR
W–B
Assembly<17–3>
Airbag Sensor
From Center
A/C PRESSURE SW
A1
W–B
5 IE1
A
J18
JUNCTION
2 CONNECTOR
A
B–W
D
W–B
BR
Front left EA EC Rear bank of
fender left cylinder head
M
6 TOYOTA TUNDRA (Cont. next page)
* 1 : w/ Cruise Control
P ow er S ou rc e E n gine C o ntro l (5 V Z – F E ) * 2 : w/o Cruise Control
* 3 : Malfunction Indicator Light
1 2 3 4 W–G
A
B–R
B
6 18
B–R B–R W–L R
IA4 IA4 C
10A
EFI NO. 2 W–L
D
ACC W–L B–Y
2 2 E
2 AM1 IG1 4 B–Y B–Y
W–G
F
13
W–L W–G
IE1 G
J1
W–L
1 IA5
B
7 AM2 IG2 6 W–L B
B–Y
B–R
B–R
B–Y
B–Y
W–G
ST2
B 20 IE1
2 1I 9 1F 2 1K
W
JUNCTION CONNECTOR
I23
B–R
W–R
W–G
W–G
IGNITION SW 2 2 2 2
W–G
10A 7. 5A D J8
From Center
2 2 2 2 2
B–R
GAUGE OBD JUNCTION
Airbag Sensor
2 3 3 2 W–G D
CONNECTOR
Assembly<17–4>
2 2 D D
W–L
W–L
W–L
B–W
EFI RELAY
5 1F 4 1B
C/OPN RELAY
W–G
W–G
1 5 5 1
4 1I
40A AM1
B–Y
15A ETCS
W–G
B–Y
COMBINATION
Y
D6
L–O
9 A METER
2 2 2 DATA LINK
From Center Airbag
5A CONNECTOR 3
with ECU<16–3>
W–B
IGN
with ECU<16–3>
CG TS SG WFSE SIL
Sensor Assembly<17–4>
From ABS Actuator
A
(*3)
J18
4 12 5 15 7
CRUISE
50A J/B
30A AM2
Sensor Assembly<17–4>
100A ALT
8 C 9 C
Y
W
W
W
JUNCTION
BR
L–O
W–L
L–W
W–B
1 1 1 A
7 1J 11 1F 6 1K
CONNECTOR
D D
3 BB1 15 IE1 D D W
H
B–R
M OVERALL ELECTRICAL WIRING DIAGRAM
J5
V–G
W–L
W–L
W–B
2 JUNCTION
CONNECTOR
L–O
W–B
3 IE1
B–W
4
B–O(*2)
B–O(*1)
From ABS
F10
ECU<16–4>
Actuator with
FUEL M
PUMP
B–R
B
5 L–W
I
W–L
V–G
J
W–B
W–L
K
12 BB1
Y
L
BATTERY B–O(*2)
M
B–R
W–B
N
B–O(*1)
O
A Y
J3 A W–B P
W–B
JUNCTION
CONNECTOR
W–B
W–G 5 6 7 8 B–Y
A A
B–R
B
R R
C
W–L W–L W–L
D
26 F G
CONNECTOR
JUNCTION
CONNECTOR
JUNCTION
B–Y B–W B–W B–W B–W B–W B–W B–W
J14 A , J15 B
J14 A , J15 B
W–L
E IE1 A B H A F B
B–W
B–Y V1
F J14 A , J15 B VAPOR
W–G 1 EF1 JUNCTION PRESSURE 1
B–W
B–W
W–L
G SENSOR 1
VSV(EVAP)
V4
CONNECTOR E B G A
B–W
T2
W–L
THROTTLE
BR–B
MASS AIR FLOW METER
M1
POSITION
L–W
L–W
TEMP. SENSOR
ENGINE COOLANT
E2
2 1 5 1 1
R
SENSOR
3 2 2
B–Y
SENSOR
ACCEL PEDAL
A8
E2 E2
G–B
R–L
1
CONNECTOR
JUNCTION
15 IA4 VPA VPA2 VC VTA VTA2 VC 16 IE1
J14 A
I B H B
3 4 1 2 3 4 2 3 2 4
G–Y
2
G–B
,
2003 TOYOTA TUNDRA (EWD491U)
J15 B
D A E A
G–W
G–W
R–W
L–W
B–R
G–B
R–Y
Y–G
R–B
B–Y
2 EF1
R
19
G–B G–B G–B
IE1
W–G
W–G
22
G–Y
B–Y
R–L
R–L
G–B
IE1
8 A 7 D 4 A 16 A 10 C 15 C 10 E 12 E 13 E 11 E 18 E 15 E 4 C 25 E 24 E 14 D 19 D
+BM TC MREL BATT VPA VPA2 E2G VG THA E2 THW VTA VTA2 VC PTNK EVP1 CCV
SIL WFSE W +B FC IGSW #10 # 20 # 30 #40 #50 #60 HTAF1 AF1+ AF1– OX2B HT2B KNK1 KNK2
14 A 13 A 2 A 1 A 22 A 15 A 6 D 5 D 4 D 3 D 1 D 8 D 21 E 14 E 26 E 27 D 29 E 23 E 22 E
(Shielded)
BR
R–W
R
(Shielded)
B–O(*2)
B–O(*1)
(Shielded)
L–W
V–G
W–L
R–B
GR
W
W
R
G
Y
B
L
25 IE1 23 IE1 14 IE1
P
W
H
(Shielded)
(Bank 1 Sensor 1)
AIR FUEL RATIO SENSOR
A10
R–W
BR
R
BR
1 1 1 1 1 1 1 3
INJECTOR NO. 1
I14
INJECTOR NO. 2
I15
INJECTOR NO. 3
I16
INJECTOR NO. 4
I17
INJECTOR NO. 5
I18
INJECTOR NO. 6
I19
HT AF+
1 EE1 3 EE1 2 EE1
24 IE1 4 BD1 2 BD1 3 BD1
+B AF–
BR
R–W
BR
R
2 2 2 2 2 2 2 4
L–W
(Shielded)
(Shielded)
I
BR
3 1 4
GR
V–G
B
OX HT E1
W–L
B–R
B–R
B–R
B–R
B–R
J B–R
BR
P
W–L
K B–R B–R B–R +B
KNOCK SENSOR 1
K1
KNOCK SENSOR 2
K2
Y H9 1 1
L 2
HEATED OXYGEN
W–L
BR
BR
B–O(*2) SENSOR
B–R
M BR
(Bank 1 B
B–R 1 BD1 Sensor 2)
N
B–O(*1)
O W–L
Y
P
BR
BR
B B B–O(*1) Y
C
J5 B B–O(*1) BR BR
JUNCTION
CONNECTOR B–O
D
(*1)
M
6 TOYOTA TUNDRA (Cont’ d)
B–Y 9 10 11 12
A
* 1 : w/ Cruise Control
B–Y
E
J8
JUNCTION
CONNECTOR
R
1 2 E
C2
C1
<19–4>
<19–3>
<29–3>
CAMSHAFT
B–Y
(M/T)
<13–4>
<1–1>
CRANKSHAFT
Neutral Position)
2 1
L4 Position)<19–3>
<4–2><4–3>
To Park/Neutral
BR
Position SW<1–2>
Sensor Assembly<17–3>
C18
R
G
CRUISE CLUTCH SW
(Shielded)
2
(Shielded)
P
B
See Electronically
LG
GR
B–L
R–L
B–Y
L–R
R–B
R–Y
(A/T)
G–O
G–W
(4WD)
Controlled
(4WD A/T)
(4WD A/T)
W–R
(M/T)
L
A/T Indicator
G
System<15–4>
20 A 3 B 7 A 21 A 11 D 10 D 9 D 2 D 6 A 11 B 13 B 2 B 12 D 21 D 13 D 25 B
STP NSW STA F/PS IGT1 IGT2 IGT3 IGF SP1 TFN 4WD L4 NE+ NE– G2 D
GE01 M– M+ CL+ CL– ME01 E04 E1 E01 E02 E03 PSW AC1 ACT PI ST1– CCS
17 E 31 E 9 E 2 C 8 C 6 E 8 E 17 D 4 E 5 E 7 E 18 D 9 A 3 A 17 A 9 B 22 B
G
(*1)
L–R
BR
Y
BR
BR
L–Y
L–B
CRUISE
Y–R
W–B
W–B
W–B
W–B
CCS
Y
4 2
(Shielded)
RES/ACC
S4
R
G
SET/COAST
(Shielded)
STOP LIGHT SW
1 2 3 4 1 3 1
P2
<30–3>
M– M+ CL+ CL– CANCEL
To Integration
(*1)
B–O
EP
Control and Panel
3 C16
T1 CRUISE CONTROL SW
See Stop Light
POWER STEERING
THROTTLE CONTROL MOTOR
OIL PRESSURE SW
System<13–4> [COMB. SW]
BR
BR
B
17 IE1
Y
BR
C
ED Intake manifold left ED Intake manifold
left
B–O
D
(*1)
7 TOYOTA TUNDRA
* 1 : Towing Package
* 2 : Except Towing Package
P o w e r S o urc e H e ad ligh t (w / D a y tim e R u n ning L ig h t) * 3 : w/ Wireless Door Lock Control
* 4 : w/o Wireless Door Lock Control
1 2 3 4
ACC
[Comb. SW]2–2>
From Fog Light SW
<29–6>
Meter System
See Combination
<1–4>
From Generator
R–B
R
I23
IGNITION SW
W–G
B–Y
R–B 5 1K
R–B
R–B
2 1I 2 1K
2 2
6 1C
3 1 5A 15A
G–B
Y–G
1 1 1 1 ECU–IG TAIL
R
10A HEAD RR
10A HEAD RH
RELAY
DIMMER
10A HEAD LH
10A HEAD LL
4 1O 5 1O 2 1N 13 1N 1 1N
W–G
W
2003 TOYOTA TUNDRA (EWD491U)
R–B
R–B
9 6
R
4 5 2
2 2 3 3 2 2
2 2
2 2 2 2 2 2 2 2 2 INTEGRATION RELAY
40A AM1
50A J/B
G–W G
Y–B
R–W
R–L
L
8
W–G 9 IA5
1 2 1 2
1 1
HEADLIGHT RH
H2
HEADLIGHT LH
H1
3 1O 15 1N 6 1O 8 1J 3 1N 8 1N 7 1N 24 1N
2 2 Y–B
R–W
R–G
3 3
G–Y
(*3)
2 2 3
100A ALT(*2)
140A ALT(*1)
W–G
W–G
W–G
R–B
CONNECTOR
JUNCTION
J7
G–Y(*4)
F
LIGHT[COMB. METER]
HIGH BEAM INDICATOR
H–LP
C11 A , C12 B
GR
BR
16 B G–Y F
V
RELAY
R–W
A 2 2 (*3)
J2 A
1 5 JUNCTION F
1 CONNECTOR 3 1J (2UZ–FE)
3 1
A
G–Y
ECU<23–3>
To TVIP
4 1J (5VZ–FE)
(*3)
7 A
W–G
DRL
NO. 4
2 B RELAY 13 8 7
W–B
J2 B W–G
JUNCTION 5 2 H EL T HF HL HU
CONNECTOR
W–B
B OFF
CONNECTOR
JUNCTION
J8
2 2 4 1K A B C
CONNECTOR
JUNCTION
W–G
SW
CONTROL
LIGHT
J23 A , J24 B
1 TAIL
B–L(*1)
R–W
B (*2)
HEAD C
D2 A A
DAYTIME RUNNING LOW
DIMMER SW
W–B
LIGHT RESISTOR
HIGH
FLASH
2
C15 16
BR
BATTERY A COMBINATION
W–B
W–B A J18 J13
SW
W–B
JUNCTION JUNCTION
CONNECTOR A CONNECTOR
A J3 A W–B W–B A
W–B
JUNCTION
CONNECTOR
Front left fender EA Left kick IE IF Left kick Right kick II Right IH
panel panel panel kick
panel
M
8 TOYOTA TUNDRA
1 2 3 4
2 * 1 : Towing Package
1 1 1 * 2 : Except Towing Package
1 5 * 3 : w/ Wireless Door Lock Control
* 4 : w/o Wireless Door Lock Control
10A 10A 20A
H–LP
HEAD LH HEAD RH FOG
RELAY
100A ALT(*2)
140A ALT(*1)
1
2 3 3 2 2
2 2 2 2 2 2 2
R–B
R
G–R L–R
5 1K
R–L
R–W
B (*2)
B–L(*1)
2 2
3 3
6 1C 7 1C H1 H2 8 IA5 2 3
HEADLIGHT HEADLIGHT
J7 LH RH FOG
R
JUNCTION 2 1 2 1 RELAY
R
CONNECTOR R–G
G–Y F F 6 1L 1 5
(*3) R–Y
G–R
F 10 2 2
R–Y
R–G
C15
A A B B FOG LIGHT
RELAY
J2
P
J2
(*3)
SW
G–Y
W–B
JUNCTION JUNCTION
[COMB. SW]
CONNECTOR CONNECTOR
INTEGRATION
A B 11 D D P
<23–3>
5 1L
R–G
D
To TVIP ECU
R–Y
R–Y
G–Y
(*3)
4 1K
(*4)
G–Y
R
G–Y
(*3) 9 IA5
13 8
P
P
4 1J 3 1J
OFF
SW
R–G
R–G
TAIL
LIGHT
1 1
CONTROL
HEAD 16 B F1 F2
R–Y
R–Y
C11 A , C12 B FRONT FOG FRONT FOG
B (*2)
LOW LIGHT LH LIGHT RH
B–L(*1)
HIGH BEAM 2 2
A INDICATOR LIGHT
HIGH J11 A [COMB. METER]
JUNCTION
FLASH CONNECTOR 7 A
DIMMER SW
A
C15
W–B
W–B
W–B
16 17 7
COMBINATION R–Y
W–B
SW
BATTERY
R–G A B
J23 A , J24 B A A
JUNCTION A W–B
CONNECTOR
W–B
A A J18 A
JUNCTION
A J3 CONNECTOR
JUNCTION
W–B
CONNECTOR
W–B
* 1 : Towing Package
* 2 : Except Towing Package
P o w e r S o urc e T a illig ht Illum in a tio n * 3 : w/ Daytime Running Light
* 4 : w/o Daytime Running Light
1 2 3 4
G
1 2 G–Y To Engine Control
(2UZ–FE) Module<5–9> To Option Connector
INTEGRATION RELAY <31–3>
D10
(2UZ–FE)
DIODE
G
6 8 4 4 1G (Idle–Up)
G
J10 J12
(*1)
G
JUNCTION JUNCTION
4 1N (*3) E E CONNECTOR CONNECTOR E
15A TAIL
13 1L (*4) 2 1E 3 1H E G E E
E E E E E E E E
R–B
G
[COMB. SW]
STEERING SW
C16
2 1K 8 1J C A C A 1
JUNCTION CONNECTOR
J21 A , J22 B
G
J1 4
JUNCTION 1
W–G
A CONNECTOR
RHEOSTAT
R3
A B A B T
BR
2 BB1
G
5 ID2 6 ID2
2003 TOYOTA TUNDRA (EWD491U)
W–B
R–B
R–B
R–B
E L
G
A A
2 3
2
10 B
<23–4>
To TVIP ECU
W–G
W–B
G
CIGARETTE LIGHTER ILLUMINATION
C8
50A J/B
G
I24 A , I25 B 5 A
G
LICENSE PLATE LIGHT RH
L2
LICENSE PLATE LIGHT LH
L1
[REAR COMB. LIGHT RH]
TAILLIGHT RH
R5
[REAR COMB. LIGHT LH]
TAILLIGHT LH
R4
ASHTRAY ILLUMINATION
A18
INTEGRATION
MIRROR HEATER SW
M4
GLOVE BOX LIGHT
G3
1 1 2 2
[COMB. METER]
METER ILLUMINATION
C12
1 CONTROL
1 1 15 7 A AND PANEL 2 2 1 1
ILL+
2
G–W
2 2 1 1 2 3
100A ALT(*2)
140A ALT(*1)
2 2 3 3
14
GND ILL– IL–1
1 B 8 B 7 B
W–B
W–B
W–B
W–B
W–G
W–G
W–G
W–B
1
R–B
W–G
W–G
G–W
W–B
LIGHT
2 CONTROL SW
[COMB. SW] 14
EL T H
4 ID2 3 ID2
W–B
W–B
W–B
OFF
B–L(*1)
B (*2)
W–G
TAIL
W–G
W–G
BR
HEAD 3 BB2
E E E E E
CONNECTOR
JUNCTION
J18
A E
16 A
BATTERY
J5
W–B
W–B
W–B
A JUNCTION CONNECTOR 5 IE1 (2UZ–FE)
W–B W–B W–B 17 IE1 (5VZ–FE)
W–B
J3 A A
W–B W–B
W–B
W–B
JUNCTION B A
(2UZ–FE)
(5VZ–FE)
CONNECTOR A A
J13
BR
BR
W–B A W–B A J23 A , J24 B
JUNCTION
CONNECTOR JUNCTION
CONNECTOR
Left kick panel IF EA Front left fender Surrounding of the BL II Right kick Left kick IE Rear bank of EC Intake ED
front of the fuel tank panel panel left cylinder manifold
head left
M
M OVERALL ELECTRICAL WIRING DIAGRAM
PERSONAL
Relay<20–2><21–2> (*1) (*1)
1
D17
LIGHT
DOOR COURTESY SW
P8
FRONT RH
* 4 : w/o Wireless Door Lock Control
B–W(*2)
W–B B–W W–B
BK
(*2) (*2)
2
CONNECTOR
* 6 : Except Towing Package
D20
JUNCTION
J5
DOOR
B–W B–W B–W B–W W–B
4 BH1
5 BF2
4
2
D21
3
DOOR COURTESY SW
REAR RH UPPER
B–W B–W
4 BE2
(*2) (*2)
C
B–W
(*3)
B–W D11
DIODE
B–W
(*4)
C
ON (Power Window
* 3 : w/ Wireless Door Lock Control
2 IC1
1 1H
9 1B
DOOR
(*4) (*3)
1
2
I26
L–Y
W–B
INTERIOR LIGHT
B B–W
(*3)
* 1 : Standard Cab
W–L
* 2 : Access Cab
CONNECTOR
8 1B
ECU<23–4>
(*3)
JUNCTION
B
L–Y W–B B–W
To TVIP
(*3)
B
1
DIODE
B
J4
(TVIP)
B A
V7
D29
ECU<23–3>
W–B
VANITY LIGHT RH
L–Y
From TVIP
B–W B B
B B
(*3) (*3) (*3)
JUNCTION
J21 A , J22 B
JUNCTION CONNECTOR
J3
3
In terior L ig ht
2 1A
8 1J
IF
A
1
W–L
V6
VANITY LIGHT LH
L–Y L–Y
C B
B A
L–Y
D14
DOOR COURTESY
9 IB4 (*3)
1 IB2 (*4)
8 IB4 (*3)
4 IB2 (*4)
J23 A , J24 B
LIGHT LH
C
L–Y L–Y W–L W–L
CONNECTOR
B A
C
1
2
JUNCTION
JUNCTION CONNECTOR
D15
DOOR COURTESY
LIGHT RH
B A
8 IF4
4 IF1
C
1
L–Y
3 1A
4 1F
J9
L–Y L–Y W–L W–L
6 1E
3 1F
5 B
7 B
C
DOOR D9
C
DIODE
(Door Courtesy)
<23–3>
From
L W–L
TVIP
ECU
2
R
6 B
CYLINDER LIGHT
D27 S3
(*3)
IGNITION KEY
L B L–Y
E
1
2
I22
L–B L L
9 B
(*1) (*1)
Inside of rear door LH
1
E
CONNECTOR
D16
JUNCTION
L
4 BG2
DOOR COURTESY SW
(*2) FRONT LH
J4
GAUGE
(*2)
10A
BJ
2 1I
9 A
13 B
2
B–Y
B–W
D18
E
(*2)
DOOR COURTESY SW
C11 A , C12 B
REAR LH LOWER
COMBINATION
METER B–W B–W W–B
IG1 4
5 BG2
L
REAR LH UPPER
1
P ow er S ou rc e
I23
2 AM1
140A ALT(*5)
40A AM1 100A ALT(*6)
BATTERY
W
2
2
10A DOME
SHORT PIN B–L(*5)
L–Y B B (*6)
2
2
2
1 2 3 4
L–W
ACC
2 1I
2 AM1 IG1 4 B–Y 22 IA4
5A
TURN
I23
IGNITION SW
L–W
5 1J
R–B
G–B
G–B
G
G
1 4 6 5 1 3
IG +B ER EL TL TR TB
L–W
T5 C15
W
EHW LL LR GND RH
8 3 2 7 2
G–R
G–B
G–Y
W–B
W–B
7 1D 10 1D
and Panel<30–7>
From Integration Control
2 2
11 1E 12 1H 13 1H 7 1E 5 1D 11 1D 9 1D 6 1D
G–B
G–Y
2
G–Y
G–B
40A AM1
C A B A
G–B
G–Y
G–B
G–Y
J14 A , J15 B
1 JUNCTION
A B B B CONNECTOR
2 2
<31–4>
To Towing Converter
100A ALT(*2)
140A ALT(*1)
20A HAZ
LIGHT[COMB. METER]
TURN SIGNAL INDICATOR
C11 A , C12 B , C13 C
COMB. LIGHT LH]
LIGHT LH[REAR
REAR TURN SIGNAL
R4
G–Y
LIGHT LH
FRONT TURN SIGNAL
F3
LIGHT RH
FRONT TURN SIGNAL
F4
3 1 1 3 1 B 12 C
1 1
LH RH
2 2 3 3 2
W–B
W–B
W–B
7 A
W–B
W–B
CONNECTOR
JUNCTION
J18
A
B–L(*1)
B (*2)
A W–B
W–B
W–B
A A
W–B
A
3
W–B
W–B
A A
W–B W–B
W–B
W–B
BB2 B A
BATTERY
A A
W–B
J23 A , J24 B J3 J13
JUNCTION JUNCTION
JUNCTION CONNECTOR CONNECTOR
CONNECTOR
EA Front left BL Surrounding of the Left kick IE IF Left kick II Right kick
fender front of the fuel tank panel panel panel
M
12 TOYOTA TUNDRA
* 1 : 2UZ–FE
* 2 : 5VZ–FE A/T * 5 : 5VZ–FE
P o w er S o u rce F o g L ig ht (w / D ay time R un n in g Ligh t) B a c k– U p L ig h t * 3 : w/ Door Lock Control * 6 : Towing Package
* 4 : w/o Door Lock Control * 7 : Except Towing Package
1 2 3 4
D F
9 W–R(*3)
L–R(*1) L–R(*1) A B
IA4
ACC 3 L–R(*5) B–Y J21 A , J22 B
(*5)
L–R
JUNCTION
2 AM1 IG1 4 B–Y
W–R(*3)
CONNECTOR
L–R W–R(*4)
2 1I 1 1I
(*1)
3 2
W–R(*4)
W–R(*3)
I23 A22
10A 15A
IGNITION SW ACC CUT RELAY
GAUGE ACC
8 4 1
L–O L–O See Engine Control
17 IA5 IA4
(*1) (*1) System<5–2>
J9
7 1F 8 1F 9 1F 11 1G JUNCTION
R–B G–W CONNECTOR
GR(*3) A A GR(*3)
W
D8
L–R
L–R
W–R
R–B DIODE(A/T)
GR(*4) GR(*4) 3
B–Y
B–Y
(A/T)
(M/T)
2 2 2 2 2 2
B–Y E E B–Y 1 2
(A/T) (A/T)
2 1 3 3 J8
2 3 JUNCTION CONNECTOR
(*2)
(*1)
L–B
L–B
B–Y
10A
(M/T)
B–Y
(A/T)
HEAD LL J12
JUNCTION
5A ECU–B
CONNECTOR
FOG RELAY
DIMMER RELAY
1 2 2 2 2 2 5 4 1 1 5 4 IE1 (*2)
R–B C C
(A/T) 2 IE1 (M/T) 26 IE1
2 2 2 3 2 2 2 2 2 2 2
5 1 L–B(*2)
(*1)
L–B
P
B3 B–Y(M/T)
B
R–Y BACK–UP
40A AM1
20A FOG
H–LP RELAY
LIGHT
R–B
(M/T)
5 1 D
G
R–B(*2)
R–B(*1)
J2
RELAY
R–B(M/T)
2 1 1 3 A (A/T)
8 IA5 D
3 2 2 B (M/T)
R–B
2 2
JUNCTION
B1 B
P1 A
D (A/T)
CONNECTOR
P
P
R–Y
POSITION SW]
7 BB1
F2
F1
[PARK/NEUTRAL
11
2 A (A/T)
SHORT PIN
1 1
BACK–UP LIGHT SW
BACK–UP LIGHT SW
100A ALT(*7)
140A ALT(*6)
C15 1 B (M/T)
R–B
See Headlight
System<7–3>
Y
[COMB. SW] Socket
2 2 (*6)
<31–3>
R4
(*5)
R–B
5 5
G–B
(*1)
R–B
W–B
W–B
W–B
(A/T)
J18
A
12 IE1 (M/T)
B (*7)
B–L(*6)
JUNCTION
BACK–UP LIGHT LH
BACK–UP LIGHT RH
A 3 3
CONNECTOR
W–B
A B R–B(*2)
[REAR COMB. LIGHT LH]
[REAR COMB. LIGHT RH]
Relay<7–3>
3
W–B
W–B
To Integration
W–B W–B W–B
JUNCTION
BB2 R–B(M/T)
CONNECTOR
BATTERY A A
W–B
J23 A , J24 B
W–B
W–B
1 2 3 4
G–Y
G–Y
System<5–15><6–11>
G–Y
2 1F * 1 : Towing Package 4 2
* 2 : Except Towing Package
ACC
S4
15A 2 AM1 IG1 4 B–Y STOP LIGHT
STOP SW
2 1I
3 1
I23
2 1K IGNITION SW
Module<5–14><6–9>
To Engine Control
See Cruise Control
G–W
10A
System<5–15><6–11>
GAUGE
2003 TOYOTA TUNDRA (EWD491U)
J11
JUNCTION
CONNECTOR C C
W–G
R–W
D D C J10
W
9 1F JUNCTION
CONNECTOR
D C C
B–Y
G–W
G–W
G–W
G–W
(*1)
R–W
R–W
R–W
R–W
B–Y
B–Y
16 IA5
G–W
2 2 2 2 2
E
J8 E B–Y 4 1D 1 1D
<31–4>
To Towing Converter
<31–3>
To Option Connector
ECU<16–4>
To ABS Actuator with
2 2 JUNCTION 2 3 25 IA4 6 IB3 6 IF3
CONNECTOR
E
MIR HTR
50A 15A 40A
RELAY
R–W
R–W
R–W
J/B MIR HTR AM1
1 5
M4
G–W
G–W
1 1 2 2 J14 A , J15 B
MIRROR HEATER
2 SW 2 2 JUNCTION
2 IG CONNECTOR A A 1 IC1
R–W
W
140A ALT(*1)
G–W
100A ALT(*2) 6 6
E D
STOP LIGHT
HIGH MOUNTED
H10
11 IA4 1
C B C B
W–B
W–B
4 6
1
G–W
G–W
W–B
2
2 P–G
W–B
W–B 4 4
B–L(*1)
B (*2)
2 1A
A B A B
W–B
W–B
J23 A , J24 B
JUNCTION 3 3
CONNECTOR
8 1J
W–B
W–B
A A
W–B
BATTERY
A A
W–B
J13 J3
W–B
JUNCTION JUNCTION
CONNECTOR CONNECTOR
IE Left kick Right kick II Surrounding BL Left kick IF
panel panel of the front panel
of the fuel tank
M
14 TOYOTA TUNDRA (Cont. next page)
1 2 3 4 W–R
A
L–R
B
B–Y
C
ACC 3 L–R
* 1 : Towing Package
2 AM1 IG1 4 B–Y * 2 : Except Towing Package
B–R
4 1I
ST2
5A
W–R
IGN
I23
A4
2 IGNITION SW
2 R–B
See Engine Control System D
2 11 1F <5–7><5–10><5–11><5–12><5–13>
W–R
<5–14><5–15> W–R
E
6 IA4 15 IA4
B–O
1
L
B F
5A ECU–B
J5
A/T OIL TEMP. SENSOR
1
W
LG
B–R
G
JUNCTION
B
2
CONNECTOR
2 2 2
R–L
B–Y
B–Y
B–R
B–R
B–R
B–W
L
Y–R
LG
R–B
W–R
B–O
2
3 A 8 A 9 A 32 D 28 E 19 B 16 E 17 E 19 E 21 E 22 A 20 A 17 B 18 E 11 B 10 B 9 B 8 B 25 B
B
BATT MREL IGSW THOC E2 STP NSW STA THW VTA VPA TC SPD VC R D 2 L OILW
40A AM1
2 1
2 2 +B +B2 E1 S1 S2 SL SLT+ SLT– SP2– SP2+ ME01 E03 E02 E01 NCO– NCO+ ODMS ODLP
1 A 2 A 1 C 11 D 10 D 15 D 13 D 12 D 34 D 26 D 4 C 7 C 6 E 7 E 35 D 27 D 16 A 7 B
2 2 2 2
2 3
BR
EFI
V
P
R
RELAY
L–O
Y–R
W–B
W–B
W–B
W–B
W–R
30A AM2
SHORT PIN
1
100A ALT(*2)
140A ALT(*1)
P–L
B–R
W–L
W–L
G–R
1 1 1 1 5
G–W
2 2 14 IA4 1
O1
1 3
2
O4
W–L
W–B
Controlled Transmission)
4 8 7 2 6
SPEED SENSOR
O/D MAIN SW
E1
2 2 1
B (*2)
B
B–L(*1)
O/D DIRECT CLUTCH
J1
B
Y
G
A
O
J18
JUNCTION
CONNECTOR
W–L
W–B
B
VEHICLE SPEED SENSOR(Electronically
JUNCTION
W–R
CONNECTOR
BATTERY
SLT
NO. 1
NO. 2
NO. 3
L–O
W–L
I
W–B
TRANSMISSION SOLENOID
W–B
J
ELECTRONICALLY CONTROLLED
BR
W–R 5 6 7 8
A
L–R
B
B–Y B–Y
C L–O
W–R
L–R
2 1I 1 1I 8 IA4 9 IA4 17 IA5
P1
A/T INDICATOR SW L–B W–R
[PARK/NEUTRAL (*3)
L–O
L–R
POSITION SW] 3
10A 15A
CONNECTOR
JUNCTION
J21 A
RB GAUGE ACC D A
W–R
,
(*4)
J22 B
LL 2L DL NL RL PL
F B
5 1F 9 1F 11 1G
8 4 7 5 2 1
R–B
D W–R
(*3)
W–R B–Y 3 2
2003 TOYOTA TUNDRA (EWD491U)
LG–B
W–R
R–B
B–Y
L–Y
E
(*3)
GR
LG
L
A22
L 11 IE1 20 IE1 6 IE1 10 IE1 2 IE1 19 IE1 E A ACC CUT RELAY
F J8 J9
(*4)
GR
JUNCTION JUNCTION
CONNECTOR CONNECTOR 4 1
LG
G E A
L–O
B–Y
(*3)
GR
Y–R
LG–B
W–R
W–R
R–B
R–B
H
LG
LG
L
System<5–2>
See Engine Control
JUNCTION CONNECTOR
J11
CONNECTOR
JUNCTION
J8
B C C C 1 3
B
D8
DIODE
A B A B B C C J12 (A/T)
JUNCTION
L–Y
CONNECTOR 2
J12 A B
L–B
JUNCTION
LG–B
CONNECTOR
W–R
R–B
B–Y
LG
26 IE1
9 A 9 D 8 D 7 D 6 D 5 D 4 D
A/T OIL TEMP.
L 2 D N R P L–B
O/D OFF
J23 A , J24 B
L–O
I JUNCTION
CONNECTOR
A A
W–B W–B W–B
J B A
IE Left kick
panel
M
15 TOYOTA TUNDRA (Cont. next page)
P o w e r S o urc e E lec tro nica lly C o ntro lled T ran s mis s io n a n d A /T In dica tor (5 V Z – F E )
1 2 3 4
L–R
A
B–Y
B
R–Y
W–R
C
I23
11 1F
A4
IGNITION SW
1 R–B
D
See Engine Control System
B–R
W–R
<6–5><6–7><6–9><6–10> L
E
(*1)
B–O
6 IA4 15 IA4
B
J5
2
LG
F
JUNCTION
2 2 2 B
Y–R
CONNECTOR
G
2
(*1)
(*2)
B–Y
B–Y
R–Y
B–R
B–R
B–R
B–O
B–O
B–W
L
LG
R–B
Y–R
W–R
16 A 4 A 15 A 19 E 11 E 20 A 3 B 7 A 18 E 15 E 25 E 7 D 6 A 25 B 6 B 5 B 4 B 21 B
40A AM1
BATT MREL IGSW OIL E2 STP NSW STA THW VTA VC TC SP1 D R 2 L OILW
1
E3 A , E4 B , E5 C , E6 D , E7 E ENGINE CONTROL MODULE
2 2 2
2 2 +B SLT+ SLT– S1 S2 SL SP2– SP2+ E1 E02 E03 E04 E01 ME01 ODMS ODLP
1 A 5 C 11 C 3 E 2 E 1 E 22 D 23 D 17 D 5 E 7 E 8 E 4 E 6 D 14 B 20 B
2 3
30A AM2
100A ALT
1 1 1 EFI
R
BR
BR
RELAY
L–O
Y–R
W–L
W–B
W–B
W–B
W–B
W–R
B–R
W–L
V3
G–R
1 5
G–W
2
2 2 14 IA4 1
B
3
W–L
W–B
2 6 4 8 7
O4
E1
A B SLT+ SLT– 2
J18 J1
B
Y
O
W
JUNCTION JUNCTION
O/D MAIN SW
CONNECTOR CONNECTOR 1
(Electronically Controlled Transmission)
W–L
A B
SL
BATTERY
W–B
W–R
NO. 1
NO. 2
L–O
W–L
W–B
H
TRANSMISSION SOLENOID
W–B
I
ELECTRONICALLY CONTROLLED
5 6 7 8
L–R L–R
A * 3 : w/ Door Lock Control
B–Y B–Y * 4 : w/o Door Lock Control
B
P1 L–B 2 1I 1 1I
A/T INDICATOR SW
[PARK/NEUTRAL POSITION SW] 3
RB
10A 15A
GAUGE ACC
LL 2L DL NL RL PL
8 4 7 5 2 1
W–R
C 5 1F 9 1F 11 1G
R–B
D
B–Y
L
2003 TOYOTA TUNDRA (EWD491U)
LG–B
W–R
R–B
B–Y
L–Y
E
(*3)
GR
LG
L
LG 23 IE2 6 IE2 26 IE2 2 IE2 15 IE2 21 IE2 E A
F J8 J9
(*4)
GR
JUNCTION JUNCTION
Y–R CONNECTOR CONNECTOR
G E A
B–Y
(*3)
GR
W–R
W–R
R–B
R–B
LG
LG
L
CONNECTOR
JUNCTION
J8
A B A B B C C 1 3
B
LG–B
L–Y
D8
DIODE
B C J12 (A/T)
J12 A B JUNCTION
JUNCTION CONNECTOR 2
CONNECTOR
W–R
Y–R
R–B
B–Y
LG
L–B
9 A 9 D 8 D 7 D 6 D 5 D 4 D
4 IE1
A/T OIL TEMP.
L 2 D N R P
O/D OFF
L–B
10 D 3 D 7 A
C11 A , C14 D W–B
COMBINATION METER
A A
J23 A , J24 B
W–B
JUNCTION
L–O CONNECTOR
H
A B
W–B W–B W–B
I W–B
IE Left kick
panel
M
16 TOYOTA TUNDRA
1 B–Y 2 3 4
2 1I
ACC
W 2 AM1 IG1 4
10A 5A
GAUGE ECU IG
I23
IGNITION SW
B–R
5 1F 3 1K
W
B–Y
<5–4><6–4>
<13–4>
B–Y
<18–4><19–3>
To Detection SW
Data Link Connector 3
Y
9 A
(Transfer L4 Position)
From Stop Light SW
[COMB. METER]
C11 A , C13 C
B–Y
B–R
ABS WARNING LIGHT
G–W
Y
W
L–R
2 2 2 7 C
W–L
W–G
B–Y
B–R
B–L
2
1 17 11 6 14 3 15 7 24
+BS +BM WA IG1 EXI D/G TC TS STP
40A AM1
A5
1 ABS ACTUATOR WITH ECU
FL+ FL– FR+ FR– RL+ RL– RR+ RR– GND1 GND2
2 2 2 9 8 23 22 5 4 19 20 2 18
P
V
B
Y
R
W
LG
40A ABS2
30A ABS3
100A ALT(*2)
140A ALT(*1)
1 1 1
1 EA1 4 EA1 2 EA1 5 EA1 8 BB1 9 BB1 10 BB1 11 BB1
B
Y
R
W
W–B
W–B
2
L
P
V
LG
2 1 4 3
B (*2)
B–L(*1)
2 1 2 1
A6 A7 LH RH
ABS SPEED SENSOR ABS SPEED SENSOR
FRONT LH FRONT RH
A19 A A
BATTERY
J13
ABS SPEED SENSOR REAR JUNCTION
CONNECTOR
II Right kick panel
17 TOYOTA TUNDRA
1 2 3 4
L–Y
ACC B–R
L–Y
AM1 IG1
6 1E
4 1I
L–Y
10A Airbag Assembly) (Steering Wheel Pad)
DOME
I23 3 1M 5 B
1 IGNITION SW C12 B , C13 C
SRS WARNING LIGHT
<30–5>
Sensor and Buckle SW RH
Occupant Detection
From Seat Belt Warning
1 2
<5–14><6–9>
To Engine Control Module
2 SPIRAL [COMB. METER]
Y–G
Y–R
P3 A , P4 B CABLE
2003 TOYOTA TUNDRA (EWD491U)
<26–4>
To Buckle SW LH
PASSENGER AIRBAG
W–R
MANUAL ON–OFF SW 2 A 3 A
B
1 2 10 C
SQB+ SQB–
B–O
B–Y
2 2
Y–B
E IND ECU– ECU+ A
Y
J5
2 2 A B–Y
1 B 2 B 4 A 1 A JUNCTION
CONNECTOR
SHORT A
30A
PIN
W–B
Y–G
Y–R
R–B
B–Y
B–L
AM2
B
1
1 11 B 10 B 14 B 13 B 5 B 8 C 23 B 11 A 3 B
P– P+ D+ D– IG2 RBE+ GSW2 LBE+ LA
and Panel<30–6>
To Integration Control
and Panel<30–7>
From Integration Control
C4 A , C5 B , C6 C
2 CENTER AIRBAG SENSOR ASSEMBLY
W–R
BR
B–L(*1)
B (*2)
BR–W
W–G
W–B
W–B
B–W
Y–B
Y–B
B–Y
1 IA1 2 IA1
W
Y
W–R
BR
1 2 1 2 2 1 2 1
CONNECTION CONNECTION
DETECTION PIN DETECTION PIN
<5–4><6–4>
To Data Link Connector 3
BATTERY
P13 P14 A B A B
PRETENSIONER PRETENSIONER
LH RH
W–B
A11 A12
AIRBAG SENSOR AIRBAG SENSOR
FRONT LH FRONT RH
Left kick panel IE IH Right kick panel
M
18 TOYOTA TUNDRA (Cont. next page)
P ow er S ou rc e 4 W D (2 U Z – F E )
1 2 3 4
* 1 : w/ Door Lock Control
* 2 : w/o Door Lock Control
(*2)
W–R
* 3 : Towing Package
9 * 4 : Except Towing Package
ACC 3 L–R L–R
IA4
(*1)
W–R
2 AM1 IG1 4 B–Y
3 2
<29–3>
(*2)
(*1)
W–R
W–R
A22
ACC CUT
I23 RELAY
F B IGNITION SW
4 1
To Combination Meter
JUNCTION
L–O
See Engine Control
CONNECTOR
D A System<5–2>
8 IA4
J21 A , J22 B
B–Y
B–Y
(*1)
L–O
W–R
2 1I 1 1I 1 1J
G–O
B–Y
F7
12 3 4WD CONTROL ECU
17 IA5 IG SPD
10A 15A 20A
GAUGE ACC 4WD
W–R
W
2
IND2 IND1 N GND H–L 2–4 L4 4WD
2 20 21 5 25 7 4 18 6
9 1F 11 1G 5 1F
5A
P
L–R
B–Y
B–Y
Y–B
G–Y
W–B
BR–Y
LG–B
GR
ECU–B
(*1)
J12
E A JUNCTION
J8
J9
2
D CONNECTOR
1 C11 A , C12 B , C14 D
GR
(*2)
G–R
2 9 A COMBINATION METER
JUNCTION
JUNCTION
E A
2
CONNECTOR
CONNECTOR
D D D
GR
40A
(*1)
B–Y
AM1
B
1 3
<30–6>
L–R
L–R
L–R
2 1 D8
To Integration
2 DIODE
(A/T)
Control and Panel
2 24 IE2 3 IE2
140A ALT(*3) 2
SHORT 10 B 11 B 8 A 1 D
100A ALT(*4)
PIN
L–B
L–R
G–R
1 1
Module<5–10>
D3
2 2
with ECU<16–3>
26 IE1
D4
Y–B
Y–B
BR–Y
BR–Y
From ABS Actuator
L–B
3
DETECTION SW
From Integration
DETECTION SW
P1
W–B
<30–6>
(Transfer 4WD Position)
[PARK/NEUTRAL W–B
B (*4)
B–L(*3)
POSITION SW]
W–B
W–B
5
10 2
W–B
4 W D (2 U Z – F E )
5 W–B 6 7 8
T3
TRANSFER SHIFT ACTUATOR 4
H2
M
H4
L4
1 2 3 5 6
B–W
B–R
W
G
L
13 26 8 9 22 19
2003 TOYOTA TUNDRA (EWD491U)
GR
TM1 TM2 TL1 TL3 TL2 ADD
R–B
GR
LG
GR
17 IE2 9 IE2 16 IE2 8 IE2
R–W
R–B
GR
LG
R–B
GR
LG
R–B
GR
LG
6 2 5 1 3
4 A9
W–B
ADD ACTUATOR
6 ED1
6
W–B W–B
A EC1
W–B
B
M
19 TOYOTA TUNDRA
1 2 3 4
L–R
ACC 3 B–Y
2 AM1 IG1 4 W W
B–Y
L–R
2
D3 1 1J 2 1I 1 1I
W
DETECTION SW
I23 (Transfer 4WD
IGNITION SW Position) 6 IE1
W
1
B–R
W
W
1 IE2 (A/T)
15A ACC
20A 4WD
C C
Module<6–10>
Module<6–10>
Module<6–10>
with ECU<16–3>
10A GAUGE
B–R
W
W
7 9 3
J8
J9
GR
B–Y
L–R
L–R
L–R
R–Y
(A/T)
(A/T)
(A/T)
(M/T)
GR
(*1)
2
D E A
T4
J12
D
2
JUNCTION
GR
(*2)
D E A
CONNECTOR
GR
GR
(A/T)
(M/T)
40A
AM1
GR
(*1)
JUNCTION CONNECTOR
JUNCTION CONNECTOR
B–Y
J9
L–R
17 IE2 10 IE3
(A/T)
JUNCTION 1 3
1 B CONNECTOR
B–Y
2
13 IE2 7 IE3
GR
GR
GR
GR
D8
(A/T)
(M/T)
(M/T)
ALT 2
2 4 10 1 5 DIODE
(A/T)
L–R
L–R
(A/T)
(M/T)
R
LG
R–B
R–Y
R–Y
(A/T)
(A/T)
R–W
1 D D
L–B
GR
(A/T)
1 IE3 9 IE3 2 IE3 18 IE1 (M/T) J10 2 D 9 A
R
LG
R–B
R–W
5 EG1 4 EG1 3 EG1 2 EG1 1 EG1
L–R
R–Y
(A/T)
(A/T)
4WD
A/T P
L–R
L–B
(M/T)
R
LG
GR
GR
R–B
1 2 5 6 3 1 1 3
COMBINATION METER
R–W
4 D 10 B
W–B
B
P1
D4 D5
NEUTRAL
C11 A , C12 B , C14 D
DETECTION SW DETECTION SW
(Transfer L4 (Transfer Neutral POSITION SW
M [PARK/NEUTRAL
Position) Position)
POSITION SW]
2 2 1
GR
L–Y
L–Y
A9
(A/T)
W–B
W–B
4
ADD ACTUATOR 6
W–B W–B
EG1
7 21 IE2
BATTERY W–B W–B W–B W–B
IE1
(A/T)
A
W–B
L–Y
J13
JUNCTION
CONNECTOR
Right kick panel II
20 TOYOTA TUNDRA
L igh t A u to T urn O ff
(w / D ay tim e R un ning
P o w e r S o urc e D o or Lo c k C on trol (w / D a ytim e R u nn in g L ig ht) L ig ht)
1 2 3 4
W–G
B–Y
<7–3><7–4>
System
See Headlight
* 1 : Towing Package
System<9–1>
See Taillight
W–G
ACC * 2 : Except Towing Package
<10–4>
Rear LH, RH
Front RH,
Courtesy SW
To Door
<10–1>
SW Front LH
Courtesy
To Door
SW<26–4>
Warning
To Unlock
2 AM1 IG1 4
2 1I 2 1K
1
I23
IGNITION SW
W–G
B–W
P–B
5A 30A 15A
W
L
ECU IG POWER TAIL
6 1N 7 1H 6 1H 4 1O 3 1N 4 1N
2
2 2
9 14 15 INTEGRATION RELAY 3 6
2 2
40A AM1
50A J/B
2003 TOYOTA TUNDRA (EWD491U)
13 12 8
1 1
22 1N 20 1N 23 1N J 7 19 1N 21 1N 9 1N 10 1N 8 1H 9 1H 8 1J 24 1N
2 JUNCTION
L–R
C
G–B
R–Y
CONNECTOR J4 J7
100A ALT(*2)
140A ALT(*1)
R–Y(5VZ–FE)
R–W(2UZ–FE)
R–L
C L–R JUNCTION JUNCTION
W–G
L–W
L–W
D C CONNECTOR CONNECTOR A
L–Y
C C A E
J7 L–R
A
CONNECTOR
JUNCTION
J7
JUNCTION D
CONNECTOR B D
1 C A E E
W–G B B
B A
W–B
D C D C D
B–Y
BR
2
W–G
W–G
L–W
L–W
B
G–B
R–Y
G–B
R–Y
R–Y
W–G
L–R
L–R
L–R
R–L
R–L
L–Y
L–Y
J21 A , J22 B
JUNCTION
CONNECTOR
6 IF4 7 IF4 6 IB4 7 IB4 9 IB3 8 IB3 9 IF3 8 IF3 3 IB3 5 IB3 3 IF3 5 IF3
<23–4>
From TVIP ECU
<23–3>
From TVIP ECU
L–W
L–W
R–L
L–Y
<23–4>
From TVIP ECU
W–G
W–G
G–B
G–B
R–Y
R–Y
R–Y
<23–3>
From TVIP ECU
L–R
JUNCTION CONNECTOR
J8
SW LH
DOOR UNLOCK DETECTION
DOOR LOCK MOTOR AND
D25
SW RH
DOOR UNLOCK DETECTION
DOOR LOCK MOTOR AND
D26
[POWER WINDOW MASTER SW]
DOOR LOCK CONTROL SW LH
P10
4 2 4 2
D
SW RH
DOOR LOCK CONTROL
D24
UNLOCK SW RH
DOOR KEY LOCK AND
D23
UNLOCK SW LH
DOOR KEY LOCK AND
D22
1 3 1 3 2 5 6 5
<23–4>
From TVIP ECU
UNLOCK
UNLOCK
UNLOCK
M M
UNLOCK
B–L(*1)
B (*2)
D
LOCK
LOCK
LOCK
LOCK
2 2 1 3 1 3 1 3
W–B
W–B
B–Y
B–Y
W–B
W–B
W–B
W–B
W–B 4 IB3 4 IF3 J21 A , J22 B
W–B W–B W–B JUNCTION
B–Y
CONNECTOR
F
W–B
A A 1
B–Y
B–Y
A
BR
W–B W–B L–Y To TVIP ECU
A B IB3
BATTERY 1 IF3 <23–4> D F
J23 A , J24 B J3 B A
W–B
W–B
JUNCTION JUNCTION
A CONNECTOR CONNECTOR
J13 A W–B A A W–B
JUNCTION
CONNECTOR
II Right kick panel IE Left kick Left kick panel IF Right kick IH
panel panel
M
21 TOYOTA TUNDRA
L ig ht A u to T u rn O ff
(w /o D a y tim e R un ning
P o w e r S o urc e D o or L oc k C on tro l (w /o D ay time R u nn in g L ig ht) L ig h t)
1 2 3 4
W–G
W–G
2 AM1 IG1 4
<10–4>
To Door
<10–1>
To Door
<26–4>
Courtesy
Front RH,
See Headlight
System<8–1>
To Unlock
2 1I 2 1K
See Taillight
Rear LH, RH
System<9–1>
SW Front LH
Courtesy SW
Warning SW
1
I23
IGNITION SW 5A 30A 15A
W
P–B
B–W
W–G
ECU IG POWER TAIL
7 1H 6 1H 4 1L 6 1L 5 1L 13 1L
2
2 2
9 14 15 INTEGRATION RELAY 3 6
2 2
50A J/B
40A AM1
13 12 8
1 1
D28 3 1L 1 1L 2 1L 9 1L 8 1L 8 1H 9 1H 8 1J 16 1L
2 DIODE
(LOCK) J4 D30
L–R
G–B
R–Y
2 1 G–B JUNCTION DIODE
D C CONNECTOR (UNLOCK) J7
C C R–Y 1 2 E
JUNCTION
L–Y
R–L
L–W
L–W
L–R C A A
W–G
CONNECTOR D
J7
100A ALT(*2)
140A ALT(*1)
D J7 A R–L D
1 C JUNCTION E E
L–R
R–W
J4 A CONNECTOR B A
JUNCTION
B D C D C JUNCTION A A D
2
J7
CONNECTOR
BR
B–Y
W–B
R–L
R–L
L–W
L–W
A JUNCTION
JUNCTION
B B CONNECTOR
3 IB3 5 IB3 3 IF3 5 IF3
CONNECTOR
L–R
R–Y
R–Y
G–B
G–B
W–G
W–G
R–W
R–W
L–R
L–R
W–G
6 IB4 7 IB4 9 IB3 8 IB3 9 IF3 8 IF3 6 IF4 7 IF4
R–L
L–Y
J8
D25
D26
4 2 4 2
<23–3>
SW LH
D
SW RH
L–R
R–Y
R–Y
R–Y
G–B
G–B
W–G
W–G
P10
D24
D22
D23
1 3 2 5 6 5 1 3
From TVIP ECU
M M
SW RH
D
B (*2)
DOOR LOCK
B–L(*1)
<23–4>
<23–4>
MASTER SW]
LOCK
LOCK
LOCK
LOCK
UNLOCK
UNLOCK
UNLOCK
UNLOCK
JUNCTION CONNECTOR
UNLOCK SW LH
1 3 1 3
UNLOCK SW RH
From TVIP ECU<23–4>
CONTROL SW LH
[POWER WINDOW
DOOR LOCK MOTOR AND
DOOR LOCK MOTOR AND
2 1 3 2
DOOR UNLOCK DETECTION
DOOR UNLOCK DETECTION
B–Y
B–Y
W–B
W–B
W–B
W–B
W–B
W–B
F
A A 1 A
W–B W–B W–B L–Y To TVIP ECU
B–Y
A B IB3
BATTERY 1 IF3 <23–4> D F
B–Y
BR
J23 A , J24 B J3 B A
JUNCTION JUNCTION
A
W–B
CONNECTOR CONNECTOR
J13 A W–B A A W–B
JUNCTION
CONNECTOR
II Right kick IE Right kick Left kick panel IF Right kick IH
panel panel panel
22 TOYOTA TUNDRA
1 2 3 4
L–R
(*1)
ACC L–R
(*2)
2 AM1 IG1 4
L–R
L–R
L–R
(*1)
(*2)
L–R
W–G
B–Y
(*2) 3 IB4
I23 2 1I 2 1K 1 1C 2 1C
L–R
IGNITION SW A A A A
J21 A , J22 B P10
1 JUNCTION 9 POWER WINDOW MASTER SW
CONNECTOR BW
5A 30A WINDOW
ECU POWER C B LOCK SW
IG
FRONT RH
2
W–G
FRONT LH
W
UP DOWN
2003 TOYOTA TUNDRA (EWD491U)
L–R
9 3 2 1 5
RELAY
POWER
2 2 INTEGRATION RELAY
2 2
14 15 8 2 3
1 UP DOWN
40A AM1
50A J/B
7 1H 6 1H 8 1J P21
POWER WINDOW SW
(Back Window)
1 1 E DU DO PU PW
OPN CLS E1
2 3 6 2 1 3 4 8 10
W–B
100A ALT(*4)
140A ALT(*3)
R–W
R–B
W–B
G–B
R–L
2 IB4 1 IB4
W–B
L–Y
LG
1
<20–2><21–2>
Control System
See Door Lock
R–W
R–B
L–R
2
1 BF2 4 BF2
1 IB3
2 IF4 1 IF4 3 IF4
B–L(*3)
B (*4)
R–W
G–B
R–B
R–L
L–R
2 1
W–B
M
5 2
P11
POWER WINDOW SU SD
MOTOR FRONT LH B 4
A B P9
J23 A , J24 B POWER WINDOW
1 2
DOWN
M CONTROL SW RH
UP
BATTERY JUNCTION
P22 A A CONNECTOR
POWER WINDOW MOTOR U D
W–B
(Back Window) 3 1
W–B
L–Y
LG
A
W–B A J3 1 2
JUNCTION M
CONNECTOR
P12
IF Left kick IE Left kick POWER WINDOW
panel panel MOTOR FRONT RH
M
M OVERALL ELECTRICAL WIRING DIAGRAM
UL2
10 B
(*6) RH<21–3>
UL1
9 B
LH<20–1><20–2>
TVIP ECU
4
L2
8 B
LH, RH<20–1><20–2>
DMLP
From Interior Light, B–W L–R To Door Key Unlock SW
UL3
6 C
4 A
Personal Light<10–3> LH<20–1><20–2>
6 : w/o Daytime Running Light
5 : w/ Daytime Running Light
2 : Except Towing Package
HORN
G–R B–Y
ACT–
From Integration Relay To Door Lock Motor RH
4 C
12 A
<27–3> <20–4><21–4>
1 : Towing Package
R–B L–Y
ACT+
From Integration Relay From Door Lock Motor LH
TAIL
2 C
11 A
<9–1> <20–3><21–3>
7 : w/o TVIP
3 : 2UZ–FE
4 : 5VZ–FE
LSWP
HEAD
From Integration Relay G–Y L–Y To Door Unlock Detection SW
10 A
15 B
<7–4><8–1> RH<20–3><21–3>
*
*
*
*
*
*
*
T V IP an d W ire le ss D o or L oc k C on trol
To ST Relay G–R
LSWD
<2–2> (*3) R–L To Door Unlock Detection SW
14 B
LH<20–3><21–3>
From ST Relay G–R
ST
3 C
<1–2> (*4)
DSWD
L To Door Courtesy SW
4 B
Front LH<10–2>
GR
Cut Off
12 B
A
P–B
KSW
To Unlock Warning SW
6 B
<26–4>
3
W–R
(*4)
B To Diode(Power Window System),
CTY
5 B
(Door Courtesy)<10–3>
P From Park/Neutral
W–R W–R W–R (*3) Position SW<2–3>
+B1
17 IA5
D A
D A
11 B
(*3) (*3)
P To Park/Neutral Start SW(A/T)<1–2>
SRLY
J21 A
(*4) Cancel SW(M/T)<1–2>
JUNCTION
CONNECTOR
L–W
IND
LP
6 A
W–G 2
(*4)
(Shielded)
POWER
MIC–
MI–
17 B
4
30A
MI+
4 1C
2 1K
C A
B B
1 A
18 B
(*3) (*3)
1
J23 A , J24 B
J23 A , J24 B S10
JUNCTION SECURITY INDICATOR
CONNECTOR
CONNECTOR AND GLASS BREAKAGE
JUNCTION
SENSOR MICROPHONE
W–B
2
W–B W–B
E
7 A
A A
A B
T10
TVIP BUZZER
V V W–B W–B
BZR
7 IA4
3 IA4
2 A
A A
ECU IG
2
5A
IG
2 1I
13 B
2 B
A A
(*7) (*7)
1
S9
SHORT CONNECTOR
B–Y
(TVIP)
A A
IG1 4
ACC
W–B
Left kick
IGNITION SW
panel
W–B
I23
IE
2 AM1
40A AM1
P ow e r S ou rc e
W
140A ALT(*1)
100A ALT(*2)
2
1
23 TOYOTA TUNDRA
50A J/B
BATTERY
W–G
2
5A ECU–B
SHORT PIN B–L(*1)
W–R B B (*2)
2
2
2
1 2 L–R 3 4
(*5)
L–Y
GR
W–R
L–R
(*5)
(*7)
L–Y
L–Y
ACC 3 L–R GR
4 1F (*6)
W–R W 2 AM1 IG1 B A
J23 A , J24 B
(*8)
JUNCTION
1 1I 10 1G 12 1G CONNECTOR
9 IA4 C B
17 IA5 6 1E I23
IGNITION SW
W–R
W–R
W–R
15A
L–R
L–O
(*7)
(*8)
(*5)
(*5)
L–Y
(*5)
GR
ACC
2 2
L–Y
1 ID2 (*1)
GR
CONNECTOR
JUNCTION
J21 A , J22 B
10A DOME
5A ECU–B
2003 TOYOTA TUNDRA (EWD491U)
F B
GR
1 4
1 1
L–O
(*5)
GR
B
2
W–R
L–O
(*7)
(*5)
C7
2 16 IA4 CIGARETTE
LIGHTER
1
2
<5–2>
See Engine Control System
GR
B
W
B
13 5
2 2 2 2 1 1 ACC B
AND PANEL]
[INTEGRATION CONTROL
CLOCK
I25
PWR OUTLET1
15A
PWR OUTLET2
15A
2
W–B
40A AM1 3 2 GND
POWER 1
OUTLET 2 2
RELAY 2 2
1 5 1
G–B
2 2
G
100A ALT(*4)
140A ALT(*3)
SHORT PIN
G–B
* 3 : Towing Package
W–B
* 4 : Except Towing Package 1 2 2
POWER OUTLET
P6
POWER OUTLET
P7
* 5 : 2UZ–FE
* 6 : 5VZ–FE
* 7 : w/ Door Lock Control 2 2
* 8 : w/o Door Lock Control
1 1
B–L(*3)
W–B
W–B
W–B
W–B
B (*4)
W–B
A
J18
W–B
JUNCTION
CONNECTOR
A A A
BATTERY J3 A W–B A J13
W–B
JUNCTION JUNCTION
CONNECTOR CONNECTOR
EA Front left fender IF Left kick panel II Right kick
panel
M
25 TOYOTA TUNDRA
P o w e r S o urc e P ow e r S ea t
1 2 3 4
W–G C C W–G
* 1 : Towing Package
J23 * 2 : Except Towing Package
JUNCTION 1
CONNECTOR
W–G
W–B 2 S8
SHORT
PIN
4 1C
3
2
W–G
30A 2 BI1
POWER
L–W
1 A
J16 A L–W
2 1K JUNCTION
CONNECTOR
A
L3
P16 LUMBAR SUPPORT
POWER SEAT CONTROL SW CONTROL SW
L–W
W–G
(Driver’ s Seat) 1 4 (Driver’ s Seat)
B
FRONT REAR
50A SLIDE RECLINING
UP
UP
VERTICAL VERTICAL
J/B
REAR
REAR
DOWN
DOWN
FRONT
FRONT
1
SLDF SLDR FUP FDWN LUP LDWN RCLF RCLR E
9 6 10 5 7 8 3 2 4 3 1 2
2
L
L
B
R
L–R
B–R
Y–R
Y–G
W–R
W–G
140A ALT(*1)
M OVERALL ELECTRICAL WIRING DIAGRAM
100A ALT(*2)
A
1 BJ1 2 BJ1
A
1
J17
A JUNCTION
2
1 2 1 2 2 1 2 1 CONNECTOR
M M M M
L
POWER SEAT MOTOR POWER SEAT MOTOR POWER SEAT MOTOR POWER SEAT MOTOR
(Driver’ s Seat (Driver’ s Seat (Driver’ s Seat (Driver’ s Seat
P20
W–B
1
B (*2)
B–L(*1)
Control) Control) Control)
M
(Driver’ s Seat
W–B
W–B
2
POWER SEAT MOTOR
BATTERY A A
W–B W–B
B A
J23 A , J24 B
JUNCTION
CONNECTOR IE Left kick
panel
26 TOYOTA TUNDRA
1 2 3 4
L–Y
L–Y
* 2 : Except Towing Package * 6 : INT2 *10 : Bench Seat
L–Y ACC * 3 : w/ INT Time SW Mechanism * 7 : w/ Door Lock Control *11 : Separate Seat, Captain Seat(w/o Power Seat)
* 4 : w/o INT Time SW Mechanism * 8 : w/o Door Lock Control
2 AM1 IG1 4
2 2 1I 6 1E
2
10A DOME
1
W
2 3 1G 3 1E 2 1G 5 1F 3 1F
B–Y
L–Y
C17 C11 A , C12 B , C13 C
B
L
9 A COMBINATION METER 5 B
2003 TOYOTA TUNDRA (EWD491U)
WASHER MOTOR
W2
3
L
2 +B +2 +1 +S EW WF OFF
SEAT BELT
WASHER
M
MIST INT
40A AM1
4
OFF LOW
LOW HIGH
L(*4)
L(*3)
1
L–R
HIGH WASHER 1 A 7 A 2 B 1 C 12 B 8 B 13 B
2 2
SHORT PIN
100A ALT(*2)
140A ALT(*1)
B
WASHER
CONNECTOR
JUNCTION
J10
B
LG–R
23 IA4
ECU<23–3>
From TVIP
W–B
Y–B
P–B
(*7)
WIPER RELAY
BR
UNLOCK WARNING SW
U1
B B
1
1 17 8 7 16 2 11 17 8 7 16 2 11 B
P–B
System<10–1>
See Interior Light
(*8)
1
10 IA4
W–B(*3)
L–W(*3)
Y–L(*3)
L–B(*3)
L–R(*3)
Sensor Assembly<17–4>
From Center Airbag
(*9, *10)
2
2 L–R(*4) L–R(*4)
B
P–B
(*7)
W–B(*4) W–B
LG–R
(*11)
P–B
(*7)
CONNECTOR
JUNCTION
J8
E C
B
3 BI1
L–W(*4) E E
J7
B–L(*1)
L–B(*4) L
B
B (*2)
JUNCTION E C
Y–L(*4) CONNECTOR 1 A (*9)
3 C 2 B (*10)
[WASHER MOTOR]
WASHER LEVEL SENSOR
W2
P–B
(*7)
BUCKLE SW LH
BUCKLE SW LH
B7 C
B7 A ,
3 5 2 1 4 1
CONNECTOR
JUNCTION
A B
J23 A , J24 B
BR
+2 +1 B S E
4 C 2 A (*9)
Relay<20–2><21–2>
From Integration
B
A A 1 B (*10)
BATTERY M 2
(*9, *10)
W4
(*11)
W–B
W–B
W–B
W–B
W–B
W–B
WIPER MOTOR
CONNECTOR
JUNCTION
J13
A A 4 BI1
J3 W–B
JUNCTION
CONNECTOR (*9, *10)
Right kick II IF Left kick EA Front left Left kick IE IH Right kick
panel panel fender panel panel
M
27 TOYOTA TUNDRA
1 2 3 4
L–R * 1 : 5VZ–FE w/ Door Lock Control, 2UZ–FE
* 2 : 5VZ–FE w/o Door Lock Control w/ Daytime Running Light
(*11) * 3 : 5VZ–FE w/o Door Lock Control w/o Daytime Running Light
* 4 : 5VZ–FE w/ Door Lock Control w/ Daytime Running Light, 2UZ–FE w/ Daytime Running Light
W–G
* 5 : 5VZ–FE w/ Door Lock Control w/o Daytime Running Light, 2UZ–FE w/o Daytime Running Light
* 6 : w/ Mirror Heater
9 * 7 : w/o Mirror Heater
ACC 3 L–R L–R 1 1I 2 1K
IA4 * 8 : Towing Package
(*10) (*10) * 9 : Except Towing Package
2 AM1 IG1
W–R(*13) *10 : 2UZ–FE
L–O
(*10)
*11 : 5VZ–FE
W–R(*12) 15A *12 : w/ Door Lock Control
ACC *13 : w/o Door Lock Control
*14 : w/ Wireless Door Lock Control
10A HORN
I23
IGNITION SW F B 2 3 8 IA4
A22
11 1G
JUNCTION
GR A J9
CONNECTOR
JUNCTION
D A (A/T)
CONNECTOR
J21 A , J22 B
1 4 A
GR
(M/T)
17
W–R L–O (A/T)
IA5
(*12) (*10)
W
(*10)
W–R
W–G
REMOTE CONTROL
GR
8 MIRROR SW
2 2 2 B
INTEGRATION RELAY 7
SW
2 2
OPERATION
50A J/B
40A AM1
5A ECU–B
1
1 1
LH RH 12 1N (*2, *4)
2 12 1L (*3, *5) 8 1E
HL HR VL VR M+ E
SELECT SW
5 2 4 3 6 7
B
R
G–R
W–B
LG–R
2
(*2, *4, *5)
A
J10
2 2 G–R A
B
(*3)
(*14)
G–R
JUNCTION
A
CONNECTOR
L–B
Y–B
LG–R
To TVIP ECU<23–4>
SHORT PIN
(*1)
100A ALT(*9)
140A ALT(*8)
B
1
R
L–B
P–B
Y–B
Y–B
LG–R 6 1 1
2 H7 H8
W–B
LG–R
B (*9)
B–L(*8)
3 A 1 A 5 A (*6) 3 A 1 A 5 A (*6) JUNCTION
CONNECTOR
2 B 3 B 1 B (*7) 2 B 3 B 1 B (*7) A A
BATTERY
M M M M
W–B
R8 A ,
R9 A ,
MIRROR LH
MIRROR RH
B
B
IE Left kick
panel
REMOTE CONTROL
REMOTE CONTROL
28 TOYOTA TUNDRA
P ow er S ou rc e R ad io a nd P la y er
1 L–R 2 3 4
(*7) 9
ACC 3 L–R L–R
IA4 * 1 : w/ Door Lock Control * 5 : Except Towing Package
(*6) (* 6)
L–R
(*7)
2 AM1 IG1 * 2 : w/o Door Lock Control * 6 : 2UZ–FE
17 * 3 : Access Cab * 7 : 5VZ–FE
W–R W–R
IA5 * 4 : Towing Package
(*6) (* 2)
W–R 1 1I
W–R
L–R
L–O
(*2)
(*6)
(*6)
(*1) W–R
I23 (*1) C16
CONNECTOR
JUNCTION
W
J21 A , J22 B
R D A 2 3 [COMB. SW]
W–R
(*6)
ACC INTEGRATION CONTROL
AND PANEL
2 2 11 IA5 F B ACC ACC1 EAU AU1 AU2
1 4 13 14 10 12 11
10 1G
2 2 W–R L–O
G–B
R
L
(*1) (*6)
5A 20A
ECU–B RADIO GR
See Engine Control
GR
System<5–2> 5 II1 3 II1 4 II1
R
2003 TOYOTA TUNDRA (EWD491U)
1 1
G–B
R
L
R 1 A , R 2 B , R11 C
2
4 B 3 B RADIO AND PLAYER 6 C 7 C 8 C
B ACC SWG SW1 SW2
W
2
40A AM1
(*3)
(*3)
(*3)
(*3)
LG
W
R
P
Y
L
1
2
2 10 IF4 5 IF4 10 IB4 5 IB4 (*1) 2 BE2 3 BE2 2 BF2 3 BF2
100A ALT(*5)
140A ALT(*4)
LG(*2)
P (* 1)
L (*2)
V (*1)
(*3)
(*3)
(*3)
(*3)
BR
LG
W
1 1
R
L
LG
B–L(*4)
L
B (*5)
LG 2 1 L LG 2 1 L
(*3)
(*3)
(*3)
(*3)
W
R
B
Y
T8 T7
LG
LG
TWEETER RH TWEETER LH
L
L
BATTERY 1 2 1 2 1 2 1 2
F9 F8 R6 R7
FRONT DOOR SPEAKER FRONT DOOR SPEAKER REAR DOOR SPEAKER REAR DOOR SPEAKER
Instrument panel RH LH LH RH
IG
brace RH
M
M OVERALL ELECTRICAL WIRING DIAGRAM
(Cont. next page)
WASHER
See Wiper and
1 A
Washer System<26–3>
MALFUNCTION
INDICATOR LAMP
See Engine Control
8 C
System<5–6><6–3>
A/T OIL TEMP.
10 D
See Electronically Controlled
Transmission and
O/D OFF A/T Indicator System
6 : Except Towing Package
<14–5><15–5>
3 D
4
O2
24 IE1 (*1)
8 IE1 (*2)
5 : Towing Package
12 A
(*8)
1
1 : 2UZ–FE
2 : 5VZ–FE
OIL O6
CONNECTOR
Y–B
*
*
*
*
*
*
*
*
JUNCTION
(*7)
J8
COMBINATION METER
B–R B–R BR BR BR
5 BB1
6 BB1
IH
5 C
C
1
3
FUEL
4 BB1
FUEL
6 C
F10
2
BR
BR
8 B
(*1)
(*2)
FUEL
1 A (*1)
1 B (*2)
Y–R Y–R
13 IE1
10 IE1
6 A
WATER TEMP.
C o m bina tio n M ete r
W3 A , B
3
3 1F
5 B
7 B
See Interior Light System
DOOR 6 B <10–2>
SEAT BELT
B B From Igniter
5 IE1
4 C
ECU<18–4> (*1)
D
9 B
G–O System<10–1><10–2>
From Integration
1 C 13 B
Relay<30–7>
D
CONNECTOR
JUNCTION
System<26–3><26–4>
J9
12 B
P–L P–L
9 IE1
(*1) (*1)
2
(Combination Meter)
VEHICLE SPEED
(*3)
(*4)
LCD
P–L P–L
3 IE2
6 IE3
13 C
SENSOR
(*2) (*2)
2
V2
G–B G–B
25 IE2
4 IE3
2 C
(*2) (*2)
3
B–Y
5 1F
9 A
R–L R–L
B–Y
17 IE1
(*1) (*1)
GAUGE
10A
(*1)
(*2)
B–Y B–Y
7 IE1
2 IE1
8 1F
2 1I
B–Y
IG1 4
ACC
IGNITION SW
29 TOYOTA TUNDRA
1
P ow er S ou rc e
I23
2 AM1
140A ALT(*5)
40A AM1 100A ALT(*6)
BATTERY
W W
2
1
2
10A DOME
SHORT PIN B–L(*5)
L–Y B B (*6)
2
2
2
5 6 7 8
* 1 : 2UZ–FE
* 2 : 5VZ–FE
* 9 : w/ Daytime Running Light
*10 : w/o Daytime Running Light
Light System<11–3>
Hazard Warning
See Turn Signal and
<1–4>
See Charging System
System<7–3><8–3>
See Headlight
System<9–3>
See Illumination
See Electronically Controlled Transmission
and A/T indicator System<14–6><15–6>
2003 TOYOTA TUNDRA (EWD491U)
(*2)
ILLUMINATION
(*1)
HIGH BEAM
TURN RH
TURN LH
VOLT
A/T P
ABS
SRS
CHARGE
4WD(*2)
4HI(*1)
CRUISE
BRAKE
P
L
2
4LO
(*1)
(*1)
(*1)
(*2)
8 A 1 D 10 B 11 B 9 C 4 B 11 A 2 B 7 C 13 A 7 A 2 D 14 B 10 C
G–W
G–W
(*9)
13 1N
W–B
W–B
(*10 M/T)
5 1B 6 1B
R–W
INTEGRATION
RELAY
System<5–6><6–3>
See Cruise Control
<1–4>
See Charging System
<26–3>
Warning System
and Seat Belt
See Key Reminder
<16–2>
See ABS System
<19–4>
See 4WD System
System<9–3>
See Illumination
<17–4>
See SRS System
4 1E
<18–2><19–4>
See 4WD System
1 1N
W–B
R–W
G–W
(*10 M/T)
(*9 A/T)
(*9 M/T)
R–W
R–W
1 1
SW
LEVEL WARNING
BRAKE FLUID
B2
SW(M/T)
PARKING BRAKE
P5
A B
1 J23 A , J24 B
P5 JUNCTION
2 PARKING 2 CONNECTOR
BRAKE A A
W–B
(M/T)
W–B
SW(A/T)
A W–B
J18 A
JUNCTION
W–B
CONNECTOR
W–B
W–B
A A A
18 J3 J13
W–B A
W–B
M
30 TOYOTA TUNDRA (Cont. next page)
P o w er S ou rc e A ir C o nd ition in g
1 2 3 4 W–R(*1)
A
W–G
B
L–Y
C
L–R L–R(*1)
D
(*1)
ACC 3 L–R L–R(*2)
E
(*1)
(*2)
L–Y
W–R
2 AM1 IG1 4 B–Y B–Y B–Y
L–R L–R
2 1I 9 1F E
2 2 B–Y E E
I23 2 J8
IGNITION SW * 1 : 2UZ–FE JUNCTION E
2 2 1
* 2 : 5VZ–FE CONNECTOR
B–Y
B–Y
* 3 : 5VZ–FE A/T
* 4 : 5VZ–FE M/T 10A 5
L–R
* 5 : Towing Package A/C
+
10A GAUGE
* 6 : Except Towing Package
5A ECU–B
10A DOME
W
13 IA4
W–G
1 1 2
A15
5 1E 2 6 2
B6
A13
CONTROL
AIR INLET
W–L
L–R
L–R
B–Y
SERVO MOTOR
JUNCTION 7 1 1 2
DEFROSTER SW
B
R
A/C THERMISTOR
CONNECTOR
C 1
B
(*2)
(*2)
B–L
B–L
B–Y
W–L
B–W
W–G
B4
BLOWER M 12 B 9 B 20 A 10 A 4 B 13 A 15 A
2 2 2 2
B–Y
MOTOR
B L IN E IG REC FRS
2
2 2
2 2 2
I24 A , I25 B
5 2 INTEGRATION CONTROL AND PANEL
L–B
4 HTR W–B AIND(*1) A/CM(*1)
50A J/B
40A AM1
50A HTR
RELAY ACT(*2) AC1(*2) GND MGC
1 1 1 B5 18 A 19 A 1 B 8 A
3 1 BLOWER RESISTOR
L–B
2 2 2 2
L–B
L–Y
(*1)
(*2)
L–R
W–L
3 2
16 IE2 (*3)
L–R
Y–R
100A ALT(*6)
140A ALT(*5)
SHORT PIN
4 IE1 8 IE3 (*4)
1 1
L–R
L–Y
L–R
L–B
(*1)
(*2)
L–R
W–L
W–B
4 8
2 19 IA4 LO M1 M2 H1
5 3 A (*1)
From Engine Control
1 B (*2)
Module<5–9><6–10>
Y–R 3
W–B
B (*6)
B–L(*5)
1
A W–B
J18
JUNCTION
CLUTCH
B6
W–B
CONNECTOR
BLOWER SW
W–B
A A A
BATTERY
A/C MAGNETIC
W–B
CONNECTOR CONNECTOR A2 B , A3 A
EA Front left fender IF Left kick panel Right kick panel II A/C MAGNETIC CLUTCH
30 TOYOTA TUNDRA (Cont’ d)
W–R(*1) 5 W–R 6 7 8
A
(*1) * 1 : 2UZ–FE
W–G
B * 2 : 5VZ–FE
L–Y * 7 : w/ Door Lock Control
C To Combination * 8 : w/o Door Lock Control
W–G
9 17 IA5 Meter<29–2> * 9 : w/ Daytime Running Light
L–R(*1) L–R
D IA4 *10 : w/o Daytime Running Light
(*1) 2 1K
L–R(*2) L–O W–R
E
(*1) (*7)
W–R
L–R
(*1)
(*8)
G–O
1 1I 6 1E W–R 5A
(*7) CARGO
3 2 D A LP
J21 A , J22 B
11 1N (*9)
A22 JUNCTION
15A ACC CUT 11 1L (*10)
8 IA4 CONNECTOR
ACC RELAY
<5–15>
From Engine Control Module
F B
5
System<28–3>
See Radio and Player
4 1
Flasher<11–2>
To Turn Signal
W–R
L–O
(*1)
(*7)
10 1G 4 1F INTEGRATION
RELAY
L–Y
2003 TOYOTA TUNDRA (EWD491U)
11
System<5–2>
See Engine Control
B A
GR J23 A , J24 B 5 1N (*9)
JUNCTION 10 1L (*10) 10 1H
CONNECTOR
C B
G–R
R–B
W–R
(*1)
L
21 A 13 B 5 B L–Y 17 A 14 B 12 A 2 1D
A/C ACC B B1 ACC1 +B
I24 A , I25 B
INTEGRATION CONTROL AND PANEL
IG+ AC+2 BKLD H–L 2–4 IND1 IND2 GND1 PIND ILL+ ILL– IL–1 L 2 1H 7 1A
6 A 11 B 16 A 4 A 5 A 2 B 3 B 1 A 3 A 7 A 8 B 7 B 9 A
R–B
R–B
L–W
B–R
(*2)
(*2)
O
BR–Y
W–B
G–Y
Y–B
R–B
(*1)
(*1)
(*1)
(*1)
3
R
P
H10
CARGO LIGHT
[HIGH MOUNTED
SENSOR AND BUCKLE SW RH
OCCUPANT DETECTION
SEAT BELT WARNING
S5
W–B
W–L
(*2)
(*2)
O
<18–3><18–4>
From 4WD Control ECU
<18–2>
To Combination Meter
System<9–3>
See Illumination
1 BUCKLE SW
A/C DUAL PRESSURE SW
A1
B–L
2 1A
To Center 8 1J
Airbag
Sensor
Assembly
W–B
2
<17–3>
W–B
A
J3
JUNCTION
CONNECTOR
IH Right kick panel Left kick panel IF
M
31 TOYOTA TUNDRA
1 2 3 4
(*1)
B–Y
B–R
B–W
Flasher<11–4>
SW<13–3>
SW<13–3>
Relay<9–4>
ACC
From Integration
1 IA4 21 IA4
2 AM1 IG1 4 B–Y B–W
(*1)
2 1I
(*1)
(*1)
(*1)
2 2
B–Y
B–R
G–B
G–Y
G–W
G–W
I23
IGNITION SW
3 2 2 4 5 8 9 3 1
<12–3>
(*1)
(*1)
(*1)
B–Y
+B STOP TAIL STIN LTIN RTIN +B
B–R
L–W
B–W
TOW TAIL T9
TOWING
RELAY
BRK GND LTOT RTOT GND CONVERTER
10A GAUGE
5 1 1 3 O5 4 2 6
OPTION
From Back–Up Light Relay
2 2 2 2 2 CONNECTOR
L
R
5 1E 2 2
BR
BR
(*1)
(*1)
W–B
2 2 2 2
5 BB2 6 BB2
(*1)
B–Y
B
C C
R–B
J1 J8
Y
R
BR
(*1)
40A AM1
JUNCTION 1 BB2 JUNCTION
CONNECTOR 12 IA4 20 IA4 CONNECTOR
L
2 2
G
BR
(*1)
(*1)
(*1)
(*1)
B–Y
R–B
L–W
Y
(*1)
W–B
Y(*2)
R(*1)
G(*2)
BR(*1)
140A ALT(*1) 2 2
100A ALT(*2) 4 BB2 4 A 3 A 5 A (*1)
2 3 3 B 4 B (*2) A B
30A TOWING
1 1 B/UP STTL STTR T6 A , B
JUNCTION
SUB BATT
RELAY TRAILER
CONNECTOR
1 5 7 A 1 A 2 A 6 A (*1)
2
2 B 1 B (*2)
2 2
[COMB. SW]<9–1>
To Light Control SW
L
B
W
(*1)
(*1)
W–B
G(*1)
L
BR(*2)
(*1)
(*1)
W–B
B (*2)
C
B–L(*1)
2 BK2 4 BK1 1 BK2 2 BK1
J2
JUNCTION
CONNECTOR
L
B
G
W
(*1)
(*1)
2 BB2
(*1)
W–B
BATTERY
A
J18
JUNCTION
B
(*1)
CONNECTOR 4
L
A IA4
(*1)
BR
(*1)
(*1)
W–B
W–B
W–B
270
2003 TOYOTA TUNDRA (EWD491U)
[A] : System Title [F] : Junction Block (The number in the circle is the
J/B No. and the connector code is shown beside
[B] : Indicates the wiring color.
it). Junction Blocks are shaded to clearly
Wire colors are indicated by an alphabetical code. separate them from other parts.
B = Black W = White BR = Brown
,,,,
L = Blue V = Violet SB = Sky Blue Example:
R = Red O = Orange LG = Light Green ,,,,
,,,,3C indicates
P = Pink Y = Yellow GR = Gray ,,,,
,,,,
that it is inside
Junction Block
G = Green
,,,,No.3
The first letter indicates the basic wire color and the ,,,,
second letter indicates the color of the stripe.
Example: L–Y
M
272
Fog Light (w/o Daytime Running Light) . . . . . . . . . . . . . . . . . . . . . . . . . 8–3 Trailer Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31–2
Headlight (w/ Daytime Running Light) . . . . . . . . . . . . . . . . . . . . . . . . . . 7–2 Turn Signal and Hazard Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . 11–2